Valve cover bolts keep bracken (32) and leaves oil running all over the motor and transmission

- Houston, TX, USA

The contact owns a 2011 Ford F-250. The contact stated while her husband was driving at an unknown speed, the check engine warning light illuminated. The driver was able to continue driving to his destination. The contact took the vehicle to an independent mechanic, where it was diagnosed with needing the DEF (Diesel Exhaust Fluid) heater and the sending unit to be replaced. The vehicle was repaired but continued to experience the failure. The contact took the vehicle back to an independent mechanic, where it was diagnosed with needing the DEF heater to be replaced for the second time. The vehicle was repaired but continued to experience the failure for a third time. The contact took the vehicle back to an independent mechanic, where it was diagnosed with needing the DEF heater to be replaced. The vehicle was repaired but continued to experience the failure for a fourth time. The contact took the vehicle to the local dealer, where it was diagnosed with needing the DEF heater, the DEF pump, and the sending unit to be replaced. The vehicle was repaired but continued to experience the failure for a fifth time. The contact stated while towing a trainer, the vehicle lost acceleration and the check engine warning light illuminated. The contact took the vehicle to the back local dealer, where it was diagnosed with needing the DEF heater, the DEF pump, the injector, and the sending unit to be replaced. The vehicle was not repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 150,000.

- Middleton, ID, USA

Hold down clamps for the fuel injectors are breaking or coming loose on diesel engine. Injectors are not visible for a person to look at as they are buried by covers. Due to the injector coming loose it would allow combustion gasses to escape the cylinder causing other injectors to become damaged and possibly causing a fire. This issue has happened 2 times on my truck and both times the Ford Technicians stated that it is not something that should happen. Vehicle was inspected/fixed by Ford dealership Techs back in March of 2021 and again in May of 2021(still there at this time). A check engine light came on and i immediately drove to the dealership both times. I will provide a picture of a Ford tech site where they talk about this issue happening and their internal memo. Ford at this time refuses to fix the issue and is making me pay for their defective parts.

- Wichita, KS, USA

With absolute zero notice a cylinder misfired which caused the crank shaft to break and the engine to blow. We maintained this vehicle very regularly and never had any issues.

- Polk City, FL, USA

When stationary exhaust fumes are drawn into cab of truck by the air handling system. This is an ongoing problem.

- Auburn, WA, USA

Purchased vehicle 11-2018 have taken to two service shops engine knock. Metal in filter. Cylinder #1 low compression due to bad machining of the engine block. Vehicle non drivable.

- Fredericksburg, TX, USA

2011 F250 6.2L engine. Truck dies randomly and will not restart for sometimes days. Sometimes it starts and sometimes it doesn't. weather is not a factor, sometimes its warm sometimes its cold. Very random start and no start issue.

- Murray, UT, USA

"takata recall" while driving down road, vehicle went into reduce speed mode. When slowed down, engine shut off and would not start.

- Pierre Part, LA, USA

The contact owns a 2011 Ford F-250. While driving 60 mph, the vehicle vibrated, emitted a knocking noise, and the engine emitted smoke. The contact was able to coast onto the shoulder of the roadway. The vehicle was towed to an unknown dealer to be diagnosed and a failure code for the engine valve was detected. The dealer informed the contact that the engine needed to be replaced. The engine was not replaced. The manufacturer was notified of the failure. The VIN was not available. The approximate failure mileage was 146,000.

- Powell, TN, USA

Our lady of the lakes road in St. Martin parish, Louisiana, is a curvy road. The "service advance track and hill descent control, check engine light and break light" came on. The "!" and the "ABS" light came on. Break pedal was hard to depress, while in motion. Fire started under the hood and burnt front seats and engine

- New Iberia, LA, USA

The truck went to limp mode for 3 sec then shut off. My son was driving and it shut of on a busy 4 lane road with nowhere to go, no power steering, brakes, no motor nothing. Let it be known and I am coping this letter. This could be very hazardous even deadly. I hope something is done before it kills someone or multiple people. The vehicle was in motion when it happend.

- Mobile, AL, USA

Pulling my fifth wheel trailer up a hill at 50mph the engine just shut down very abruptly. No alarms or lights that I saw. After letting it sit for a minute or so, put it in park and it restarted, oil temp at 240, trans: Temp at 201. First time this has happened. A little over 50,000 miles.

- Santa Barbara, CA, USA

While driving at 35 mph on city street "stop safely now" appeared on the dash screen. Within a few second the vehicle shut down, which eliminated the power brakes and steering, while still at 35 mph. This made the vehicle difficult to control and stop. Vehicle would not restart, luckily I was able to pull into a parking lot and out of traffic. This turned out to be any egt sensor failure.

- Atlanta, GA, USA

My vehicle has experienced no power while accelerating onto a state highway. Acceleration was extremely slow and created a dangerous situation in which the vehicle had to be pulled over on the shoulder immediately to move out of the way of traffic, which was very far away when I initial pulled out on the highway. This occurred multiple times and at random. The vehicle could only reach 40 mph on flat highway and while driving on mountain roads, this would decrease to a maximum speed of 20 mph. This would create a significantly dangerous situation if on was crossing an intersection with oncoming traffic. And

- Atlanta, GA, USA

The truck that I own has no accidents, no damages, 75K miles on it and the radiator is prematurely failing. This coolant leak on the lower driver's side is a reoccurring issue with this model vehicle and would cause the engine to overheat. Ford is aware of the issue and has refused to recall the part.

- Fayetteville, AR, USA

The contact owns a 2011 Ford F-250. While driving 45 mph, the vehicle shook and stalled. The steering wheel became difficult to turn and the brakes failed. The vehicle had a full tank of fuel. The vehicle took awhile to restart. The vehicle was taken to a dealer where it was unable to be diagnosed. The manufacturer was not made aware of the failure. The failure mileage was 40,000.

- Chugiak, AK, USA

Turned onto busy highway, vehicle warning chimed a few times and message center said 'stop safely now" vehicle slowed down and then shut off in the middle if an intersection with no prior warning. I had to have my wife exit the vehicle to a safe location and then have the vehicle pushed out of the intersection. I contacted a towing company to have the truck towed to a local Ford shop. They diagnosed it as a failed number 4 egt sensor. Upon further investigation I have found that this is a know problem.

- Hudson, FL, USA

Driving the car at 50 miles per hour on a highway, the message "pull over safely now" came on, within 10 seconds the engine and subsequently steering shut itself down. There was no place to pull over except for a turn out lane. I bought this car to pull my 2 horse trailer and drive on interstate for long road trips. I drive at night since that is easier on my horses. If the engine and steering can shut itself down going at 75 miles per hour on interstate, 10 seconds is not a safe enough time to pull over when carrying a live animal load. I was told the sensor was bad and needed to be replaced. The vehicle is completely unsafe for what it was designed to do. No piece of mind driving and towing with a vehicle that can shut itself down without adequate warning due to bad sensors within 10 seconds. Extremely dangerous! apparently the sensors on these vehicles go out on a regular basis, it's just a matter of time until someone gets killed due to a $50 failed sensor and the engine shutting itself down and lost steering control. Dealers I have talked to are very familiar with this issue but say they can't do anything until engine shuts itself down. Dealers say it's random and unpredictable when egt sensor will fail. Some of the sensors are covered under warranty, but engine needs to shut down before dealer will fix it! insane. I have a friend whose wife died on the freeway in an accident caused by a similar issue on her vehicle before it was declared a recall. I believe that the sensor issue on the Ford 250 will lead to similar situations. It's time this is looked into before lives are lost.

- Sedona , AZ, USA

The contact owns a 2011 Ford F-250. The contact stated that after coming to a stop, there was an abnormal odor coming from the radiator. The contact noticed coolant leaking from the radiator. The failure recurred numerous times. The vehicle was taken to a dealer where it was diagnosed that the radiator needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 88,000.

- Lake Charles, LA, USA

While going up the highway the message of " stop safely now" was displayed. Once pulling over to stop the truck died and would not start back. Had to have it towed to a dealership. Turns out the egt exhaust gas temperature sensor was faulty. This seems to be a very common issue.

- Mooresburg, TN, USA