Was traveling 45 mph wrench light came on and stalled.

- North Ridgeville, OH, USA

The contact owns a 2011 Ford Fusion. The contact stated that the vehicle failed to start without warning. The vehicle was taken to the dealer, who diagnosed that the battery cable assembly was burned, causing five fuses to malfunction. The manufacturer was made aware of the failure. The vehicle was repaired. The failure and current mileage was 51,960. Updated 01/07/14 updated 1/17/2014

- Denton, TX, USA

While driving at all times, the vehicle would start to surge and buck then loose power. It never completely died but when I pulled over it ran terrible and would not accelerate. I turned it off for a few seconds and restarted it. It would run for a while, good, then the problem would reoccur. The engine light came on, I had the code checked. The result was a faulty throttle body or sort in the throttle body module.

- Crown Point, IN, USA

My wife had my 6 month old sign in the backseat when she was pulling out from a stop sign into a 4way when the car lurched and the accelerator quit responding in the middle of the street a truck nearly T boned her on the driver side where our son was in his car seat upon diagnostics the electronic throttle body was stuck open. I've found similar issues with similar vehicles although the dealership informed me my vehicle is not currently on a recall list.

- Cherokee Village, AR, USA

This has happened multiple times varying from accelerating from a stop to highway speeds of 60+ mph. 2011 Ford Fusion sel suddenly loses all power and wrench icon illuminates and no acceleration happens at all. The engine remains at idle with fluctuations from 800-1200 rpms. Had to cross multiple lanes and was almost ran into by three cars going a lot faster than me while I was listing to the emergency lane. Once car is turned off and restarted the problem will go away. After much research and the one time it showed a check engine light I ran the codes and it all was pointing to a defective throttle body. I noticed that there are a lot of complaints with this aspect on this car and just hope someone doesn't have to get killed on the road like I almost did to get a recall on this car and part.

- Atlanta, GA, USA

On September 15, 2013 I was driving on a major surface street at approximately 35 miles per hour when the car just stopped working. Completely powerless. I saw two lights on the dashboard: The battery and the oil. There may have been more but I was more focused on safety and oncoming traffic than the lights on the dash. I decided not to take a chance of getting rear ended (injured or killed) so at the first big break in traffic I safely exited the vehicle and walked over to the sidewalk (one lane over). A local apartment resident saw the incident and grabbed a safety cone to put behind my car as a warning. Thankfully there were no accidents but there were some close calls and last minute lane changes as drivers came upon my car. I called Ford roadside assistance and they sent a tow truck to get the vehicle. It started up perfectly for the driver, but I had it towed anyway. It has been at the dealer for two days. They have been unable to duplicate the situation and have received no "codes" to indicate a problem with the vehicle. They have called Ford to ask for assistance and Ford has asked them questions regarding lights going on, my speed at the time of the incident, how far I had been driving the car before the incident, etc. This is the second time I have had a problem with my 2011 Fusion completely failing. The first time was in September 2012 when the throttle failed on the freeway. It was supposedly fixed. This time the lost of power did not feel like the throttle. It just stopped working. Had power. Didn't have power. I am extremely concerned that the dealer will find nothing wrong with the vehicle and it will be returned to me in an unsafe condition. Others have reported this and similar issues. Please get these vehicles recalled before someone loses a life.

- Santa Ana, CA, USA

Car dies while driving, surges at times, had been happening on and off. Died part way through a large intersection on 7-13-13, luckily I just avoided a collision. It would start and go a few feet, then surge and die. Called crater lake Ford in medford, or, they stated very busy that day and had not heard of the symptoms I described. Placed a call to dave's import service they said they would look at the car. Within 45 min they had diagnosed failed throttle body.

- Medford, OR, USA

My wife was driving down the highway and the engine bucked and seemed to stall, then recovered. The previous week it had stalled completely. Shortly after it stalled while I was driving it again and did not recover.

- Madison, CT, USA

Drove a mile from our home to pick up pizza. Went into the shop for about 5 minutes, came out and started the car. Backed out of the space and pulled across a divided road to head home and the car sputtered and lost power so that I had to pull over to the side. The check engine light was lit. I shut down the car and it started right up and the check engine light was clear. It repeated this issue again about 1 week later on the highway for my wife though recovered. Then again for me while accelerating up a state route but did not recover.

- Madison, CT, USA

I left from my home in the early afternoon. The car had not been used since the previous evening. About 2 miles from my house I got onto a state route and started to go up a slight hill. I had accelerated up to approximately 45 mph and the engine started running really rough, then stalled. The check engine light lit up. It seemed to go down to idle with no response from engine while pushing the pedal. I glided to the side of the road and crested the hill, then let the engine sputter at around idle as I was able to put it in neutral and let gravity take me to the bottom of the hill where I could glide around the corner into a safe parking lot. I shut the car down, waited a minute and it started back up as though nothing had happened. The check engine light was clear. I have not tried to check to see if it stored any codes yet. I had experienced 2 previous events in the previous 2 weeks with this car. The car has been serviced regularly.

- Madison, CT, USA

I have been sensing a surge in engine power for several months in my 2011 Fusion. I suspected a throttle body problem and googled for information. I found all of the information on the NHTSA website about throttle body problems for this car as well as information in other forums. It was a good thing as I was prepared for what happened today. I had just left my house when the dreaded (and expected) loss of engine power with the wrench light being illuminated. I experienced the same symptoms reported by so many complaints logged for this issue: Loss of power, rough idle, just enough power to barely move the car, certainly not enough to limp anywhere, much less home, even though the engine was in "limp home" mode. I had my code scanner with me and was able to retrieve the P2111 (throttle stuck open) code before I restarted the car to restore full power. This only worked enough to get the car turned around when limp home was triggered again. I restarted again and was able to get within a block of my house when limp home triggered once more. The third time I was able to get to my house. I called the dealer and then roadside assistance to get my car towed to the local Ford dealer after verifying that they had a throttle body in stock. The car was towed there and a defective throttle body was diagnosed and replaced. This is not a case of if the failure will happen, but rather when. I was fully expecting it any day and sure enough, it happened. I was extremely fortunate as I was less than a mile from home, knew what to expect and how to deal with it, and my car was still in warranty, but only by 1,806 miles! any other situation would have resulted in me being in a very dangerous predicament with a car that was basically dead in the water. I was almost to the point of purchasing a new throttle body on my own in the interest of being proactive rather than being stranded.

- Little Rock, AR, USA

Car experienced a sudden loss of power during acceleration from a stop sign. Lost 99% of power and missed heavily. Nearly rear-ended. Pulled over, turned car off, waited a few minutes and restarted the car. Ran fine. Drove approximately 15 miles and 25 minutes before parking the car; problem did not recur. Drove approximately 20 miles and 30 minutes to dealership; problem did not recur. Dealership diagnosed the problem the same as many of the complaints on this website - the throttle body actuator is sticking. $400 repair. Information online indicates that this is a new throttle design by Ford, so in essence, Ford is experimenting on my dime. Not acceptable.

- Strasburg, VA, USA

The engine shook violently. The wrench light and check engine light suddenly appeared. The speed of the car went from 45 mph to 0 in an instant. Then the entire car powered off. I managed to pull over to the shoulder as this happened and not being able to accelerate at all. I turned the car on again with keys in ignition. Started to drive and the same series of events happened again and my car completely powered off. I got my car towed to Ford malcolm cunningham on 8/26/13. They confirmed it was the throttle body that caused the issues. I purchased extended warranty on my car which only covered the actual part and not the labor to replace the throttle body. The dealership service rep, [xxx], said that they recommended I also flush the engine because they have seen this is related to the throttle body issue. She also said the throttle body issue is a common problem with Fusion and escapes, as she had another person in there for the same issue on an escape. Ford needs to realize this is extremely unsafe and issue a recall asap! I cannot believe my car is practically new and I'm out of pocket $400, while Ford doesn't take any responsibility. Information redacted pursuant to the Freedom Of Information Act (FOIA), 5 U.S.C. 552(B)(6).

- Sandy Springs, GA, USA

Three issues have arisen in the last month: 1) while slowing down to turn a corner, to stop or after a stop and starting to accelerate, my car stalls 2) at a stop light, my car jumps - will intermittently stall when going to accelerate 3) after putting gas in the tank it is very difficult to turn over.

- Hoschton, GA, USA

I was driving with my daughters in the car in the middle lane of a 3 lane highway. I was traveling the speed limit, at or around 55 mph, when all of a sudden the car went limp. There was no acceleration and the car immediately began to coast. A wrench light and the engine light went on. With no ability to speed up, I had to navigate through two lanes of high speed traffic with a paralyzed car to get me and my children to safety. Luckily, I was able to do so. The dealership informed me that this doesn't happen very often, and that unfortunately, this repair would not be covered under the power train. They ordered and replaced the throttle body. Upon investigating this issue online, I was shocked to discover that this problem is so prevalent. The fact that Ford is covering this up and pushing the costs on to its customers is frustrating (more than $1300 in my case), but the fact that they are willing to risk the lives of these very same customers is downright disturbing. There should be an immediate recall on all the cars affected by this throttle body issue, as well as a full reimbursement for all those who have had to suffer through this already.

- Englewood, NJ, USA

Dash board reports power steering assist fault. Difficulty steering. Drive to parking place. Turn car off. Two hours later return to car. Turn on car and the power steering is ok. Second fault at 46045 miles. Car was parked. Turn car on. Power steering assist fault. Turn car off. Turn car on. Power steering ok.

- Concord, MA, USA

Went to start car and it would not start. Ford roadside towed it the next day. After trying various things for 3 weeks Ford engineering called to tell me it was due to a lightning strike. Insurance believes it is a warranty claim as the car is still under warranty; Ford will not honor this as a warranty claim. No one at Ford has been able to give me a cost for repairs already attempted or for further repairs to make the car work normally again. I feel there is a deeper electrical issue with the car, but Ford is claiming there is nothing in the car that could supply this kind of electricity to fry several modules, fuses, and light bulbs. Worried about a bigger issue which is not being diagnosed and fixed properly. Could be a safety hazard.

- Cherry Hill, NJ, USA

While driving at 60 mph on the highway, vehicle appeared to "stall" causing a sudden loss of acceleration. This occurred on three separate occasions in the past week. Vehicle malfunction caused vehicle to enter "limp" mode.

- Philadelphia, PA, USA

Driving 45mph on state road 45 in southern Indiana, which is very curvy. Let off gas, then when I went to accelerate, pedal went completely to the floor. Car then started sputtering. No acceleration at all. Finally got car off of state highway. Car never completely died, just absolutely no acceleration, throttle body sensor bad! this is a safety issue! had I been going faster and vehicles behind me, there would have been a major accident. Cost $580 to repair on a 2011 car! according to the Ford technician that repaired my car, they have replaced several in the last 6 months! very disappointing for Ford not to recall sure a important repair!

- Unionville, IN, USA

My wife was driving her car when the check engine light came on, it reduced engine power and would not accelerate. She turned it off, then restarted it. She drove home with no further incident. This was June 1st. It happened a few more time through June and July and we had a competent mechanic clean the throttle body after the code he scanned said throttle body was stuck closed/stuck open. This did not fix the problem. On the way home from dinner with my family on August 3, we made a turn across two lanes of traffic. In the middle of the turn, the wrench light came on, car lost power, and we were essentially dead in the water while making a turn. The vehicle coming down the lane happened to see us in the middle of the road. Had they not braked, we would have been T-boned. It happened the next day on the interstate. Not very confidence inspiring to travel at 70mph, then have your car not go over 900 RPM. Look for a shoulder very quickly. In all instances, car goes to reduced engine power (which limits it to 900 RPM). At a stop light, the idle is very erratic going from 1000 RPM down to about 400.

- Hephzibah, GA, USA