1.7
hardly worth mentioning- Crashes / Fires:
- 0 / 0
- Injuries / Deaths:
- 0 / 0
- Average Mileage:
- 97,228 miles
About These NHTSA Complaints:
The NHTSA is the US gov't agency tasked with vehicle safety. Complaints can be spread across multiple & redundant categories, & are not organized by problem. See the Back button — blue bar at the very top of the page — to explore more.
The contact owns a 2003 GMC Envoy. The contact stated that the headlights ceased to operate as needed. Upon taking the vehicle to a local Pep Boys, it was diagnosed that the electrical wiring harness was burned and needed to be replaced. Additionally, the bulbs needed to be replaced. The contact stated that the vehicle was repaired; however, the failure recurred. The vehicle was taken back the local Pep Boys, who replaced the electrical wiring harness and the bulbs a second time; however, the failure persisted. The dealer and the manufacturer were not notified of the failure. The vehicle was not repaired. The failure mileage was unknown.
- Chicago, IL, USA
Back door latches sticking/very hard to open and at times won-??t open at all. Visibility from wipers is very limited and not good. Rear exterior lights at times flicker and bulbs come loose at times
- Danville, IL, USA
Headlights and brake lights went out at same time. High beams work, vehicle runs, has all powers. This happened when I left the house, while driving, noticed when it began to turn into early evening.
- Glenolden, PA, USA
When trailer is connected to the 7 way to box trailer connection trailer tail lamps do not light correctly. Brake and left turn signal lamps work properly. The right turn trailer lamp is partially lit when turn signal is not engaged. When right turn signal is engaged the left and right turn signals start flashing, brake lights work normal. This turn signal issue apply only when trailer electric circuit is plunged in to the trailer circuit. My understanding there was a recall regarding the flasher unit for the 2003 Envoy vehicle turn signals. It appears the trailer circuit has a similar issue. Both the vehicle and trailer work off the same flasher module. See recall 05V198000. I plan to replace the flasher unit to correct this defect. If you never towed a trailer this issue would not be discovered. When towing a trailer driver could become confused when your making a right turn. This potentially could result in an accident. The trailer used was a 5X10 foot single axle box trailer with four wire electrical circuit. I had no issues when towed with a different make of truck. I did replaced both trailer tail light assembly and issue did not change.
- Falls Church, VA, USA
No damage to turn signal when I turn on left turn signal sometimes it doesn't work sometimes I can move steering wheel and it will come on for second other times nothing have to try to turn off and on sometimes works sometimes doesn't can not get a good reason why won't work. Have automotive experience at trouble shooting. Also nonsafety issue cruse control on blinker on same switch intermittent working
- Austin, TX, USA
The lights come on by themselves and drains the battery. Two batteries have been installed. The car has had road service jump starts 3 times in 2 wks. The lights come on themselves when they'R'E off. The alternator was checked and is good. The vehicle was parked in a garage when this occurred and 1 time in a parking lot.
- Peoria, IL, USA
The standard headlamps inconsistently and often shut off. The bright lamps remain working, thank goodness. This happens usually when in motion, or right when the ignition is turned on. Weather does not seem to be a factor.
- Fishers, IN, USA
The contact owns a 2003 GMC Envoy. On three separate occasions, the low beam headlamps failed without warning. When the passenger's side turn signal was activated, the four-way hazard indicator illuminated. The vehicle was not diagnosed or repaired. The failure was intermittent. The vehicle was not included in NHTSA campaign number: 05V198000 (exterior lighting). The manufacturer was notified of the failure. The approximate failure mileage was 125,000.
- Martinsville, IN, USA
The contact owns a 2003 GMC Envoy. While the vehicle was parked and turned off, the low beam head lamps continued to illuminate. The vehicle was taken to an independent mechanic who was unable to diagnose or repair the vehicle. The manufacturer was notified of the failure. The failure mileage was 144,000...updated 10/18/16 updated 03/09/17.
- Tuscaloosa, AL, USA
The contact owns a 2003 GMC Envoy. After parking the vehicle and attempting to exit, the driver and passenger side doors failed to unlock. In addition, while driving 45 mph, the headlights blinked on and off and failed to remain illuminated. The vehicle was not diagnosed nor repaired. The manufacturer was notified of the failures. The approximate failure mileage was 188,343. The VIN was not available.
- Natchez, MS, USA
The contact owns a 2003 GMC Envoy. While driving at 55 mph, the low beam headlights were activated and unexpectedly failed to illuminate. The high beam headlights were engaged. The vehicle was taken to an independent mechanic, who stated that the low beam headlight module would need to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 192,000.
- Lottsburg, VA, USA
The contact owns a 2003 GMC Envoy. The contact stated that the brake lights stopped working on the vehicle. The vehicle was taken to the dealer and it was determined that the tail light stop lamp assembly needed to be replaced; however, the vehicle was not included in NHTSA campaign number: 04V527000 (exterior lighting). The vehicle had not been repaired. The failure mileage was 120,000.
- Fort Wayne, NY, USA
Headlights stopped working (low beams only) while driving car at night. High beams continue to work after outage. Occurs at all headlight settings, almost every time the headlights are used and does not resolve itself upon turning car on/off.
- Aldie, VA, USA
The contact owns a 2003 GMC Envoy. While driving approximately 35 mph the contact activated the high beam exterior headlights. The contact noticed the interior lights on the instrument panel also failed to illuminate simultaneously. The vehicle was not taken to the dealer for diagnostic testing. The vehicle was not repaired. The approximate failure mileage was 100,000.
- Edenton, NC, USA
2003 Envoy drivers side headlight bulbs keep burning out. Wires are burnt and terminal has melted. This past week both headlights have gone out while driving took vehicle to dealer they said they knew there was a problem with the headlight socket but my vehicle wasn't one of the of the 308 others that were recalled.
- Trego, WI, USA
Riding on freeway and headlights suddenly went off in dark area. Cut on fog lamps and headlights came back on after couple miles of travel. They have not went off yet again but would be dangerous on curve road. Problem maybe in turn signal control. Cruise went out day before and came back. All located in same switch. Called GMC and told them of problem. Have not went off again yet. Talked to dealer and they want to see it with problem.
- Norcross, GA, USA
Throat of gas tank leaking on a 2003 Envoy. Reviewing internet, found many similar problems on the Envoy's and stated in 2007 that NHTSA was investigating. Mechanic stated very unusual to leak in that spot. Also, have replaced both head light sockets due to burning up. Have talked to many Envoy owners with the same problem. When bulb burns out and the recommended bulb is put in place the socket and wiring gets so hot that the socket is charred and is no longer functional. Wires have to be cut and a new socket wired in.
- O Fallon, IL, USA
The contact owns a 2003 GMC Envoy. While driving at any speed, the headlights on the vehicle will suddenly shut off. The high beams do not fail when the headlights shut off. The vehicle has not been diagnosed by the dealer. There were no warnings prior to the failure. The current mileage was 129,087 and failure mileage was 127,000.
- Lanett, AL, USA
2003 GMC Envoy with a list of problems ** the consumer began to hear a knocking and pinging in the engine on cold starts and felt a hesitation when the automatic transmission shifted into gear. After many complaints, it was finally discovered the engine knock was due to shorter pistons in the re-designed engine and the hesitation in the transmission shifting required reprogramming. The consumer was told he would have to live with the engine knock, because it could be more trouble taking the engine apart. On a separate occasion, the engine stalled due to the battery dying. From April 2004 to October 2004 the battery failed several times and had to be re-charged. During that same time the engine light illuminated and each time it happened, the dealer would have to reprogram the engine computer. The radio was not functioning properly which primarily consisted of static. The driver information center control knobs as well as the radio knobs wore out. The front center console was loose. It was discovered that the engine light was coming on because the third stop light that's on the top of the liftgate malfunctioned. There was a short circuit in the stop light. The cooling fan broke, the brakes and the left front head lamp had to be replaced. The rear tail lights, directional and signal lights have been replaced several times. The lug nut broke while a replacement tire was being mounted on the vehicle. The front stabilizer linkage was replaced. The gas tank had to be replaced along with the fuel lines and a seal on the tank due to a leak. The seat belt was designed poorly and the belt cuts into the consumers neck. The drivers side door didn't close properly, the windshield wipers were replaced within the first 2 years.
- Kinnelon, NJ, USA
- Shreveport , LA, USA