10.0
really awful- Crashes / Fires:
- 2 / 0
- Injuries / Deaths:
- 1 / 0
- Average Mileage:
- 109,501 miles
About These NHTSA Complaints:
The NHTSA is the US gov't agency tasked with vehicle safety. Complaints can be spread across multiple & redundant categories, & are not organized by problem. See the Back button — blue bar at the very top of the page — to explore more.
The dashboard has warped. The seems on the dashboard around the passenger side airbag cover have become partially unattached to the rest of the dashboard and have caused an opening above passenger side airbag that may allow for debris/dirt to enter into safety equipment and could potentially lead to serious hazards to person if airbag unit deploys. The plastic vent and sensor under the windshield located in the very top front of the dashboard has cracked and has also become dislodged and lifteb from dashboard housing and can pose safety issues if in a collision. There is also some notable brittleness arising in the dashboard material. The warping of the dashboard and its components pose strong safety concerns and a risk to service departments doing recall repairs for manufacturers. There are many similar vehicles produced by this manufacturer during this time that have had same dashboard failures and at the very least it was been the root of stress anxiety for owners and repair dealerships.
- Fountain Valley, CA, USA
I just bought this car and the brakes do not feel right when i go to stop. They are new and i got them changed today and it still makes a pop noise.
- Abbeville, GA, USA
The number 16 transmission fuse would blow and then the car wouldn-??t start until you replaced the fuse and now it-??s not even starting when the fuse is replaced.
- Las Vegas , NV, USA
The passenger side airbag is bulging from the dashboard causing the widows to fog. Also while driving parts of the dashboard flew off which could result in injury or death if this issue is not resolved promptly
- Waco , TX, USA
A recall was issued for our 2008 for Fusion concerning the ABS system. This recal is NHTSA 19V904. We have recieved postcards from Ford Motor Company concerning this critical defect in the brake system numerous times in the past 2 years, this problem has not been resolved and I feel the car may me unsafe to drive daily.the master cylinder has been replaced to try and remedy this problem over 2 years ago. Still, brake travel and fluid has lost pressure many times since while driving. The local dealer, nor Ford Motor Company, will not comment on the recall nor the repair that is needed and estimated time this will be.
- Olive Branch, MS, USA
Dashboard around the airbag and defrosting agent is bulging and coming apart. I feel that this would be a malfunction if the airbag were to be deployed causing serious injury or death.
- Chico, CA, USA
The door handles keep breaking. They are made of junk plastic and I have had to replace 3 out of 4 door handles and the driver door 3 different times now. I also have a friend with a 2012 Fusion with the same issue. Please recall these crappy parts Ford!
- Lake Worth, TX, USA
My driver side door will not open from the inside. Thru extensive research I have found that this seems to be an issue on the Fusion years 2007- 2012 models. It seems to be that a crack forms in the handle causing the cable to come out of place. This happens when the car is stationary.
- Ogden, UT, USA
Takata inflators- been waiting for years for Ford to replace. Safety issue for passengers.
- Atlanta, GA, USA
The dashboard warped and the affected areas are the center dashboard and the passenger side. The airbag light is still on after getting the airbag recall fixed.
- Riverside, CA, USA
Takata recall: The airbag is opening. Also the long bar on the dashboard close to the front window, the left side has popped up. There was no accident!
- Chula Vista, CA, USA
I was driving home from campus and my suspension started acting up. It started firing up and down and fluctuating a lot. I had to pull off the highway and take backroads. It was still acting up the entire time. The "check engine" light and "wrench" light both came on simultaneously. I could barely go over 35 mph without the RPM flaring up past 5000 and it felt like my whole engine was going to give out. Even when I was going 20-25 mph, it felt and sounded like I had the pedal to the floor. The aaa guy who towed my car said that I had the same transmission part number as a 2010, which got recalled for faulty transmissions. My car only has 40,000 miles on it so there is no way I should be having issues with the transmission unless the part is faulty or it is something I am unaware of.
- Cincinnati, OH, USA
The inside door handles break very easily have replaced twice. When broken and have to wait for replacement the door will not lock even manually and I feel unsafe due to someone having access to car whilr at stop, light or when parked in public areas
- Harlingen, TX, USA
The department of motor vehicles has contacted me about my 2008 Ford Fusion it has a recall with the airbags that could kill or seriously injured or me or any of the passengers if it deploys, my airbag light stays on I bought it at Ontario sales in lockport New York, when I bought my car the people had already told me that there was a recall on it and I should be getting a letter in the mail that was about a year ago 2017
- Lockport, NY, USA
Dash board is warped. Took it to the dealership where I was told that they no longer had the dashboard. This dashboard is so warped it is an issue to the airbags.
- Ceres, CA, USA
On the passenger side of the dashboard where the passenger airbag, and the dashboard meet, the dashboard has separated from the airbag compartment resulting in a bell shaped curve rising approximately 1 1/2 inches above the airbag deployment compartment. If the airbag were to deploy, it could be affected by this amount of risen dashboard. I've also seen this in other 2008 Ford Fusion. Sent letters to Ford, and they refuse to help out.
- St.Paul, MN, USA
The dashboard is bulging it doesn't look good and it doesn't feel safe. I wonder if it would activate correctly at an impact during an accident or if it would activate while riding down the road. It started on the right side passenger and it has slowly moved to the left side driver. This started happening over 2 years ago and it's slowly become worse. Ford needs to be held accountable for the fix this is cosmetic but it also is functional with the airbag right behind it where it started.
- Monroe, NC, USA
When the ABS is engaged, brakes go soft/are lost. This has happened 3 to 4 times so far. So when the ABS activates, I lose about 80 percent of my braking capability and have to push the brake all the way to the ground for it to even slow down the car. It does not even stop the car, it just slows the car a little bit. The car then needs to be restarted for the brakes to work again. The most recent incident of this was in Washington DC. The ABS engaged on a city street and the car rolled into the intersection because the brakes failed. There was no collision but only narrowly.
- Lavale, MD, USA
My dashboard is separating from the car. It is getting so bad that now it is separating from where the passenger air bag is at. The other issue is that I have in the passenger door an imploded airbag that has caused a bubble in my door. My car has not been in any form of accidents for either of these items to occur. As for my airbag that has been on recall for 21/2 years and has yet to be handled, yet my brother in law and my cousin have both had their cars fixed (not Ford) which makes me wonder what the issue is.
- Cere, CA, USA
- West Chester, OH, USA