The contact owns a 2000 Ford Ranger. The contact noticed that the subframe was corroded. The vehicle was not diagnosed nor repaired. A dealer was not contacted. The manufacturer had not been informed of the failure. The failure mileage was approximately 153,000.

- Lincoln Park, MI, USA

Frame has rusted to the point where it is unsafe to drive.

- San Juan, TX, USA

Both the back seat small doors were locked and unoperable since 2015 (the dealer refused to repair without paying for service- they said will cost $1,000 for each door and just to exam cost. That was not the repair cost yet) 2020 in August, perhaps, the back gate door for the trunk suddenly collapsed, felled out from the roller. That was the passenger side of the back gate to the bed of the truck I had to put back to the roller. And, it is not sure that the gate is stable condition. Under the dashboard, the cigarette lighter just touched and collapsed-broken inside under the dashboard and could not pull it out. So, it is still inside under the dashboard (notice: That feature-the cigarette lighter nobody used since bought the vehicle- non smoker owner). The under body vehicle cost a lot to repair through the years. The vehicle has about 120,000 miles currently.

- San Antonio, TX, USA

Frame is rotted with only 75,000 miles on vehicle. Seems as truck will break in half

- Taunton, MA, USA

THE CONTACT OWNS A 2000 FORD RANGER. WHILE DRIVING, A THUMPING NOISE WAS PRESENT COMING FROM THE VEHICLE. AFTER PARKING, IT WAS DISCOVERED THAT THE BED OF THE VEHICLE WAS DAMAGED AND MISALIGNED. ALSO, THE DRIVER AND PASSENGER SIDE FRAME BEHIND THE CAB WAS FRACTURED DUE TO RUST AND CORROSION. THE CAUSE OF THE FAILURES WAS NOT DETERMINED. TODD JUDY FORD (7891 MACCORKLE AVE, CHARLESTON, WV) AND THE MANUFACTURER WERE BOTH NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 260,000. Broken frame

- Given, WV, USA

Rust on frame, radiator support and under carriage.

- Mastic Beach, NY, USA

Massive amounts of rust on frame, front and rear bumper, leaf spring shackle brackets, bracket holding body to frame., and radiator support.

- Mastic Beach, NY, USA

Tamara recall my paint is bubbling and chipping

- Hilmar, CA, USA

The frame is rotting away.the bed is about to fly off, and I fear the rear bumper, and spare is also.the truck is still running good, but I am very hesitent about using it.

- Shamong, NJ, USA

I was driving my truck down a main road and there was a small pothole.it was only about an inch deep by about a foot and all of a sudden my truck started making very loud noises going down the road and almost seeming like the truck didn't want to go straight. I pulled over because I wanted to check it and here was a massive crack in the frame behind the shackle mount in the front of the wheel well. This was caused by the gas tank mount that the strap connects do holding dirt and moisture behind it and rotted out a hole in the frame. Also the gas tank mount rotted compleatly out and is no longer there on the drivers side the same place that the frame rotted out. This is a big defect by Ford as there is no way to clean it out and the frame will just rot even though the body of the truck is spotless and rust free because I wash the undercarriage every week as well as the whole truck. This is extremely unsafe because the moisture and dirt consistaintly eat away at the frame. Also it is bad enough that I possibly need to take the truck off the road even though the rest of the truck is perfect. It is very unsafe to drive and I can't believe Ford could have over looked this.

- Goshen, CT, USA

Frame and crossmembers have severe flaking rust and frame rot on rear section of frame behind the cab. Leaf spring brackets broke and ripped out of frame this section has been replaced apx 2 years ago. Back spare tire rear crossmember has rusted completely out and is in the process of being replaced. Bed support crossmembers all rusted almost completely out leaving bed weak. This is in the process of being replaced. Gas tank cross member has rusted out around bottom of mount and also up the inside of the frame rails. Gas tank holding straps are in process of rusting out and breaking. These are being replaced.

- Williamsburg, OH, USA

I recently bought this vehicle and only noticed how severe the rust was after the purchase. My vehicle is extremely rusted on the bottom and has several rust holes on the front passenger side of my vehicle. Knowing that at any moment one bump could finish the job and blow the frame off is not great. A recall for the extreme rust damage would be greatly appreciated since I have no other way to fix this.

- Manhattan, KS, USA

Car chassis is rotting very bad even with no salt around and never used to beach. Have a hole throught the chassis near rear driver side.

- Center Moriches, NY, USA

Frame rusted out

- Clifton Park, NY, USA

The contact owns a 2000 Ford Ranger. While driving 35 mph, the vehicle drove over a pothole and the subframe twisted sideways. Upon inspecting the vehicle, the contact became aware of several issues pertaining to the rear, driver, and passenger sides of the subframe, including severe corrosion to the spare tire support and the fuel tank strap was fractured due to corrosion. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The approximate failure mileage was 146,000. Updated 10/24/17

- Edwardsville, PA, USA

The contact owns a 2000 Ford Ranger. During an oil change, an independent mechanic noticed and informed the contact that the frame was completely rusted. There were no warning indicators illuminated. The manufacturer was not made aware of the failure. The vehicle was not repaired. The failure mileage was 186,000.

- New Philadelphia, OH, USA

The contact owns a 2000 Ford Ranger. While operating the vehicle, a rattling type noise was present under the vehicle. Upon inspection, it was discovered that the leaf spring shackle connected to the subframe failed due to rust and corrosion. The cause of the failure was not diagnosed. The vehicle was not repaired. The manufacturer was notified. The contact was informed that the replacement components needed to repair the vehicle were no longer available. The VIN was not available. The failure mileage was 85,000.

- South Bend, IN, USA

Going over a bump on city street leaf spring broke. Frame around radiator is completely rusted away. Under body frame rusted as well.

- Omro, WI, USA

Lower control arm body frame mounts rust on both sides.....................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................

- Phila, PA, USA

Rear frame rusted badly. Was repaired was costly as well as rear bumper.

- Rochester, NH, USA