My truck will not update its internal software that controls everything from windows to ABS braking system. My truck has numerous pending updates, verified by my dealer and FMCO update section, that are not being sent to my truck. The updates are there for a reason, to improve and to prevent issues. I asked my dealer to do them, they said it would cost $1500 to do it since they would not install over the air as they should. I contacted Ford on 9/12/25 and they refused to assist by either paying the dealer and or by using my Ford ESP warranty. My safety is at risk because these updates address transmission issues, braking issues, electical issues etc all that could fail and cause an accident. Add these failure to update with the exisisting fuel pump problem and the truck is a serious problem. I am told by Ford that my updates are "stuck" and that there is nothing that they can assist with and I must take to a dealer and pay for the updates that others get for free. But, should there ever be a "recall" for my trucks failure to update, I can apply for a refund. I have about 12 different updates that will not download to my truck. In the history of the truck, this is not the first time it would not download updates. Shortly after it was built it was taken to Ford and a "forced update for the Bluecruise technology" had to be done. Critical software updates to the trucks main computer that do not initiate is not acceptable and a danger to this truck! Thank You!

- Barker, TX, USA

Truck has been at Ford dealership since July 9th for this recall. After updating the computer as mentioned in the recall, a -??trailer brake fault-?? was displayed and we were left with no trailer brakes while towing our camper. It has beyond a -??reasonable amount of time-?? to get this safety issue fixed. Compaign recall number: 25S15/25V132

- Shawnee, KS, USA

On Sunday, [XXX], I was driving on a state highway in my 21 Ford F150 FX4 with my family. 67mph, 73 degrees sunny outside. The front portion of my moonroof/sunroof exploded, shooting glass shards internally all over my truck/passengers and externally into the bed of my truck, and into the boat I was towing. Multiple people had glass shards embedded in their skin. There were no other vehicles nearby, and there was no prior damage to the sunroof/moonroof of the vehicle. The truck gave no warning or signs of malfunction prior to the event. The sunroof was closed, and all windows in the vehicle were closed. On Monday morning ([XXX]), I took my truck to the local Ford service center, and they inspected it, shocked at the results. They filed a claim that Ford denied because the windows are not covered by my extended warranty. They wanted to charge me $ 4,000 for the repair/replacement of the glass and track. I have been on the phone with Ford Protection and Ford Customer Service (Aug 6th, 2025), trying to get something resolved, and Ford continues to deny responsibility. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

- Hailey, ID, USA

About 1 hour into a commute, I attempted to connect to a call while using the Car Play function of the SYNC system. Upon connection, the speakers blasted as loud as they could possibly go, a terrible pulsing static sounds that scared me and the passenger and almost caused us to have an accident. The volume knob was indicating 0 and would not move and I could not lower the volume of the terrible sound. I pulled over and tried to restart the car a few times, but the sound would not stop until I left the car off for about 10 minutes. I've not connected my phone via Bluetooth or Car Play since for fear that the sound may return when I am not expecting it, startle me and cause an accident. Though I am not certain of the cause. After about 10 minutes of the sound, I also noticed that the speakers were getting hot and I could smell the electronics or wiring overheating. I have a video of the sound but the dealer could not replicate it.

- Huntingdon Valley, PA, USA

A few months ago, my 2021 F150 started sending me repeating dashboard messages that there's a front camera fault and service is requested followed up with a message about how the pre-collision assist is not available. It's bad enough that this is a problem on a late model vehicle, but my real gripe is that the message repeats over and over non-stop, with a repeating chime to go along with it. It is a terrible distraction for a feature that I've never needed in a vehicle. I asked the Ford dealership about this issue, they said that it would be several thousand dollars to replace and calibrate. So now I'm stuck with a truck that chimes and flashes messages, over and over, every time I drive it. I can provide video evidence of the issue.

- Ocala, FL, USA

Rear view camera and the 360 camera does not work at all on my 2021 Ford F-150 It says return to dealership for repair

- Redford Charter Township, MI, USA

What component or system failed or malfunctioned, and is it available for inspection upon request" -The electrical system malfunctioned causing a complete system failure and shutdown of the vehicle. The vehicle came to a sudden stop in an intersection and could not be moved. How was your safety or the safety of others put at risk? -The vehicle instantly died going through an intersection causing the steering column to lock up, the parking brake to engage and transmission to remain in drive while the vehicle was stopped without any power. This was a sudden and abrupt stop where all control over the vehicle was lost, and I came to an immediate stop in the middle of an intersection. The vehicle would not restart. I could not disengage the parking brake to move the vehicle out of the intersection due to the complete loss of power. The transmission would not shift into Neutral due to the complete loss of power. The hazard lights would not turn on due to the complete loss of power. If this happened on the interstate, I would have very likely been in a serious life threatening /taking accident. This is as big of a near miss that I can think of, and only because it happened on a neighborhood street when no other vehicles were approaching from in front or behind. This is a major safety issue. Has the problem been reproduced or confirmed by a dealer or independent service center? -The vehicle is currently at the dealer for a diagnostic review. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? -in process at the ford dealership Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear" -the vehicle had been running for 30-45 minutes prior to this happening without any warning lights / symptoms.

- Richmond, VA, USA

The rear axle hub bolt on my 2021 Ford F-150 PowerBoost failed to meet design safety standards and is subject to Recall 23S65. The vehicle is currently at a Ford dealership and is available for inspection upon request. My safety was put at risk because the bolt can shear off without warning, causing the rear axle shaft to disengage. This can result in sudden loss of propulsion or vehicle rollaway, especially if parked on an incline. Ford has acknowledged this risk but has not made a final repair available for PowerBoost models. I was not offered a loaner, and I cannot confirm if the vehicle is safe to drive. The problem has been confirmed by the dealership. They told me they are unable to perform even the interim repair until at least July 22 and that there is no ETA at all for the final fix specific to hybrid (PowerBoost) models. The vehicle was inspected by a Ford dealer but not by Ford Motor Company representatives directly. Ford customer service has failed to provide any meaningful support or confirmation of safety. There were no warning lamps or messages prior to the recall. Ford states the failure may occur without symptoms, which makes the defect more dangerous. I have not personally experienced a failure yet, but I'm being asked to either drive the vehicle in this condition or go without transportation indefinitely.

- Weirton, WV, USA

My gear shifter was sticking, making hard to shift gears. I had to pay $1100. 00 dollars to get it fixed. The truck has only 37,000 miles. This seems like a defect not a random component gone bad.

- Oceanside , CA, USA

My transmission has failed and is slipping it's jolting and has cling sound. The rpms indicator fluctuates. Sometimes stays on 10 speed.

- Phoenix, AZ, USA

The side rails that come out when door is opened to assist with getting inside the truck does not work properly. It has come out and will not go back in. The door is closed and I have to drive the truck with the rails hanging down. That is a hazard.

- Crystal Spgs, MS, USA

Since my truck was brand new, the infotainment screen very often blacks out so that I can not see navigation, back up camera, radio, etc. It keeps resetting itself until it comes back on. A couple of times when I brought it in for service I asked them to check it out and it was always "Seems to be working fine". Today I backed into a sign as the back up camera was frozen and I did not notice that it was not real time. After I hit the sign, the screen went black and then the Ford insigna came up and it repeated 3 times and then everything was fine. Ford service has never been able to fix it as the don't see it when they start the vehicle. I will start taking videos with my phone. Anyway now that the extended warranty just ran out, it is getting worse where it happens almost all the time. I talked to some friends and they tell me they have the same issue so you need to be aware that this dangerous situation might be a common problem.

- Ellijay, GA, USA

The step bar that come out whenever a door opens ro assist with getting inside the truck does not come out everytime. Sometime the bar will come down once door is open and remain down when the door closes. The bar is supposed to go ba k in once the door is closed. This happens several times in a week.

- Crystal Spgs, MS, USA

I was driving my 62000 miles truck on the highway while trying to pass another car which was driving slower, I was at a speed close to 60mph, the engine ran at 5000 and I lost power, a truck just behind me has to swerve to avoid me. No warning lamp was on. No accident occurred hopefully. Went to the dealership and they said that the issue was caused by a defective transmission. Ford had denied to pay for the repair or replacement as the warranty is a only covering the first 60000 miles.

- Houston, TX, USA

I drove approx 50 miles. Parked, Return to truck approx 45 mins later and the battery was DEAD. No turn over at all.Called AAA purchased new battery which was installed roadside in a parking lot. Upon starting the engine I noticed the ac was not blowing and hot air only if it did. I took vehicle to Mac Maik Ford. I was told the ac was in need of new parts and $FREON$ " The repair was approx $4500 then add freon fee. I declined. Returned to Gullo Ford where I purchased truck and I was told it would take up to a week or more to leave it for just evaluation. They offered a rental vehicle for $65/ day.i was not going to pay$800 In rental fees to wait for an evaluation not even repair?! I returned home in the hot truck and stopped by the private garage in neighborhood.RUSTYS.They kept it half a day&said upon investigation numerous complaints were filed for the same situation.Rusty stated he would order the part and be completed in abt 3-4 days max>.OK, order parts. I get in the truck after the small independent garage guys went over it in 1/2 a day & THE AC WAS WORKING.I again refused to leave it at Rustys garage. He said he would order the part because site stated numerous ppl had the same thing I had had.battery dying and a/c malfunction combo. IF I HAD NOT BEEN INFORMED OF THE RECALL POTENTIAL OF THE TYPE OF REOCCURRING INCIDENT ON VEHICLES LIKE MINE I WOULD HAVE BEEN RIPPED OFF FOR THOUSANDS!! Rusty ordered the part but kept part b/c my ac is good but tapping the battery" 3 days after his diagnosis being different from the dealers my a/c is still witking..However, The potential remains high for ac failure at this point to reoccur.There is obviously a malfunction in the a/c that kills the battery. I AM NOT THE ONLY PERSON WITH THIS ISSUE. This warrants a recall on whatever it is that drains the battery and kills the a/c function and lets the dealers profit! Please address & recall. Bust the dealers who want THOUSANDS TO FIX THIS TOO! Recall the ripoff...

- Houston, TX, USA

Trucks been in to Ford for repairs 38 times for force motor shuts down while driving. Ford wasn-??t able to duplicate so they kept blowing me off. Finally morries of Okemos actually drove truck 45 minutes like I requested because it only shuts down after truck warms up. They have got it to finally shut down and have realized the panic of not being able to start back up until it-??s in park and how dangerous it is to be driving 70 on highway and if you break it does force motor shut down. Ford refuses buy back and vehicles not safe to drive. They still have no answers. At this point I-??ve went 245 days without a vehicle while being in and out of shop. Mine isn-??t the only one out there. There telling people if they can-??t duplicate when they drive it they can-??t fix it. Problem is these dealerships aren-??t driving consecutive enough to fix it. Thankfully mirrors did thinking I was crazy and dealership says they have never seen this actually happen. Just from talking I know several people with same issue.

- Perry, MI, USA

Had ac on on the way out of town when the air from the vents smelled like mold and mildew and the smell is not healthy for any human beings and the ac drain has no elbow on it witch is the cause of water getting back into the system the smell made me sick and called ford and was told I would have to pay for it since it was pass 3 years truck has 29k miles on it should not be making that smell at so little miles it is a health Hazzard

- Fortmorgan , CO, USA

The plastic clips that hold the keypad on the driver-??s side door to the truck have failed allowing access to the trucks wiring and potentially gaining entry to the truck. Concerned with break-ins

- Barrington, NH, USA

Ford stated a solution to this would be available Q1 2025, but has not provided one. They had already pushed this back once before. THE WHEEL END HUB BOLT IN THE REAR AXLE MAY BECOME LOOSE OR BREAK. CONTINUED DRIVING WITH A BROKEN BOLT MAY LEAD TO WEAR WITHIN THE AXLE AND DAMAGE THE AXLE HUB SPLINES. THIS MAY INITIALLY RESULT IN A CLICKING NOISE AS THE BOLT BECOMES LOOSE AND A RATTLE NOISE FROM THE WHEEL CAP IF THE BOLT BREAKS. VEHICLES WITH DAMAGED AXLE HUB SPLINES MAY ROLL IN PARK WITHOUT THE PARKING BRAKE APPLIED, OR, ALTERNATIVELY, LOSE DRIVE POWER, BOTH OF WHICH MAY INCREASE THE RISK OF INJURY OR A CRASH.

- Powell, OH, USA

I was driving to in the morning and my entire rear window randomly shattered and glass flew everywhere in my truck and on me in the drivers seat.

- Fort Wayne , IN, USA