The contact owns a 2020 GMC Sierra 1500. The contact stated while driving at an undisclosed speed, there was an abnormal knocking sound coming from the engine compartment and the vehicle then failed to exceed 30 MPH. No warning lights were illuminated. The vehicle was taken to the dealer, who were unable to determine the cause of the failure. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling); but the VIN was not included. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 90,000.

- Wilmington, NC, USA

The contact owns a 2020 GMC Sierra 1500. The contact stated while driving 5 MPH, the vehicle made an abnormal popping sound. The check engine and the ABS warning lights were illuminated. The messages "Parking Brake Service" and "ESC Service" were displayed. Additionally, the contact stated the vehicle experienced a reduced fuel range. The vehicle was taken to the dealer, where it was diagnosed that the lifters had fractured, causing damages to the engine. The dealer determined that the engine needed to be replaced, and the part was ordered. The vehicle was not repaired. The contact related the failure to NHTSA Action Number: PE25001 (Engine, Engine and Engine Cooling). The manufacturer was notified of the failure. The failure mileage was approximately 80,100.

- Hugo, OK, USA

The contact owns a 2020 GMC Sierra 1500. The contact stated that occasionally while driving at various speeds, several unknown warning lights remained illuminated, and the vehicle lost motive power. The vehicle was taken to a local dealer to be diagnosed, and the contact was informed that DTC: P0016 was retrieved, and it was confirmed that the engine had failed and needed to be replaced. The vehicle was not repaired. The contact referenced NHTSA Campaign Number: 25V274000 (ENGINE AND ENGINE COOLING). The contact expressed a concern that the remedy was the same engine that was prone to failure. The manufacturer was notified of the failure. The approximate failure mileage was 150,000.

- Mounds, OK, USA

The contact owns a 2020 GMC Sierra 1500. The contact stated that while driving at an undisclosed speed, the low oil warning light illuminated even though an oil change had been performed within 1,000 miles. The vehicle was taken to the dealer, who diagnosed a failure with the piston O-rings, resulting in damages to the engine. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Action Number: PE25001 (Engine and Engine Cooling). The manufacturer was notified of the failure but provided no assistance. The failure mileage was 79,000.

- Billings, MT, USA

The contact owns a 2020 GMC Sierra 1500. The contact stated while driving 70 MPH, the low oil pressure warning light illuminated. The contact pulled over to the side of the road and noticed that the oil level was abnormally low. The contact added oil to the vehicle and continued driving. The vehicle was taken to Mike's Garage, where it was diagnosed that the valve cover was fractured; however, the part to repair the vehicle was on backorder. The contact related the failure to TSB Number: 22-NA-027. The dealer was notified of the failure and informed the contact that the vehicle was not covered under the TSB. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 96,000.

- Owatonna, MN, USA