2.6

hardly worth mentioning
Crashes / Fires:
0 / 0
Injuries / Deaths:
0 / 0
Average Mileage:
56,830 miles

About These NHTSA Complaints:

The NHTSA is the US gov't agency tasked with vehicle safety. Complaints can be spread across multiple & redundant categories, & are not organized by problem. See the Back button — blue bar at the very top of the page — to explore more.

Get notified about new defects, investigations, recalls & lawsuits for the 2002 GMC Envoy XL:

Unsubscribe any time. We don't sell/share your email.

problem #2

Feb 262007

Envoy XL 4WD 6-cyl

  • Automatic transmission
  • 69,000 miles
2002 GMC Envoy has an ses illumination accompanied by a fuel odor, and/or a few drops of fuel on the ground when refueling the vehicle. This is caused by a fracture of a weld on the fuel tank inlet check valve (icv). The icv is located above the full fuel level. A fracture in this area may allow fuel vapors to pass through and allow droplets of fuel to accumulate on the side of the fuel tank as it passes over the fracture during refueling.

- Colchester, CT, USA

Add Complaint
problem #1

Oct 122004

Envoy XL 8-cyl

  • Automatic transmission
  • 44,660 miles
Fuel tank has leak at joint where filler pipe and tank join allowing fuel and vapors to escape. Smelled fuel inside the garage. The dealer service manager said that the weld had failed, that it is a manufacturing defect, and that they had replaced the fuel tank for 2 other Envoy for the same failure. There was no prior repair on the fuel tank or removal of the fuel tank.

- Covington, GA, USA

Add Complaint