10.0
really awful- Crashes / Fires:
- 2 / 4
- Injuries / Deaths:
- 0 / 0
- Average Mileage:
- 1,737 miles
About These NHTSA Complaints:
The NHTSA is the US gov't agency tasked with vehicle safety. Complaints can be spread across multiple & redundant categories, & are not organized by problem. See the Back button — blue bar at the very top of the page — to explore more.
At idle, the vehicle will shutter and idle rough, nearly stalling in traffic. I have taken it to the dealership twice to two separate dealerships and it's under factory warranty and they have no repair or fix for the problem.
- Houston, TX, USA
Loss of Acceleration in 2022 Ford F-150 PowerBoost Hybrid I am writing to report a safety issue with my 2022 Ford F-150 PowerBoost Hybrid, which has been experiencing acceleration lag and loss of power during regular driving conditions. Component/System that Failed: The powertrain system, specifically related to the integration between the electric motor and gasoline engine, appears to be malfunctioning. This issue primarily affects the vehicle's ability to accelerate after a stop or during turns. Safety Risk: The loss of acceleration poses a significant safety risk to both myself and others on the road. The delay in throttle response has caused the truck to remain in a low gear for several seconds, even with the accelerator fully pressed. This issue has occurred while merging onto highways, when moving through intersections, where quick acceleration is necessary to avoid collisions and a simply stop signs taking a turn where I'm not able to accelerate after. The delay increases the likelihood of rear-end collisions and creates dangerous situations, especially in heavy traffic. The problem has been reproduced by a dealer and many other owners have reported the same issue. I'm hoping that Ford has releases Powertrain Control Module (PCM) update aimed at addressing this, but the issue persists for many, including myself after recent PCM updates. The vehicle has been formally inspected by my local Ford dealership. They will be applying a PCM update on 10/10/2024. There were no warning lamps or error messages that appeared before or during the incidents. The problem occurs unexpectedly, usually when I press the accelerator, particularly in Eco or Normal driving modes. The issue has been less frequent in Sport and Tow/Haul modes, but this results in increased fuel consumption, which negates the advantages of the hybrid system.
- North Smithfield, RI, USA
When driving the vehicle shut off power for 5sec but doesn-??t shut off vehicle (all electrical off ) then kick back on, idling high
- Roswell, NM, USA
The front of the truck started smoking when it was pulled over at a gas station on 07/26/2024, the hood was too hot to open, and the front of the truck proceeded to start on fire. It took the fire department 20 minutes to arrive on the scene at which point there was not much left of the front of the truck. Everyone was able to get out of the vehicle and no injuries occurred. The truck is obviously totaled, but we are unaware as what caused this truck to blow up.
- Aurora, IL, USA
Reduce power warning, instrument cluster is black, extremely loud pulse noise from radio that can not be turned off, catalytic converter issue ( ck engine light ) stalled in traffic. and horrible fuel mileage. Nothing resolved from the dealer.
- Lake Butler, FL, USA
After coasting or turning I lose all ability to accelerate for a short period of time. When trying to merge the truck fails to speed up causing a dangerous situation where traffic jams up behind you
- Venice, FL, USA
My engine failed do to faulty valves at 42000 miles. A check engine light came on and I took it to nearest ford dealership for repairs. It was originally missed diagnosed with faulty ignition coil on number 5 cylinder back in November 2023. Since then it has been determined to have issue mentioned above. They say they will need to replace entire engine. Not happy with this but what can an owner do. I have seen this has been common in other similar vehicles. Has ford found and fixed the problem or will this again happen with the new engine they put in?
- Sevierville , TN, USA
Vehicle's engine will not start. When attempting to start, it will turn on all usual electrical components, but will immediately show an warning message to "Stop Safely Now" along with an engine light of a red outlined truck with exclamation mark. Followed by a message of accessory mode on, however the engine will not start with no access to power steering or shifting gears. Normal attempts to jump start or charge the battery will not work. All fuses and harness connections appear to be normal. After researching Ford community forums, this appears to be a common complaint in the Powerboost Hybrid 2021-2022 Ford F-150s. Extremely inconvenient as this situation has left us stranded several hours from home with no reasonable solution other than to tow to a dealership. We hope our message helps encourage Ford Motor to continue researching the issue and come with a reasonable solution for all effected.
- Prince George, VA, USA
The contact owns a 2022 Ford F-150. The contact stated that while attempting to start the vehicle in a driveway, it failed to turn over and start. The contact depressed the brake pedal and the start-stop button again, but it failed to start. After another attempt, the vehicle restarted, inadvertently accelerated, and crashed into a wooden fence. There were no reported injuries. There was no air bag deployment, fire, or police report filed. The vehicle was towed to a collision center. The contact called the local dealer, who referred him to the manufacturer. The vehicle was not diagnosed or repaired. The manufacturer was contacted and referred to the NHTSA hotline. The failure mileage was approximately 12,000. The VIN was not available.
- Henderson, KY, USA
2022 ford raptor. Oil leak passenger side vehicle, Exhaust rattle while idle. Parked vehicle in garage smell oil inside garage, upon inspection found large oil leak on garage floor, when underneath vehicle and found oil leak from cover plate and front axle, steering components. Made a service appointment with local Ford dealership Long Lewis ford Prattville, Al. Vehicle odometer reading on vehicle 17,388.
- Deatsville, AL, USA
While driving down the highway, my 2022 Ford F-150 Tremor randomly caught on fire. I was driving down the highway and was flagged down by other drivers to let me know the bottom of the truck was on fire. I pulled over and luckily someone had a fire extinguisher and we were able to get the fire under control. The fire department was also called and they also helped put out the fire after their arrival. The truck has always been serviced at a Ford dealer and had gone in for an oil change less than 350 miles prior to the truck catching fire.
- Denver, CO, USA
Vehicle will not start. Get "Stop safely now" message. It is 16 degrees outside. What if this had happened while I was out. This would be a life threatening problem. This appears to be a known issue, but Ford has not fixed it. There are hundreds of reports on various forums of the same problem.
- Jonestown, TX, USA
When sitting at a stop light/stop sign/a complete stop, the truck will switch to electric mode... after about five to seven seconds, the truck "jumps" -- if feels like you just got rear ended. Truck currently at the dealership with no known ETA on repair.
- Dallas, TX, USA
I had warranty work done on a trailer brake module on October 23, 2023. About 3 weeks after that it seemed like my transmission was a little rough. Then Nov. 6, I had several incidences where I was at a stop, and it felt like someone hit me from behind and lurch my truck forward a little bit. It seems very dangerous. In case someone in a crosswalk is walking in front of me I could possibly hit them up. My Ford diagnostic tells me that it is the electric transmission fluid pump. There was no warning no lights lit up on my dashboard warning me that this would happened. After I started the motor the next morning, the check engine light came on. The next day I drove it for a short time around the block and the check engine light was not on. I drove it straight to the dealership and made an appointment to take it in. I have read several articles and forums complaining about the exact same thing recently. It seems as if there should be a recall on this issue. Another issue since I-??ve had the truck brand new in July 2023 is it always skipped second gear which kind of makes it a little rough starting off.
- Redlands, CA, USA
The contact owns a 2022 Ford F-150. The contact stated that while driving at an undisclosed speed uphill, the vehicle lost motive power. Additionally, the display screen was black. The vehicle was taken to an independent dealer; however, no failure was found. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was unknown.
- Chehalis, WA, USA
The contact owns a 2022 Ford F-150. The contact stated that while the vehicle was parked in the garage, the vehicle started without the key fob on three occasions. There were no warning lights illuminated. Additionally, the hood cover was missing when the vehicle was purchased. The contact purchased carbon pouches for the key fob and verified the vehicle did not start. The vehicle was taken to the local dealer, where it was diagnosed that the failure was due to an unknown program. The dealer informed the contact that the vehicle was not manufactured with a hood cover. The vehicle was repaired, but the failure recurred. The contact stated that the manufacturer was aware of the kind of failure that the vehicle had experienced. The failure mileage was approximately 12,000.
- Wilsonville, OR, USA
The contact owned a 2022 Ford F-150. The contact stated that while driving approximately 3-4 MPH going up a sandy rocky hill while towing a trailer, he noticed smoke and flames coming from the driver's and passenger's side engine compartments. The contact was able to stop and exit the vehicle. There were no warning lights illuminated before the fire. The vehicle was burned to the ground when the fire department arrived on the scene. There were no reported injuries. A police report was filed. The vehicle was towed to a tow lot. The insurance company deemed the vehicle a total loss. The Insurance provider had the vehicle inspected by a Fire Origin Specialist however, the contact was not provided a report of any findings. The contact called the local dealer but the vehicle was not diagnosed or repaired. The manufacturer was contacted but no additional assistance was provided. The failure mileage was approximately 4,000.
- Berlin, NH, USA
The heat exchanger on my truck is faulty per the serve department at Balise Ford of Wilbraham. I had a check engine light coming on intermittently starting in October of 2022. In late December, the check engine came on steady. I made an appointment with Balise to have it checked out as well as to have other recall issues resolved. They inspected the truck and found the heat exchanger was faulty and would have to be replaced. They ordered the part. In April, the part finally came in and I brought the truck in to get it sorted out. A couple days later when I went to pick up the truck, I found out that the wrong part had come in and that the repair would have to be done when the proper part came in. They told me at the time that it could take a month or so to arrive. It's been 2 months since that time and the part still isn't available and I'm told that Ford is planning on shipping 72 units nationwide around June 30th. It doesn't appear that I'm high enough on the list to get one of these parts when they become available. This is now over 6 months I've been waiting for the part. The issues are 2 fold, 1st, I don't know if any sort of damage is being done to the engine due to this issue. There is something overheating in the system. I drive 65 miles to work each way and some days I have to pull over 3 and 4 times to let the heat exchanger cool down. The engine temperature shows as normal, but I get an alert on my dash that tells me that the engine is going into low power mode due to overheating and it's not possible to maintain highway speeds and creates a situation where I need to get over to side of the road quickly since I can't maintain pace. I never know when this will happen. The second issue is that I live in Massachusetts, my truck has to pass a safety inspection. It won't pass with a check engine light on. Once rejected, I have 50 days to get it repaired. After that time, I legally cannot drive the vehicle.
- Monson, MA, USA
The contact owns a 2022 Ford F-150. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the local dealer where it was diagnosed and determined that the computer needed to be programmed. The vehicle was repaired but the failure recurred. While driving approximately 50 MPH with the cruise control activated, the vehicle unintendedly accelerated to approximately 70 MPH. The brakes failed to respond while depressing the brake pedal. The failure was self-corrected. The vehicle was taken back to the local dealer who documented the failure but was unable to duplicate the failure. The manufacturer was contacted, and the contact was referred to another dealer. The failure mileage was approximately 10,600.
- Powhatan, VA, USA
- Holden, MA, USA