When washing the truck I noticed a crack in the left rear frame just aft of the forward leaf spring shackle.Vertical crack approx, 6" long and separating, frame severely rusted while the rest of the body has minimal rust.

- Canton, OH, USA

My vehicle is otherwise in very good condition but try is frame is very worrisome. The rust makes me afraid to drive the vehicle confidently.

- Nashville, TN, USA

I was driving was about 20 mph and hit a small pot hole. I heard a loud pop bang noise and the left side of truck dropped about 2 or 3 inches. I thought the front end fell off. The frame is rusted so bad you can punch holes is the frame with a screw driver, the driver side torsion bar has collapsed due to rust on the frame that holds it in place, the crossmember to transmission is barley holding transmission up, the spare tire area is rusted in half, all main crossmembers are rusted in half and the frame is rusted in half behind fuel tank. Truck has 127K miles and the body body has little to no rust, upper and lower control arms are unsafe from rust. I do not understand how the body can be so good but frame and suspension is completely rusted to no return.

- Spotsylvania, VA, USA

I have a 1999 Ford Ranger and the frame is shot starting to crack it's so thin and like post I can almost bend it with my hands.

- Clinton, ME, USA

Spare tire fell off in street, then gas tank, whole frame is rotten, was driving down a road,

- New Bedford, MA, USA

The frame is rusting away. Both leaf spring shackles rusted completely through, muffler hangers all rusted off lost my muffler on a road.

- Belleville, MI, USA

Frame rust under drivers and riders doors. Rest of truck looks beautiful and I take great care of the truck!!!

- Hot Springs, VA, USA

The contact owns a 1999 Ford Ranger. While inspecting the vehicle, it was discovered that the rear section of the subframe was rusted and corroded. The cause of the failure was not diagnosed. The vehicle was not repaired. The manufacturer was notified of the failure, the local dealer was not notified. The failure mileage was 192,000.

- Burnsville, VA, USA

Drivers side frame has completely rusted through. Found during inspection.

- Greene, NY, USA

Rear frame and rear cross member have rusted out.. the spare tire holder is unusable. Vehicle should be recalled for frame replacement.

- White River Junction, VT, USA

Frame rot... the frame has rusted from the inside-out in the same place on both sides of the vehicle: Under the most-front part of each door (keep in mind this is the frame I'm talking about, not any kind of door support or framing... this is the section of body frame that is located underneath each door on the vehicle). The frame has rusted and begun to split horizontally (the length of the vehicle) and vertically (from the ground-up). When lifting the vehicle in certain places, the frame can be seen bending, obviously. Because of this I can only jack/lift the vehicle from the very front... all other places that I've tried to lift from result in too much weight being put on those weak points. I am now very seriously considering a new frame, which is a lot of money... or, at the very least, a lot of time and effort to pull a frame off of a vehicle from a junkyard, then put it on my vehicle (or rather, put my vehicle on it). Frame failure could result in catastrophe or death, and this frame is in very bad shape compared to most vehicles it's age (and many that are older).

- Pinson, AL, USA

My 1999 Ford Ranger just failed inspection for structural reasons. Truck runs perfect with only 107K miles on it. The truck is rotting away !! gas tank falling off. Rear bumper falling off. Tail gate rotted. Significant rot in frame and shocks. Spare tire ready to just fall from cheap strap that is rotted. This really is unsafe situation. I called Ford and filed complaint but was told nothing they can do. I will never buy another Ford!! a happy customer tells 2 people, an unhappy customer tells 100 people. I really can not believe these vehicles were not recalled. Very unsafe.

- York, ME, USA

Frame rusted into

- Nickelsville, VA, USA

The contact owns a 1999 Ford Ranger. The contact stated that there was extensive rust near the rear frame close to the leaf springs. There was also excessive rust on the rear passenger side. The contact further inspected the rear frame and determined that it fractured due to the failure. The vehicle has remained parked in the contact's driveway since the failure was identified. The manufacturer was notified. The failure mileage was not available.

- Abingdon, VA, USA

The contact owns a 1999 Ford Ranger. While the vehicle was being inspected, the mechanic noticed that the subframe was rusted. The vehicle was repaired; however, the frame fell off. The manufacturer was not notified of the failure. The approximate failure mileage was 100,000.

- Mechanic Falls, ME, USA

The bed is rusting off the Ford Ranger pt. To where, the bed needs to be removed from the back, and redone !!! this vehicle was not made well for cusumers ppl can't always afford what the company has done. Its not fair too put a vehicle out and we have to pay out of pocket for Ford poor work when making this vehicle.

- Pickerington, OH, USA

Perforated frame on the left rear frame near the front of the leaf spring, rear frame horn where bumper attaches is perforated also. Sections of frame will have to be welded in to keep vehicle in a safe condition.

- Niles, IL, USA

The frame at the right front suspension pocket rusted out. Upper control arm rear bracket is completely detached. Drove the truck to my destination with no issues, on the return trip it felt "floaty" as if it was out of alignment while I was driving down a town road. There was no bump or audible noise prior to or accompanying the issue. Body has very minimal rust, the rest of the frame appears solid. Truck has 104,660 miles.

- Clinton, MA, USA

My complaint is just how rusted away the frame is on my 1999 Ranger, the body of the truck is real nice. But the frame is rusting away, the rear bumper broke off on the drivers side, the spare tire can no longer be mounted underneath where it belongs, due to the rust. The frame rail has a foot long rust hole on the passenger side and the drivers side rail is cracked and rusted almost in two pieces. Just seems like the frame is totally rusting away, never had a vehicle with this kind of rust problem. I afraid to drive it on the highway.

- Cleveland, OH, USA

Frame and frame supports have rusted quickly over the last few years. More than I would expect.

- Papillion, NE, USA