With regard to your inquiry into ford bronco engine failures IT IS NOT A ISOLATED PROBLEM ! My 2016 has the same engine. At 3000 miles it almost shook off my truck while driving. Ford had to replace entire engine At 30,000 mile mark engine failed again and ford had to replace half the engine These engines are dangerous junk

- Shavertown , PA, USA

The contact owns a 2016 Ford F-150. The contact received notification of NHTSA Campaign Number: 18V894000 (Engine) however, the part to do the recall repair was not yet available. The dealer was made aware of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. Parts distribution disconnect.

- Indianapolis, IN, USA

I was driving vehicle to work. Going approximately 70 mph, the truck suddenly lost the ability to accelerate and starts running very rough, like it lost a cylinder. Then the collision warning comes on the dash and advanced trac icon and then the manual icon with the wrench that says check manual. I coast down the hill from the far left lane to the slow lane and take the first exit off the freeway and pull to the side of road. Shut the vehicle off, wait 30 seconds, try again starts right up and acts like no problem. Happened three times since. Same thing every time

- Petaluma, CA, USA

The contact owns a 2016 Ford F-150. The contact stated while driving approximately 35 MPH and towing a 5th wheel trailer, the vehicle lost motive power. The hill descent warning light was illuminated. The contact was able to pull over off the highway safely. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 40,000.

- Blairsden Graeagle, CA, USA

The engine has suddenly started to shake badly and shut off at stops. I-??ve had it looked at by ford and they found no issues. I-??ve asked around and this is very common. Please help

- Richlands , NC, USA

Both exhaust manifolds are warped and snapped the rear studs off. Occasionally lose power when pushing the accelerator. It has been going for awhile now. I didn-??t know what it was until I saw other people were having the same problems.

- Amarillo , TX, USA

1st incident - Sudden loss of power when accelerating onto the highway, had to make emergency maneuver into brake down lane. No warning lamps until issue occurred, than every warning light came on! 2nd incident - Sudden loss of power when going to pass a car, once again had to make emergency maneuver and ended up cutting car off I was passing. No warning lamps until issue occurred, than every warning light came on!

- West Brookfield, MA, USA

What component or system failed or malfunctioned, and is it available for inspection upon request" ENGINE/OIL LEAK How was your safety or the safety of others put at risk? IF THE OIL LEAKS OUT ENOUGH WHILE DRIVING THE MOTOR WILL CEASE UP, AND CAN CAUSE AN ACCIDENT. Has the problem been reproduced or confirmed by a dealer or independent service center? YES Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? YES Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear" NO, IT APPEARED ABOUT 2 MONTHS AGO. I THOUGHT IT WAS JUST A BAD OIL CHANGE, BUT IT HAS ACCURED 2 MORE OIL CHANGES SINCE.

- Rutledge, TN, USA

The exhaust manifold warps causing a leak in the manifold in the 3.5 Ecoboost engines. After research, it is a common problem with many Ford owners. This problem causes an emission leak, power loss, and distinct noise. I have not had this confirmed by a dealer as of yet, but it is a very common problem. My truck started having this problem around 45,000 miles. No warning lights or messages have been displayed.

- Santa Ana, CA, USA

Truck engine is stalling out while driving and coming to a stop. The engine turns off, but all electrical power remains. This has occurred six times in a two month period with the first occurrence happening on February 1, 2022. An engine stalling out while the truck is on the road way is a dangerous situation whether stopped at a red light or while in motion, but especially so if it were to occur while driving at high speeds on a highway. There were no warning messages or indication lights prior or subsequent to the occurrences. The truck was brought to the local Ford dealership on February 28, 2022. The service department at the dealership was unable to diagnose the issue because the computer did not provide them with a diagnosis. The truck is being brought back to the dealership for a second evaluation on March 6, 2022.

- Tallahassee, FL, USA

The cam phasers fail intermittently causing shuttering/stalling randomly while driving. A large amount of people have had this same issue. Truck will intermittently rev up while in gear. If you're not on the brake, you will move forward/backward. Tons of check engine lights etc

- Oshkosh, WI, USA

My wife and I were traveling to our home in the truck. When preparing to turn left off the main road, I noticed that the turn signals were not working, requiring me to go to the right off the side of the road, as there was heavy traffic behind us. While on the side of the road, I tried the windshield wipers, window sprayer, and turn signals. None were working. I turned the engine off and then restarted the truck, and limped home. After getting home, the truck was parked while looking for a mechanic to fix whatever was wrong with it. It was recommended to me that the "Wiper Multi-switch" be replaced. This did not eliminate the problem. I then arranged for the Ford Dealer, Woody Anderson Ford, to take the truck in and fix it. The Dealer says the truck has had a major electrical failure and doubts that can be fixed.

- Huntsville, AL, USA

3.5L Ecoboost - Warped/broken exhaust manifold studs that is due to extreme heat produced by the twin turbos. There's no warning lights and by the time some symptoms starts developing, studs are probably broken or warped which causes a leakage prevents the manifold from properly dissipating the heat/exhaust which can possibly cause additional heat to be repelled back to the engine. Early signs could be a minor to moderate chirping sound that might radiate somewhere around the driver or front passenger lower console when accelerating while driving.

- Las Vegas, NV, USA

My local ford dealer found during a service request that the Driver-??s side exhaust manifold has warped and broken studs for the manifold, causing an exhaust leak that poses a potential safety issue from gases leaking into the passenger cabin and creating a considerable amount of noise, as well as some performance loss.

- Augusta, GA, USA

Engine block exploded with less than 100,000 miles while moving forward after a stop sign, dropped all water through a side of an engine, lost power unable to move from road blocking traffic. Once token into a shop, melted metal was found on the engine cover, and a big hole was found on the engine head. A lot of engine smoke (CO2) was released and got into the cabin getting me sick and feeling dizzy for a whole week

- Alpine, TX, USA

While the engine is idling, whether in park, drive, or reverse the engine intermittently loses RPM and shuts off. The dealer claims they can not duplicate the issue. No messages appear other then the car is on battery power. This has been going on for about the last 20000 miles.

- Marietta, GA, USA

Several recalls on the same make and model as mine. Why is my truck not covered under recall. These issue should not happen to a vehicle 5 years old with less the. 85k miles and all work has been completed at lithos ford of boise where I purchased it.

- Boise, ID, USA

After driving at highway speed for approx 1 hour, came to stop at red light. Vehicle idles rough, dropping to 250-300 rpm, then stalled in traffic, requiring restart. Third time this issue has occurred, all at stop signs or red lights.

- Bucksport, ME, USA

Saw a small puddle under passenger side engine, had the work mechanic look at it and he said the turbo cooling line was leaking. Car has only 45,000 miles on it. Took car to own mechanic and he verified leak, we decided to replace other side on left side of engine as there a bit of weeping, while they were replacing the parts, he noticed my water pump was leaking and I told him to replace it as we don't need any issues. After all work was performed, the bill was close to $2, 700. The mechanic said with the low mileage on the truck, it was way too soon for any of these parts to fail.

- Saugus, CA, USA

Exhaust manifold faulty at 80,000 miles.. Engine broke at 99,000

- Alpine, TX, USA