10.0
really awful- Crashes / Fires:
- 4 / 3
- Injuries / Deaths:
- 4 / 0
- Average Mileage:
- 20,752 miles
About These NHTSA Complaints:
The NHTSA is the US gov't agency tasked with vehicle safety. Complaints can be spread across multiple & redundant categories, & are not organized by problem. See the Back button — blue bar at the very top of the page — to explore more.
« Read the previous 20 complaints
Oil pump belt failed at a little over 50,000 miles
- San Antonio, TX, USA
The dealership told me that I need a new engine and they said that the engine was poorly made but that there was nothing they could do to help with the cost. I only have 103,947 miles on the vehicle and kept up routine maintenance. The dealer said that Ford is likely to recall this engine. I also tried to call Ford corporate customer support for assistance and they said they were unwilling to help at all. There is a safety issue with the coolant system that causes engine failure. The diagnostic is to replace the entire engine. There are safety bulletins that exist but no assistant other than replacing a failed engine with another poorly made engine. This should not be legally allowed to occur. The consumer is helpless here. Please help me.
- Euclid, OH, USA
The dealership told me that the sensor I read that was a recall wasn't covered because my vin wasn't on the list of re-calls. I looked up what auto zone pulled up as the code and pretty sure it was the fuel filter valve. But after taking it to our regular mechanic he replaced a line in the engine area that connect beside the battery going to the air filter area looks like a long black hose and then stated that may have been bad gas but was reading the re-call and my car was doing what I was reading. Some one said purge valve. He already replaced it and works fine. But I would get gas started off not starting up good then got worse had to leave it on while pumping 1 day it just died on me on fourth of a tank in the middle of rush hour and about got hit a bunch of times and nearly had to go to the e.r. made my heart rate escalade to high. Then got to were I couldn't even barely get it started so my ex husband paid to get it fixed costing dang near $250 I shouldn't have to be responsible for. There was never anything ever wrong with my car prior had it since new took very good care of it only put 60 thousand miles on it in 5 years maybe a very few oil changes and 1 set of tires but that was it. It won't let me upload my files either
- Livingston, TX, USA
Upon arriving at my job after a 50 mile commute, I noticed my engine making abnormal noise followed by an oil pressure engine light. After researching the symptoms, I found it is well documented that there is an issue with the Ford 1 liter ecoboost wet belt system. 2 Ford SSM bulletins (48093 and 49726) describe a wet belt tensioner failure followed by the oil pump belt shedding teeth resulting in loss of oil pressure. After removing my oil pan, the tensioner was found in the oil pan along with most of the oil pump belts teeth. Ford's recommendation is an engine replacement. Ford recommends replacing the wet belts at 150,000 miles with most failing quite prematurely This failure can happen at any time or speed causing total loss of power or catastrophic engine damage making it a safety concern for the driver as well as others.
- Brentwood, CA, USA
In Oct 2022 we were on vacation driving on a highway in IL when my 2018 Ford Focus 3L 1.0L EcoBoost suddenly, without warning, shuddered and lost power. Luckily we were on a rural road and no one was around or it would have caused a traffic issue and potential accident(s). We live in UT and I frequently drive a very busy freeway and was grateful this did not occur there. We pulled to the side and noticed the check engine light and another message regarding Oil but I do not recall the exact words. We had pulled our car behind our motorhome so we were able to tow it back to our vehicle and towed it home. On the way home, we found that I did not have the extended warranty on the car that I intended when I bought it. This was maddening as the car was approximately 7k miles outside of the Ford Powertrain warranty. I eventually towed it to my parents home in ID and my father, a retired mechanic, inspected the car and eventually narrowed it down to the known issue of the oil pump/internal belt failure and that the entire engine would need to be replaced. I don't have the money to repair it. I have all of the service records as the oil changes were performed at a dealerships prior to the engine failure. We have not had it inspected by a dealer or other party at this time. I have been paying insurance and loan payments on a car I haven't been able to use for over a year now and it is extremely frustrating. I also hope to join a potential class action lawsuit.
- Mona, UT, USA
2018 Ford Focus: Engine had knocking noise and low oil pressure due to failed oil pump belt and turbocharger was failing. Vehicle got towed to Ford Dealership and this information was confirmed by the Ford dealership. This incident happened unexpectedly. Check engine light and oil light came on in vehicle while operating moments before incident occurred. Vehicle had regular oil changes roughly every 3000-5000 miles (extended performance high mileage oil). There was a recall on this specific issue/incident with the following Ford vehicles/years: July 2023 -?" A Ford EcoBoost class action lawsuit alleges 1-liter EcoBoost engines suffer from oil pump failures that destroy the engines in these Ford vehicles: 2016-2018 Ford Focus 2016-2017 Ford Fiesta 2018-2021 Ford EcoSport
- El Paso, TX, USA
The brake got stuck and made it very difficult to start the car. Considering it-??s a push start. The car then started misfiring and had trouble accelerating. Took it to Ford Auto Nation a few weeks later as it had not advanced, they informed me that the clutch and petal had to be replaced along with a few other parts.
- Marietta, GA, USA
While driving vehicle two "Oil Lights" on dash came on and car instantly began making a noise. Pulled over and had it towed to a service shop, they are telling me the "Oil Pump Drive Belt" broke and now the entire engine needs replaced. Upon researching this issue I come to find that this is a VERY COMMON issue that Ford is aware of but refusing to fix. This needs addressed!
- Massillon, OH, USA
The contact owns a 2018 Ford Focus. The contact stated that after refueling the vehicle, the vehicle independently shut off. The contact was able to restart the vehicle after several attempts. The check engine warning light was illuminated. The vehicle had not been diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 69,172.
- Lebanon, MO, USA
The contact owns a 2018 Ford Focus. The contact stated that on two occasions while driving approximately 45 MPH, the oil warning light illuminated. The vehicle was towed to a dealer where it was not been diagnosed. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 138,000.
- Midland, PA, USA
The contact owns a 2018 Ford Focus. The contact stated while driving 60-65 MPH, the vehicle started shuddering, failed to accelerate as needed and lost motive power and went into LIMP mode. The low oil pressure and the check engine warning lights were illuminated. Additionally, the messages "Reduced Engine Power" and " Service Vehicle Now" were displayed. The contact was able to coast the vehicle to the shoulder of the roadway. The vehicle failed to restart and was towed to the dealer, where it was diagnosed that the oil pump belt had failed, and the engine needed to be replaced. The vehicle was not repaired. The contact related the failure to Ford Campaign Number: SSM49918. The manufacturer was notified of the failure and referred the contact to the NHTSA hotline for assistance. The failure mileage was approximately 106,000.
- Ashland, OH, USA
The contact owns a 2018 Ford Focus. The contact stated that the check engine light had been illuminated. The vehicle would suddenly stall while idle causing the contact to have to restart the vehicle or continually reeving in order to prevent stalling. The vehicle would also display a sputtering when slowing down. The contact noticed that the mileage per gallon ratio had decreased significantly. The vehicle had been taken to a certified mechanic who diagnosed that the purge valve had been stuck open causing multiple failures. The fuel tank had been warped a bit and may need to be replaced. The vehicle had not been repaired. The contact was informed that their vehicle's year/make/model was involved in NHTSA Campaign Number: 18V735000 (Fuel System, Gasoline) however their VIN was not included. The manufacturer was made aware of the failure. The approximate failure mileage was 72,000.
- Merced, CA, USA
-Engine service now message -stalling out while driving - loss of power - loss of gas mileage
- Elsmere , DE, USA
While driving on the highway my oil light came on, followed by a complete loss of power and my vehicle went into limp mode. I was almost hit twice while trying to get off on the shoulder. I proceeded to shut the car off for 20 minutes and checked the oil level to which it was full. I sat for 30 more minutes and attempted to start the vehicle when it started knocking. I immediately shut it off and had it towed home. From home I contacted a Ford dealership and had it towed there 9/20/23. There they ran their mechanical oil pressure gauge and my engine had absolutely no oil pressure. The -??recommendation-?? is to replace the long block and turbo, as if it-??s drivable any other way.
- Oldtown, ID, USA
The contact owns a 2018 Ford Focus. The contact stated that while driving at an undisclosed speed, the vehicle stalled. No warning light was illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that the engine block had failed and needed to be replaced. The vehicle was not repaired. An undisclosed dealer was notified of the failure and the contact was advised to contact the manufacturer for assistance. The manufacturer was notified of the failure and the contact was denied coverage due to the vehicle being out of warranty. The failure mileage was 47,686.
- Gatesville, TX, USA
The contact's daughter owns a 2018 Ford Focus. The contact stated while his daughter was driving 70 MPH, the low oil pressure and check engine warning lights illuminated, and the vehicle started shuddering and then lost motive power. The contact's daughter was able to veer to the side of the road. The vehicle failed to restart and was towed to the local dealer, where it was diagnosed that the oil pump pretensioner belt had failed, which caused the engine and the turbo to fail. The dealer informed the contact that the engine and the turbo needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 70,318.
- Avon Lake, OH, USA
Vehicle has less than 70,000 miles on it. While driving lost oil pressure and brakes. Yes available for inspection. When pressure was lost and brakes failed I could not have stopped to avoid an accident. Multiple articles on the pump failure. Spoke with Ford they say not their problem. No warning. Engine light came on with brake light while driving. Car has been sitting parked. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
- Lafayette, IN, USA
The contact owns a 2018 Ford Focus. The contact stated that while driving at 20 MPH, the brake pedal was depressed, and the brake pedal became firm. The check oil warning light was illuminated. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was approximately 65,000.
- Monticello, IN, USA
The contact owns a 2018 Ford Focus. The contact stated while driving approximately 60 MPH, the vehicle suddenly stalled. The vehicle was later taken to the local mechanic who diagnosed that the purge valve was faulty and needed to be replaced. The vehicle was not yet repaired. The contact also indicated that the vehicle had previously experienced rough idling, check engine light illuminated, fuel gauge reading errors, and the Distance to Empty reading was incorrect. The local dealer was notified of the failures. The manufacturer was not notified. The VIN was not included in NHTSA Campaign Number: 18V735000 (Fuel System, Gasoline). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 55,000.
- Alexandria, VA, USA
- Manalapan, NJ, USA