The problematic 10r transmission failed stalling in highway traffic this is a very serious issue with fords transmission and it needs to be investigated

- Rushville, MO, USA

The contact owns a 2018 Ford F-150. The contact stated that while driving at various speeds, the vehicle unintendedly downshifted and jerk upon depression of the accelerator pedal. There was no warning light illuminated. The vehicle was taken back to the independent mechanic; however, the mechanic unable to determine the cause of the failure. The vehicle was then taken to a dealer and the throttle body was replaced; however, the failure persisted. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 88,000.

- Washington, DC, USA

Steel bolts holding the face of the transfer case which is aluminum is causing a corrosion response between the two metals. Transfer case is severely pitted and flaking apart. It crumbles to the touch around some bolts.

- Burlington, CT, USA

Within the first year the transmission and 4 wheel drive(4WD) appeared to be slipping and making a loud clunk when shifting from 2WD to 4WDA or 4W High. I took it to the dealer twice and they could not duplicate the problem even after I very specifically told them how to reproduce it. Approx. a year later the noise became louder and more frequent. The dealer could not duplicate it and told me, "...drive it until it breaks." The noise and slipping have continued and now are very prevalent in automatic shifting in almost every gear while in 2WH. I only have 26,200 very easy miles on the truck. The dealer's tech rode with me and I duplicated the noise and slipping. The tech said it was "normal" for the vacuum driven spindles in the front axel to make this noise as it goes from 2-4WD. My truck is out of warranty and is far worse as a result of the dealers failure to address the issue. Mike White Ford Coeur D Alene, Idaho is the dealership.

- Coeur D Alene, ID, USA

The contact owns a 2018 Ford F-150. The contact stated while driving 50 MPH, the transmission seized. The check engine warning light was illuminated. The vehicle was taken to the dealer, where the failure could not be duplicated. The vehicle was not diagnosed nor repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 75,809.

- Easton, PA, USA

Transmission has been repaired by Ford Dealer multiple times without fixing the hard shifting issues that run common on this vehicle. Ford dealer states that nothing is wrong even after the truck has been in the shop multiple times for the same issue.

- Riverton, UT, USA

The contact owns a 2018 Ford F-150. The contact stated that upon starting the vehicle, an abnormal clicking sound was coming from the vehicle without warning. The contact had initially taken the vehicle to two dealers who were both unable to determine the cause of the failure. The vehicle was then taken to Downtown Ford Sacramento (1535 Howe Ave, Sacramento, CA 95825) where a diagnostic test was performed, and an oil leak was discovered coming from the front valve cover of the engine. The mechanic also discovered a defective Variable Camshaft Timing (VCT). The manufacturer was notified of the failure but offered no assistance. The vehicle was not repaired. The failure mileage was approximately 75,000.

- Rocklin, CA, USA

Erratic shifting with transmission seeming to lock up causing me to near crash incidents.

- Milton, TN, USA

I had the truck in for normal repairs and while there they reset the shift learning program because my truck was hesitating when shifting gears. Since then the problem has gotten worse and while I was driving on the highway at 70 mph the truck kept shifting from 10 to 1 gear. When pulling onto the road in traffic from a stop the car also would not shift and sounded like it was stuck in neutral almost resulting in me getting hit from behind. Now the truck seems to be stuck in 6th gear. The gear light came on while I was driving and the both of my temperature gauges were super high. The transmission temp was 267-270 degrees and the other temp gauge read at 230 degrees. When I finally was able to stop and park the truck the cooling fan was running extremely high.

- Matawan, NJ, USA

The contact owns a 2018 Ford F-150. The contact stated while driving 20 MPH and making a stop, the vehicle lunged forward without warning. The vehicle was taken to the dealer and the dealer stated that no failure was found. The manufacturer was contacted, and the manufacturer stated the vehicle needed to be diagnosed and repaired. The failure mileage was 8,000.

- Manassas, VA, USA

Transmission would jerk in and out of 9th gear and then go from 9th gear to 1st while driving on the highway. Transmission shop reported it as a drum issue. Also said they had 3 other Ford trucks with the same transmission having the same exact issues.

- Rowlett, TX, USA

cam phasers are rattling very hard. It is a known recall with ford that for some reason is not showing under my VIN even through the recall is for the same year model and engine.

- North Las Vegas, NV, USA

The 10 speed transmission on my pickup is failing. Dropping out of gear, losing power, failing when climbing a slight hill, Loud clanking and jerking in and out of gear. Black transmission fluid. Ford dealers cannot deal with it and my dealer that does the regular service cannot schedule me for diagnostics for over a month. I finally have an appointment with an out of town dealer two week out. In the meantime, my work pickup is nearly useless.

- Fresno, CA, USA

1. Vehicle accelerates on its own when shifting into drive and releasing the brake. 2.Vehicle lunges forward when the transmission is shifting from 1st to 2nd gear or 2nd to 3rd gear. This occurs in the lower gears only. 3. Doesn't shift into the next higher gear and the RPM's are running high which should activate a gear change but it doesn't occur. 4. The RPM's are increasing but there is very little movement of the vehicle. It feels like the transmission is slipping. 5. These problems are not consistent.It may occur once a week or 3 times a week. These problems go away if I stop moving and return the vehicle to the PARK position and they have never occurred over 40 MPH.

- Shawano, WI, USA

I noticed the truck began rattling in the mornings or when the engine was cold. I was driving on the freeway when it started losing power and the check engine light was flashing. It had been misfiring and progressively got worse. I managed to get off the freeway in time to shut the vehicle off. The vehicle has gone through diagnostic testing at a Ford dealership. The service tech informed me that the cam phasers needed to be replaced because they were sticking and the computer needed to be reprogrammed. The computer was then reprogrammed and I drove the vehicle home, 5 miles away, and it would not start again. After some research, I was made aware that the CAM PHASERS are a KNOWN ISSUE on the Ford F 150 Raptor through the Customer Satisfaction Program no. 21N03-initiated by NHTSA. This replacement covers the 2017-2020 F150 Raptor if manufactured at the Dearborn plant between March 2016-Nov 2019. I have confirmed the vehicle was built at that location in the time period mentioned. I brought this up to the tech, service manager at the Ford Dealership as well as Ford Customer Relationship Center and I was told numerous times that the VIN no. does not qualify. This is a safety issue, recognized by Ford, and should be covered. I was told to contact the NHTSA to seek qualification of my vehicle.

- Concord, CA, USA

The contact owns a 2018 Ford F-150. The contact stated while coming to a stop, the vehicle made abnormal sounds as if the engine was revving, or the transmission was attempting to shift into another gear while the brake pedal was being depressed to slow down the vehicle. The contact stated that the failure occurred intermittently. The contact stated that after the initial start-up, the transmission was slightly hesitating before shifting into gear. The vehicle had been taken to a certified mechanic but was not diagnosed. The vehicle had not been repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 78,000.

- Florence, SC, USA

Transmission slips, changes gears. Auto start slams into forward gear. Ten speed transmission not safe to drive. Taking truck to dealership for two years with no resolution. Phaser start up rattle. Taking it to dealership for two years with no resolution.

- Old Town, FL, USA

I was pulling out into 4 lanes of traffic and the truck shut off. Dash had message "Auto StartStop Shift to P, then Restart Engine". I am stuck blocking 4 lanes of traffic on a busy street with cars coming fast. I put in park and restarted the engine. It died and gave the same message 4 more times. Finally revved the engine way up and was able to move the truck. It died twice while approaching the next stop sign even though Auto Start/Stop was disabled. Revved engine and was able to make it to the Ford dealer who had no one available to assess the problem. Several people suggested replacing the battery. I put in a new battery and reset the battery monitoring system. The problem still persists. Slamming a dead pickup into park in the middle of 4 lanes of oncoming traffic is most definitely a safety issue. I see that many Ford owners have experienced the same problem in a variety of Ford products. I don't think it is a battery issue since the engine should be able to run off the alternator and it still occurs after replacing the battery. I don't think it is an Auto Start/Stop issue since it occurred with AS/S activated or deactivated. In almost all cases the engine is warmed up and in the one instance I had driven the truck 22 miles before the failure occurred. In almost every case, I am gently accelerating from a stop or slowing down for a stop. It has failed in both Drive and Reverse. I get no other warning lights or messages.

- Humboldt, IA, USA

The contact owns a 2018 Ford F-150. The contact stated while driving at high speeds, the transmission experienced rough and erratic shifting while switching gears. Additionally, the transmission was slipping while driving. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 100,000.

- Grahamsville, NY, USA

My vehicle shakes during shifts or has extremely hard shifts regardless of acceleration demands. I have also had the vehicle completely drop out of gear during both acceleration and with the cruse control set. I have had the vehicle either lock into to high of a gear or refuse to engage into gear while stopped and stop signs and red lights. I have had both the ECU and TCU reflashed multiple times and this issue continues.

- Moncks Corner, SC, USA