2022 Ford F-150. The vehicle displays a warning message that reads, "Trailer Disconnected" continuously. It comes on as soon as the engine is started and comes back on as quickly as I can press the "OK" button to make it go away. I have taken the truck to the dealer for repairs four times so far and it still comes back. I have paid to have the trailer break control module reprogrammed as well as having a new one installed. The Ford web site lists this as a recall for the '22 F-150 but not for my specific VIN so it would appear the problem is larger than they know. Here is the link to Ford's description of the recall: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

- Spokane Valley, WA, USA

I bought a used Ford f-150 from Toyota used care dealership on [XXX]. On [XXX] while vehicle was being driven on [XXX], north of Santa Clarita, on the way down to San Diego. I was in the backseat, my friend who was the driver notified me. That we had to pull over and check because he was noticing smoke, then we pulled over and the truck was leaking a fluid that was on fire for about 20 minutes. We had exited the vehicle, called 911, the fire then stopped after about 20 minutes. The fire department came and then put out a small fire within the truck. We then had to wait on the side of the rode for 5 hours waiting for a tow truck to pull the truck. I got the truck towed to a ford service center because the truck still had new vehicle manufacturer warranty with Ford. The truck was given full warranty and Ford covered the damages and fixed the vehicle giving it the green light in there service report. I then waited until March 4th 2025 to receive my truck back. On [XXX], the truck was being driven down southband the [XXX], on the [XXX], again due to smoke and also hearing a loud banging, my friends had to pull over and the truck is going to be towed to the service center which it was first fixed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

- San Diego, CA, USA

I was driving around 35-40mph, slowing down, heading to a right hand turn lane. No vehicles in front of me. As I crossed over my lane into the turn lane my e-brake automatically came on and my pre collision braking light came on. No warning, nothing caused by me, and I have no clue how it happened. I had to physically pull the e-brake lever to release the brakes on a major road.

- Tucson, AZ, USA

Three warnings light up: Antilock Brake Fault, Hill Start Assist Warning, and Pre-Collision Assist Not Available. Brakes failed. I was fortunate that no one was in front of me but the truck barely stopped. Took full pedal to the floor to force lockup. I am filing the matter as it does appear to be a frequently occurring concern in 2021 and 2022 models based on what I have read to date.

- Louisville, KY, USA

When starting from a stop, with my 2022 Ford F150 FX4 in drive, sometimes the parking brake will automatically turn on without me activating it while driving. This causes my truck to skid to a halt and I have to manually disengage the parking brake to resume driving. I am concerned about the increased risk for harm to myself or others from a collision due to the unintended stopping. I don't know if the brake lights turn on or not when this happens either, but the vehicle remains in drive and the red park brake active light comes on (lower right corner of the instrument cluster). The local Ford dealership has had the truck in twice for this condition, but they have said they cannot reproduce the problem. I have recorded a video of it happening and sent it to Ford. The recall on my truck having to do with the parking brake that was issued September 2023 has been repaired by the local Ford dealership as of October 2023, but this is still occuring. No advanced warning is given when this occures. It is sudden, and seemingly random, but so far has only occurred when starting from a stop. Other potentially useful information: This has occurred with my vehicle 6 times in the last two weeks with today being the most recent. I have auto hold turned ON. I set the parking brake when I am parked in my driveway. I turn right from my driveway in the mornings. Most of the occurrences of this have been on a slope, but one occurrence has occurred on level ground. Ford has not found an answer for my vehicle yet. They did re-inspect the recall work and said nothing was wrong with that part.

- Bryan, TX, USA

Failure: Total loss of brakes, hard pedal, no airbags deployed, at estimated speed between 5 and 10 mph. Safety concern: Total loss of ability to slow down, stop or avoid impact. Crashed into a shop wall as a dealership technician with the brake lamps evidently applied before and after the impact. Reproduced: Vehicle in for ABS related faults on dash, which is why it was being pulled into the Ford dealer by a Senior Master Ford technician. Inspection by others: Not yet, vehicle has been left at impact site per management. No, there were no warnings, chimes, messages or any other symptom or sign to indicate a concern was going to happen.

- West Seneca, NY, USA

While coasting to an upcoming stop downhill, on slightly graded slope, speed within 15mph or less, with brake slightly applied; the Automatic Parking Brake engaged on its own, subsequently resulting in the transmission shifting of drive modes to park automatically. The vehicle came to an instant, unexpected stop, while still maintaining a speed around 5mph on its own. The vehicle locked up mid-line-of-traffic, leaving the potential of a rear-end collision by following vehicle. No known damage to transmission or powertrain resulted. Adverse weather/road conditions did not play a factor at the time of incident. Incident has occurred multiple times prior, during similar environment & circumstance.

- Mars, PA, USA

Brakes squeal and screech horribly, at first only when the pickup was moving in reverse but now it-??s when coming to a stop. It-??s so loud it echos in parking lots and causes people to stop and look to see where the noise is coming from. It-??s a constant problem that weather conditions do not affect. Had the vehicle in for service numerous times and Ford refuses to fix it or acknowledge there is a problem. Escalated it to Ford corporate and they also refused to do anything about it. At first I was told to wash the wheels -??extra good-?? and it would be just fine and on the last service attempt I was told that the -??brake pads just have so much metal in them by design these noises are 100% normal-?? but now the pickup seems to be losing stopping power and takes longer to stop than it normally did. Per Ford the brake pads are all 9MM and 10MM and -??perfectly fine-?? but the pickup just does not feel safe. I feel there is definitely defects in the braking system including but not limited to brake pads. And complaints are numerous in the forums and online about the same issues with the F-150 line.

- Hunt, TX, USA

The contact owns a 2022 Ford F-53. The contact stated that while driving at undisclosed speeds, the monitor screen went blank. The vehicle was taken to the local dealer, where it was diagnosed that the system needed to be reset. The vehicle was repaired, but the failure recurred. The vehicle was taken to the same local dealer, who diagnosed that the system module needed to be replaced. The vehicle was repaired, but the failure recurred. While driving, the 4WD was inoperable. The ABS, traction control, hill assist, and collision warning lights were illuminated. The brakes were inoperable. While driving, the brake pedal was depressed, but went to the floorboard. The rear wheels had locked up. The contact restarted the vehicle, but the failure persisted. The vehicle was taken to the local dealer, where it was diagnosed that the power brake booster needed to be replaced. The vehicle was repaired, but the failure persisted. The contact stated that while depressing the brake pedal, the pedal went to the floorboard. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 24,000.

- Hull, MA, USA

Advancing forward in traffic to a stop sign on a downward slope in tow/haul mode. Stopped at the intersection and began to accelerate into a left hand turn. Initial acceleration was fine and then the rear tires locked up and squealed on the asphalt. Truck came to a stop and when I looked down the screen said the parking brake was on. I never activated the parking brake. Seemed to disengage on its own after a few seconds. Highly dangerous situation.

- Hedgesville, WV, USA

"Park Brake Fault Service Now" popped up on the dash when I opened the door. There is an upcoming recall on this according to: https://www.caranddriver.com/news/a44690504/ford-f-150-parking-brake-recall/

- Spring Branch, TX, USA

Brakes completely failed without warning or any indication that something was wrong. Lost brakes completely, and dash lit up saying ABS Fault, service advanced traction, hill start assist unavailable, pre Collison assist not available. Luckily i was able to slow down by downshifting in M and throwing it into park before it even came to a stop. Had it towed to dealer and repaired. Dealer failed to give me documentation of what was replaced and/or repaired. Luckily I just exited the highway. I could have been seriously hurt or killed. As well as someone else could obviously had been killed or hurt. I live in Colorado and 75% of my driving is down steep mountain grades. This could have ended catastrophically.

- Wheatridge, CO, USA

The contact owns a 2022 Ford F-150. The contact stated that while driving at approximately 5 MPH the braking system and power steering suddenly failed causing the driver to lose control of the vehicle and crash into a concrete light pole pillar. During the incident, the vehicle was severely damaged. The driver sustained a right-hand laceration and chest and leg injuries. The front passenger sustained both leg injuries. Both occupants required medical treatment. The cause of the failures was not determined. A police report was taken at the scene and the vehicle was towed to an undisclosed location. The contact indicated that the failures had also occurred prior to the crash. The local dealer was notified of the failure. The manufacturer was not yet contacted regarding the incident. The failure mileage was 10,100.

- Warsaw, MO, USA

The contact owns a 2022 Ford F-150. The contact stated while driving approximately 5 MPH on a mountain dirt road and taking a turn to the right, the brake pedal was depressed and the contact had a braking power failure. The contact turned the vehicle to the left and crashed into the side of the mountain. The contact stated no warning light was illuminated. The contact stated that the vehicle rolled up the side of the mountain on the passenger side. The contact stated that the vehicle rolled onto its side and was left on the roadside. The contact stated that the side curtain air bags on the driver's and passenger's side had deployed when the vehicle rolled onto its side. The contact stated that he had called for a tow, but the vehicle had not been taken to a dealer or mechanic to be diagnosed. The vehicle had not been repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 8,000.

- Idaho Springs, CO, USA

Multiple warning lights came on while going 55MPH down a straight road. Warning lights consisted of Antilock break system fault, Pre-collision assist not available, and Hill start assist warning. I did not have and breaks at all.

- Timnath, CO, USA

The truck show a warning when on reverse, the rear brake assiste does not work since I bought the truck and dealer has no fix to it.

- Harrisburg, SD, USA

When applying brakes, the response time in incredibly slow. Sometimes when the brake is applied half way down, the truck tends to skid on the road.

- Spring, TX, USA