I drive a 2018 Ford fusion ecoboost. It started with a misfire on cylinder 4 and in that same week the engine started to over heat. Had the spark plugs replaced. Upon checking and monitoring coolant levels noticed I was losing coolant. Wasn't having any puddles in the driveway and no visible leaks under the hood. After few trips to work and home the engine would overheat and my work is less than 2 miles from my home. Started to quickly get worse, more codes popping up on my fixt obd2 scanner. From po304, PO300, PO303, B124D, PO313, PO316, PO317.

- San Bernardino, CA, USA

My car has stalled out coming up to a stop sign. It makes a sound coming from gas tank. I can not turn it off while pumping gas because it will not start after pumping gas. It is the purge value according to my mechanic. I know the recall on this issue is on the focus models but the fusion is basically the same car

- Jqckson, MO, USA

I PURCHASED THE CAR [XXX], FEW WEEKS LATER THE CHECK ENGINE LIGHT CAME ON THEN DISAPPEARED, I WAS ALSO EXPERIENCING PROBLEMS WITH THE SEAT COOLING FUNCTION, AS THE TOUCH SCREEN CONTROLS WAS SHOWING THAT THEY WERE BOTH ON AND IT WAS STILL WINTER/RAINY SEASON OUTSIDE. I TOOK THE CAR INNTO FORD DEALER AT SAN BERNARDINO CA, THEY TOLD ME THAT MOST LIKELY IT WAS JUST A DASHBOARD LIGHT MALFUNCTION BECAUSE THE DIAGNOSTICS RESULTS CAME OUT FINE AND AFTER RESEARCHING IN OTHER MANUALS EVEN THOUGH THE SEAT COOLING FUNCTION WAS SWITCHED TO "on", THE CAR DID NOT COME EQUIPPED WITH SEAT COOLING ONLY HEATED SEATS. 3 WEEKS LATER AFTER TAKING MY CAR HOME, THE CHECK ENGINE LIGHT CAME ON AGAIN ON Y DASHBOARD, I BOUGHT AN OBDII DIAGNOSTIC TOOL, THE RESULT CAME BACK WITH 2 DIFFERENT POWERTRAIN CODES THAT WERE STRICTLY MANUFACTURER CODES. 1ST CODE WAS P1450 WHICH IS DEFINED AS UNABLE TO BLEED GAS TANK - EXCESSIVE VACCUM. 2ND CODE WAS P2196 WHICH IS DEFINED BY O2 SENSOR STUCK TRYING TO CORRECT 1ST CODE. THE P2196 EVENTUALLY CLEARED ON ITS OWN BUT THE P1450 BECAME PERMANENT. I HAD A DIAGNOSTIC MECHANIC TAKE A LOOK AT IT AND HE TOLD ME THE SAME THING, EXCEPT THAT THE MAIN CULPRIT IS THE PURGE FLOW VALVE, WHICH IS A RECALL ISSUE ON OTHER FORD FUSIONS. WHEN I PURCHASED THE CAR, I WAS SHOWED THAT THE CAR HAD NO RECALLS BUT THE "MYFORD" APP AND OWNERSHIP DIDNT TRANSFER TO ME RIGHT AWAY UNTIL 30 DAYS AFTER THE PURCHASE, WHICH IS WHEN IT FINALLY LET ME VIEWED THE CARS PRIOR SERVICE / MAINTANANCE HISTORY AND EVEN THOUGH THE CAR SALES LADY SHOWED ME VIN RECORDS WHERE IT SAYS THERE IS NO RECALLS AND IT HAD NO ACCIDENTS, RECORDS THAT SHE SHOWED ME 30 DAYS PRIOR TO ME GAINING ACTUAL OWNERSHIP THRU "MY FORD" WHEN PURCHASING THE VEHICLE. THE "MY FORD" APP STATES THAT IT SEEMS AS IF THE CAR WAS IN AN ACCIDENT IN THE PAST BECAUSE ALMOST $8000 WENT INTO REPAIRS TOWARDS TRANSMISSION AND OTHER MAIN COMPONENTS. CALIFORNIA SMOG CHECK RECORDS SHOW THAT THE CAR HAS ONLY HAD 1 TEST IN CA LAST SEPT 2023. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATIO

- Fontana, CA, USA

Coolant is leaking into my oil.

- Van Nuys, CA, USA

I went on a road trip to see family which needed 5 hours of travel. After returning and parking the car, I noticed a knocking noise coming from the engine bay when it was started and was idling. After doing what I could to rule out possible problems I concluded the Flexplate might be the culprit due to Recall 22N12 with Ford. A short time later, my car started to stall if I did not keep my RPM's high enough while my vehicle was stopped. After getting an inspection done with a dealership they confirmed that it is the Flexplate. The symptoms gradually got worse which is what ultimately led me to bring it in to a dealership instead of a different shop. The problem is that this repair estimate I got says this repair is going to cost me $3,000. I am arguing that my vehicle should have been on Recall 22N12. After contacting Ford and going back and forth for 2 and a half hours they told me i'm out of luck and that there was nothing they can/will do about this.

- Winnebago, IL, USA

M 19 year old daughter purchased the 2018 Ford Fusion 1.5L FWD certified on May 10th from AutoNation Ford of Orange Park, FL on 5/10/2023. Car broke down on 7/31/23 at 93032 miles and had it towed back to AutoNation. Was told that the flexplate broke and that there was coolant intrusion in one or more cylinders. Had the car repaired using the extended warranty plan that was purchased for the engine repair. Also paid to have the flexplate replaced. Received the car back on 9/22/23 with 93041 miles. On 9/26/23, check engine light at 93173. Code read oxygen sensor and emission purge valve sensor. Did not have repaired right away so that we can save up for the cost since it wasn't covered by the extended warranty plan. The cost was going to be about $700. Then the car started to hesitate in traffic while making a loud "farting" noise and eventually breaking down on 11/8/23. We were able to get it to Garber Ford in Green Cove Springs but was told by the mechanic that the car is to dangerous to drive anymore. After a diagnostic was performed, we were told that not only is the evap purge valve bad, the car now needs a new transmission. The transmission pours out as fast as they can put it in. Due to the broken flexplate being noted during the first repair, its highly likely that the warranty company will cover. Estimated cost is 10k if we approve the breakdown and they deny. If we do not approve the breakdown so that insurance can inspect and just replace the transmission it will be 7-8k.

- Middleburg, FL, USA

On May 26, 2023, after I started moving from stop at a traffic light, I rear ended the vehicle in front of me when it came to a sudden stop. My speed was between 25 - 35 mph at most. My front and side curtain airbags deployed, the hood was crumpled and fascia was damaged as expected. However after 10 minutes or so, flames started coming from underneath the hood and within a few minutes the engine compartment was on fire. The Fire Department arrived and put out the fire but had to break the windshield and rip off the fender to aim the fire hoses.

- Rochester Hills, MI, USA

When I stop to get fuel/gas for my car, I am unable to turn the ignition off because if I do, the car will not restart immediately or at all. There is also a jerking motion immediately after fueling and while driving. There is a "wailing" noise immediately proceeding the car shutting down. The check engine light is on.

- Lauderdale Lakes, FL, USA

Fuel vacuum system failure. Results in the check engine light coming on. Vehicle has died in the middle of the highway. Took vehicle to mechanic and they stated that this is a very common issue they have fixed in over half of the ford fusions he has seen. Vehicle will cut off and will not start. Shows a code for fuel/emissions.

- Fort Worth, TX, USA

My transmission has start to work weirdly. My car started vibrating when I am driving slow. When move to second gear suddenly the car make stop and move again.

- Sacramento, CA, USA

The fuel door not opening. The dashboard shows fuel door opening and it doesn-??t. After watching some YouTube videos at the gas station not knowing what else to do I have to now open the trunk and use the emergency release. Nothing seems wrong once it is opened. I found out this is a problem for others with knowing other people posted videos on YouTube with the same problem.

- Marysville, CA, USA

I stopped at a gas station in 0 digit degree weather fahrenheit and when I tried to insert the pump into the capless filler, it was frozen guy the actual inner latch that opens to the tank itself. I tried to gently apply pressure and I could not get it to open after trying for 3-4 minutes. Luckily I was close to home since my gas light can come on and I didn't have a lot of gas left, but that also means my car is sitting in extreme cold right now with very little gas, which I believe poses a risk to line freezing. More important, what if I hadn't been as close to home" What if, while trying to drive around and fine someone to help me, I ran out of gas" If a person was in a more rural environment then I am, they might not be quickly seen and might be stranded with a car that can't provide heat any longer and in extreme cold.

- Chicago, IL, USA

Check engine light, lots of white smoke out of tailpipe and dark black spark plugs at 15,000 miles! dealer said I got bad gas or vandalism therefore no warranty coverage. I had to pay a local mechanic to replace spark plugs, pump out and replace fuel. Two weeks later I receive a Ford letter stating coolant can leak into the cylinder bores causing exactly happened to my vehicle. Now I have to seek reimbursement.

- Merced, CA, USA

While driving on I-95 in extremely heavy traffic the 2018 Ford Fusion suddenly decelerated and indicating lights came on. It was harrowing and extremely dangerous to navigate the disabled vehicle. The Ford dealer states the throttle body needs to be replaced. This is interesting since, the car is only six months old. Additionally, this is a known on other (older) Ford models which makes me suspect they are using known defective parts.

- Glen Allen, VA, USA