The contact owned a 2023 Ford F150. The contact stated that while his wife was driving at 70 MPH, the driver's side wheel and axle detached, the driver lost control, and she crashed into the guard rail. There were no warning lights illuminated. The driver sustained injuries to her body, including burns, bruises, and neck and shoulder pain. The driver received medical attention in the emergency room. The air bags were deployed. There was no reported fire. A police report was filed. The vehicle was towed to a tow lot. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The vehicle was deemed a total loss by the insurance company. The manufacturer was not informed about the failure. The failure mileage was approximately 178.

- Winter Garden, FL, USA

IWE four wheel drive system is engaging while driving the vehicle. Rough shaking in the front end of vehicle and grinding noise while driving. Ford has acknowledged there is a defect but the truck is operating normally and they are trying to fix the issue. Initially I was told it was unsafe to drive, but now that they do not know how to fix the issues they told me to just drive it until it completely breaks down. This is very unsafe. The vehicle is a 2023 F150 with 6,000 miles

- Nicholasville, KY, USA

Truck will randomly start making rumble strip or like you have knobby tires noise from front end. You can put it in 4 high and back 2wd an it goes away.this has happened at different speed and differs temp.

- Hazard , KY, USA

EIWE (Electronic Integrated Wheel End) failure or malfunction. Ford has multiple Field Service Engineers aware of the issue with no fix found. Multiple vehicles not only at one dealership but across the country have confirmed issues. Ford Customer Relations is aware and has an open case with me and many other owners. As requested for Ford case manager, the vehicle is currently going back for a third time to the dealership for something "they can't currently fix".

- Charlotte, VT, USA

Tire monitoring system malfunctions after 30ish minutes of driving. Seems the issue is interference from the on board power generator referred to by ford as -??pro power onboard-??. After the tire monitoring system turns on, immediately turning off the pro power generator the tire monitoring system returns to normal. After researching this issue it-??s very common and has been on going through multiple years with no fix.

- Tallahassee, FL, USA

The axel bolt sheered off of the rear passenger side of my vehicle. I only have 10K miles on the truck. This is a common problem among F150 Powerboosts w/ max tow package. This same flaw is found in Powerboosts from 21-23. Ford needs to recall!!! Check any F150 owners forum and you-??ll see the same problem.

- Pooler , GA, USA