I had a passenger in the rear passenger side seat that could not open the door to get out. I had to go to the outside door handle to open the door. On inspection it appears the interior rear door handle has started to crack at the pivot point(spring return attachment point). The break causes interference with the rear door handle bezel and limits travel of door handle (door won't open). It appears the same thing is starting to happen on the other rear door. Car only has 85000 miles. It appears to be a design/manufacturing defect. I will be going to Ford to get a replacement which I hope has had a design change to fix this. The rear doors had been used very little so its not a usage issue. This is a real safety concern for rear passengers.

- Edgerton, KS, USA

06 Ford Fusion. I have been having a cracking sound in the front right suspension, took it in to Ford to get tires done, they found that my front subframe welds have cracked and it would cost 1500 to fix with a used part, the complaint is, when I came home and researched this issue, I have found tons and tons of complaint with this same issue, it appears to be a failure of Ford to have a correct weld placed in this area, I believe we need to have this investigated and looked at, the subframe weld that has broke is where the front lower control arm hatches to the frame, with this busted and poorly welded we are looking at suspension coming apart and creating an accident and deaths I am asking for a recall to be made.

- Pocatello, ID, USA

2006 Ford Fusion key will not come out of ignition; gear shift does not go into park even though it looks as though it has.

- Tempe, AZ, USA

2006 Ford Fusion key will not come out of ignition; gear shift does not go into park even though it looks as though it has.

- La Mirada, CA, USA

The contact owns a 2006 Ford Fusion. In June of 2008, the vehicle jumped forward when the air conditioner was activated. In addition, the RPM's rapidly increased. The failure occurred approximately four times. The vehicle was taken to the dealer, but they were unable to determine the cause of the failure. The vehicle was taken to an automotive garage; however, they were unable to locate the cause of the failure as well. The failure mileage was 24,000 and current mileage was 28,000.

- Lynbrook, NY, USA

My windshield had serious distortions throughout the entire glass. Varying degress of magnification caused eye strain and headaches. It was dangerous driving the vehicle in this condition and not a pleasant experience. My dealership replaced the windshield only to have the new one be even worse. The new windshield is so bad it's as though I'm looking through a wet windshield that has not been wiped. The dealership has acknowledged the replacement is bad and that it might be indicative of a larger problem. They plan on contacting Ford. I've had the car for only one week at the time of typing this.

- Newton, NJ, USA