Ford has been fully aware of its DPS6 transmission design flaws and failures for many years. A formal recall was appropriate and they have not done so all this time; therefore, a consumer is not warned of the problem through the tried and true channels of BMV lookups during new registrations, dealer records resulting in notices sent, or other lookup tools. This causes the problem to present itself unexpectedly and progressively, and it causes quite a bad hazard by affecting the ability of the vehicle to accelerate and decelerate as expected. These transmissions slip into neutral unexpectedly as well, and it shouldn't be accepted that that is considered not a hazardous situation. Especially on the interstate, it can cause a crash. Support and responsibility by Ford is very bad. An auto transmission that isn't a flawed design may cost $2,000 to fully replace. The dual-dry clutch in Ford's PowerShift design is prone to failure. Even despite that Ford says it extended coverage for PowerShift transmissions, this can result in a $3600 repair bill, promises to cover it defaulted on, and factory warranty dishonored. I've been told by Ford it will make the defect right, but the repair estimate was $6800, twice what the car is valued for and impossible to afford to fix.

- Columbus, OH, USA

Car will start surging and then will stall out. First noticed when car was purchased, but was told it was normal for the car to do. I will start the car and it'll run for a few seconds then die. Sometimes for only a couple times and then the car will run okay. There are times it'll surge then die up to 7 times in a row. Only a couple times it has surged and died while out driving. The car would die in the middle of the road. Car started up with issues almost 3 weeks ago and is progressively getting worse. Sometimes the engine light comes on then it will turn off. 2 different dealerships, Jess Ford, in Pullman Washington and Joe Hall Ford in Lewiston Idaho, both have done inspections and claimed to have fixed the transmission, but the issue has continued to be an issue. It has happened over 15 plus times of stalling and surging in the last week. TCM replaced, clutch replaced, fuel purge valve has been replaced. We were told it was a one-time fix, but it has been a nonstop issue since. The technicians informed us that it would fail again, and it did. Car is a 2015 Ford Focus, under 94k miles.

- Lewiston, ID, USA

This vehicle stalls while driving due to a faulty purge solenoid inspected by Pep Boys mechanic. There was a recall on the ford focus in 2018 18V735000(recall number) I purchased this vehicle in 2023 with no known recalls. This issue occurred September 2024 I paid for the repair two weeks ago and now the same issue is existing. There were no warning lights displayed when the car stalled while driving. My safety and the safety of my child is at risk being that the vehicle stalls while driving which is could be the cause for accidents and or collisions

- Atlanta Ga, GA, USA

There was already a recall performed on the vehicle for the purge valve being stuck open and a gas tank deformation. fast forward a few years and now the same issue is happening to the "repaired" parts. What are my options to have this recall correctly repaired?

- Penns Grove, NJ, USA

Clutch was replaced already 1 time now it-??s bad again also the tmi was replaced 2 times since I-??ve had the car it has 126000 miles

- Beaver Falls, PA, USA

This car has had repeated issues rough idle after fueling for years. Replacing the oxygen sensor did not resolve the problem. The dealer resetting the car's computer did not resolve the problem. I recently had to replace the canister purge valve (CPV) after the car began stalling after fueling. This resolved the idle issue. I noticed Ford recalled CPVs on Ford Focuses built in Michigan (as mine was) between 2012-2018 (GDI) and before 2017 (GTDI); however, my car was excluded from this recall. Can you please investigate to determine if there are additional vehicles which also received defective parts for which the cost to replace them should be covered? Thank you.

- Winchester, VA, USA

What happened? I purchased a 2015 Ford Focus from Carvana in November 2022 with about 70,000 miles on it. Since then, the vehicle has experienced numerous and severe mechanical failures. The engine mount and transmission mount have both failed and required replacement. Additionally, the rotors, Transmission Control Module (TCM), and clutch have all needed to be replaced, with the clutch failing five times throughout the car's history. Despite extensive repairs costing upwards of $7,000, the issues persist. Most Recently, The vehicle was subsequently towed to a Ford dealership after replacing the clutch for the 6th time in vehicle history. What component or system failed or malfunctioned, and is it available for inspection upon request? The components that failed include the engine mount, transmission mount, rotors, Transmission Control Module (TCM), clutch, and evap purge system. These components are available for inspection upon request. How was your safety or the safety of others put at risk" The frequent mechanical failures and replacements, particularly of critical components like the TCM and clutch, have compromised the reliability and safety of the vehicle, posing a significant risk during operation. The vehicle's tendency to stall while driving or idling increases the risk of accidents, potentially leading to rear-end or T-bone collisions. Yes, the problems have been confirmed and addressed by both a dealer and independent service centers. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? The vehicle has been inspected by independent service centers and possibly by the dealer. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear" No, there were no check engine lights or warning lights prior to the failures. The issues began appearing shortly after the purchase in November 2022.

- Bronx, NY, USA

Stopped to get gas. Turned off engine. After filling up gas tank, car would not start, or crank/turn over. No check engine light has been on, no warning lights. Disconnected battery for about fifteen min. Car started up. Took it to shop, they changed out the evap Purge system. It failed when they tested it so they changed that out. Car did not stall when they test drove it. Car stalled two more times. Once when accelerating from a red light, and second time when just sitting in idle. Car just shuts itself off but the radio stays on. This is such a safety hazard because of the fact that not only does it stall in the middle of me driving But I-??m very lucky I didn-??t get rear ended or T boned because of this. So I thought this issue was fixed but obviously not. After the last time it stalled after getting it fixed, I then had it towed to a Ford dealership. I know this has been a recall on other Ford focuses. For some reason not mine which is a 2015 Focus. Last year I had to have the TCM fixed which was a recall so that was free however then they tell me that my clutch went bad at 60k miles" I shelled out almost $3k for that nonsense. Now This stalling it constantly Day after day at 75k miles" Thanks a lot FORD. Take your piece of [XXX] back and issue this a recall. Either way it-??s Ford-??s fault and should pay for this safety issue for free. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

- Washington , NJ, USA

It-??s a 2015 ford focus 1.0 eco boost 6 speed manual. It studders and shakes and stalls at random while driving. It only has 78000 miles on it and I just bought this car from some punk kid. Shakes the car violently as well.

- Smithville, MO, USA

The EVAP system has failed and has resulted in drivability issues. It is available for inspection if needed. The problem has been confirmed by an independent service provider with a full diagnostic exam. There is a P0420 and P1450 code on the car. There have been issues with the distance to empty on the car. Sometimes it says I have 290 miles to empty or 400 miles to empty when I fully fill up my car with gas. *There is a Ford Focus recall (Recall #[XXX]) which covers the exact issues I-??m having with this car, but the car is not included in this recall. It is even from the same manufacture plant in Michigan.* INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

- Kyle, TX, USA

When the engine is hot, it stalls and stops after starting. and this happens several times a day. There was a situation when the engine stopped in the middle of the road near an elementary school, which hampered the flow of traffic. Also, when refueling, the cutoff on the filling hose is constantly activated. two faults occur regularly

- Spokane, WA, USA

I just bought this car 2 months ago after saving for a whole year. I-??ve been having problems week into the purchase due to the transmission. My car has been overheating with the transmission (almost every 4 miles), going on limp mode (when pressing the gas), jerking (while driving), not reversing and not starting right away. Im trying my hardest to get on my feet after a being in a domestic abuse relationship that affected my and my daughters life. I just want to get my baby back and fourth from school. So I BEG you to approve the transmission recall for Ford Focus. PLEASE!!!

- Chicago , IL, USA

We are experiencing the fuel tank evaporate issue where car shuts off while driving. We were not recalled specifically but now have car in shop waiting on the recall to be reopened as the conditions match the issue under the recall. We have had 3 incidents that could have ended up in a collision as car abruptly shuts down. This is related to the evap fuel tank and sensor issues reported in the original recall. Our vehicle apparently had the programming updated during a past service visit but obviously has not corrected this issue. This vehicle has also had the transmission recall done shortly after purchase and transmission still acts up on occasion. Not happy with the current issue as it is a potential death trap when car shuts off for no reason.

- Lawson, MO, USA

I-??ve been having issues with my automatic clutch transmission since I-??ve bought this vehicle. There has been numerous repairs done but the company tells me they aren-??t responsive on covering another. It causes the car to jerk when accelerating aggressively and has almost caused a wreck. It has been confirmed by the dealership. No warning signs with this. First started to appear a few months after buying the vehicle and then upon repair the issue would return I few months after the fact and the dealership would not help.

- Opp, AL, USA

ALL OF THE PROBLEMS ASSOCIATED WITH Campaign/NHTSA#18S32/18V735 (Issue Date 2018-10-22) OCCURRED AGAIN WITH 5 TEENAGERS IN THE CAR, SOUTHBOUND ON I-65 BETWEEN OHIO AND FLORIDA, CAUSING THE CAR TO COME TO A COMPLETE STOP! THIS KNOWN PROBLEM/FORD RECALL SYSTEMS FAILURE REPEATED JUST 3 YEARS AFTER REMEDIATION/RECALL, STRANDING 5 TEENAGERS ON THE TENNESSEE-ALABAMA LINE FOR 2 DAYS AND THEN REQUIRING AN EXPENSIVE TOW TO FLORIDA (FOR VACATION) AND THEN AGAIN HOME (BECAUSE IT WAS NOT CORRECTLY DIAGNOSED AT THE FORD SERVICE CENTER IN FLORIDA)! THE FORD DEALERSHIPS/SERVICE CENTERS IN Panama City, FL STATED THERE WAS A COMPUTER PROBLEM WHICH COULDN'T BE FIXED THERE FOR OVER TWO WEEKS, SO THE CAR WAS TOWED TO OHIO. HERE, THE FORD SERVICE CENTER IN WCH, OHIO ([XXX}) DIAGNOSED THE PROBLEM AS REQUIRING REPLACEMENT PARTS AND LABOR FOR: " FUEL PUMP, O-RING, NEW FUEL TANK AND VAPOR TUBE/PURGE VALVE ON ENGINE FOR 'STUCK OPEN VALVES' 'NOT PULLING FUEL' AND COLLAPSE OF THE FUEL TANK ITSELF.' $1248.47 P/L + TAXES + TOWING X2 + $150 DIAGNOSTIC EVAL. THIS IS EXACTLY THE SAME SCENARIO AS THE OCTOBER 2018 FUEL TANK DEFORMATION RECALL Campaign/NHTSA#18S32/18V735. THIS CAR HAD THE REQUIRED RECALL PERFORMED IN MARCH 2020 AT LEBANON FORD ([XXX]) IN LEBANON, OHIO, BUT JUST 3 YEARS LATER, THE ENTIRE SYSTEM FAILED AGAIN, PUTTING 5 TEENAGERS AT GRAVE RISK (WHILE TRAVELING AT INTERSTATE SPEEDS OF 65-70MPH)--TWO OF WHOM WERE MY DAUGHTERS! I WOULD LIKE THIS SYSTEM RE-EVALUATED AND A NEW RECALL/REMEDIATION ISSUED IMMEDIATELY TO PROTECT PASSENGERS/FORD DRIVERS/OTHERS ON THE ROAD WITH THIS PROBLEMATIC CAR MODEL/YEAR! -??INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).-??

- Greenfield, OH, USA

Service engine soon light came on, repair shop said I needed a tune up and could still drive ok. Broke down. Got that done and still engine light on so transmission fluid changed too. Now repair shop says it-??s the transmission and clutch assembly that the dealer recalled and fixed a few years ago. I-??m stuck with payments still and no way to get the $5000 the dealer days it will cost to fix this. Car value is the same. Everyone I-??ve talked to has said this is a bad year-??s model and will continue to break down even after fixing. Can you offer any advice? Thank you!

- Lady Lake , FL, USA

The power train control module & transmission control module has failed since I bought the Focus 2016 at 660 m on it. I-??ve had this serviced 8 times @ Ford. Check engine light is on. Code P060A Was shown @ Ford. Mileage now is 72000. TCM & PCM were recall several times. Ford is charging me to fix it. Please tell me how this is NOT covered 10 yr. 150 k mile warranty OR by the 8th time being -??serviced-?? & UNRESOLVED?

- Anderson, SC, USA

When driving in stop and go traffic 0=5 mph for about 30 mins the car began to act as if was slipping and revenge up without moving and engine light came on and would sometimes slam into gear. I placed vehicle in sport mode and it idled irratically to the point I felt it was going to shut down. Upon arrival home I realized that now reverse had went out when attempting to put car in driveway. I will be taking it into Ford today for the 1 recall on the fuel canister software but I feel that it is not related and hope they will make some discovery and fix it accordingly.

- Maynardville, TN, USA

Car began losing power particularly at low speeds. AAA inspected vehicle and determined that clutch and transmission would need to be replaced (~$10K repair). This is the second time the transmission and clutch have been replaced. The car has a total of 50,000 miles on it (ie, it is still, mechanically, very, very young ) Manufacturer seems to have known about the issue.

- Durham, NC, USA

Check engine light came on Code P1450 Dealer diagnosed Canister Purge Valve needed to be replaced. My ViN not under recall! This has been a common problem for other 2015 Ford Focus vehicles and many under recall. Recall notice should be expanded to include those of us with this same issue.

- Monroeville, PA, USA