1.3
hardly worth mentioning- Crashes / Fires:
- 0 / 0
- Injuries / Deaths:
- 0 / 0
- Average Mileage:
- 128,379 miles
About These NHTSA Complaints:
The NHTSA is the US gov't agency tasked with vehicle safety. Complaints can be spread across multiple & redundant categories, & are not organized by problem. See the Back button — blue bar at the very top of the page — to explore more.
U guys issued recalled all GMC vehicles for a leaking gas ck valve on gas tank no matter how long in service stationary or on motion ck with my local dealer karl Chevrolet ankeny Iowa they say expired I'm 2017 at 150000 your recalled as long as in service.
- Desmoines, IA, USA
The fuel fill line is broken from the gas tank. I was filling the tank for holiday travel and the the tank began to leak. Every tank that is ordered by the repair shop is damaged in the same place
- Collinsville, AL, USA
Bulletin no.:14423 date: November 2015 part number: 15077622 tank, fuel (18.7 gal.) the icv is located above the full fuel level. A fractured icv could allow fuel vapors to pass through and droplets of fuel to accumulate on the side of the fuel tank as it passes over the fracture during refueling. If the icv fractures, the vehicle's service engine soon (ses) light may illuminate, and you may notice a fuel odor and/or a few drops of fuel on the ground when refueling the vehicle. This has happen to me and now my tank needs to be replaced. This is a known issue with GMC Envoy regardless of year or how long they are in service. The company needs to be held accountable for poor quality of parts especially when it is a safety concern and hazard with fuel odor coming into the cab of the vehicle and spilling out when going up a hill. Being told to only fill my gas tank up half to three quarters full due to that part being broken is the wrong answer. In motion when I smell gas and then notice it when I fill the vehicle up and it started pouring out.
- Warrenton, VA, USA
2 years ago the maintenance required light has been on, when checked by 2-3 mechanics they said it could be the gas cap. That didn't remedy the situation, the light stayed on, then recently the fuel gauge started dropping to empty after a little less than half a tank was used. Then filling the gas tank caused it to overflow if you fill it to full. As of today the car when shifted into reverse, something came loose inside the shifter, now it is stuck in neutral.
- Tahlequah, OK, USA
Strong smell of gas and leaking from top of tank.
- Sudbury, MA, USA
Leaking fuel on tank at fuel neck...fuel fumes, fuel on ground may cause fire, not environmentally safe as fuel is dumping on the ground where ever you drive
- Bellevue, MI, USA
Crack in filler neck where it attaches to the gas tank.
- Greensboro, NC, USA
It started with engine misfiring causing engine to jolt which damaged #4 coil pack seal to failed allowing water intrusion. In 2008, the GMC mechanic replaced all six coils seals but in 2013-present P0440 engine code is a leak in the evaporative emission (evap). Loose fuel tank filler cap is the most common cause that triggers the P0440 code. I failed a few smog check spending hundreds of thousands of dollars yet my problem still existence. I've contacted the bureau of automotive repair because purrfect auto in fullerton, ca lied about fixing my car. The bar made purrfect auto replace the gas tank and gas cap yet the engine light is still on displaying code P0440. Its been 14 years and I'm still dealing with this problem.
- Seal Beach, CA, USA
The contact owns a 2003 GMC Envoy. While the vehicle was in the garage and while driving, the odor of fuel was present. The vehicle would also shudder and hesitate while driving. The vehicle was taken to the dealer where it was diagnosed that the fuel pump was faulty and needed to be replaced. The manufacturer was notified of the failure. The failure mileage was 145,000.
- Cincinnatti, OH, USA
I smell gas all the time when I am driving
- Clay, KY, USA
Where the top of the nesk of the fuel tank meets the fuel pump it is broken where the 2 meet. Fuel vapors, as well as actual fuel leaking on the ground R both present. Stationary, as well as, in motion.
- Little Rock, AR, USA
The contact owns a 2003 GMC Envoy. After refueling the vehicle, there was a strong fuel odor present. The contact noticed the fuel tank was leaking fuel. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 120,000.
- Manteca, CA, USA
The contact owns a 2003 GMC Envoy. The contact stated that there was an abnormal odor coming from the rear of the vehicle. The contact inspected the rear of the vehicle and discovered that the fuel tank was damp. The vehicle was driven to an independent mechanic where it was diagnosed that fuel tank sending unit had corrosion and needed to be replaced. The vehicle was repaired. The manufacturer was notified of the failure. The approximate failure mileage was 99,991.
- Candor, NY, USA
In 2013 we took R vehicle to get smoged it wouldn't pass the mechanic said there is a crack in the gas tank and they can use some stuff on it to patch it, now a year goes by my son is using the car putting gas in the at the station and another lady tells him your leaking gas took it to the Chevy in tracy ca they said there was nothing they could do there was a recall on this vehicle and they couldn't do anything about it and my husband told them we never received a recall notice about this and he said there was nothing they could do and it would cost us $1600 now my GMC is setting in my driveway and we R too afraid to drive it that it will catch on fire and its undrivable the neck going to the gas tank is cracked, my son drove this vehicle with his baby for quite awhile and this has scared me to death I think GMC needs to make this right and fix this problem on my car we would of taken it in right away if we had know about it and that there was a recall.
- Patterson, CA, USA
I started experiencing a strong smell of gasoline while driving and when the vehicles was shut down. When I first noticed the odor I could not see any visible leaks under the vehicle, after about a week I started noticing drips of fuel under the vehicle. I crawled under the vehicle to find the leak and noticed a very fine spray of gasoline coming from the top of the tank. I then dropped the fuel tank and noticed that tube from the fuel pump was corroded to the point that it was spraying gasoline while under pressure. The fuel pump is located in a low point on the top of the tank which allows for road debris/salt and water to sit and erode these tubes on the top of the fuel pump. This is a very dangerous problem as all it would take is any form of ignition to cause an uncontrollable fire. GM should be required to repair this under a mandated recall due to the severity of this problem.
- Auburn Hills, MI, USA
The contact owns a 2003 GMC Envoy. The contact stated that an odor of gasoline fuel was present inside and outside of the vehicle. The contact inspected the vehicle and discovered a fuel leak from the top driver's side of the fuel tank. The contact indicated that the fuel leak only occurred when the engine was powered on. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The failure mileage was 73,000.
- Clifford, MI, USA
My car is reaping with the smell of gas on the inside and outside of the car. I called GM customer care center about this problem being hazardous and all they offered was a $150 voucher available at the GMC dealership. I am confused as to why 2006/2007 models were recalled for this matter and the 2003 model was not recalled. I am afraid to drive this car because I believe it will explode!
- Lima, OH, USA
Some times when the brakes are applied the throttle also advances causing unwanted acceleration. Happens at low speeds. Have there been any factory recalls for this problem?
- Kent, WA, USA
The contact owns a 2003 GMC Envoy. The contact stated that after refueling, the fuel gauge would read empty. The vehicle was not inspected by a dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was approximately 90,000. The current mileage was approximately 100,000.
- Delco, NC, USA
- Salinas, CA, USA