Top Grill piece attached to hood blew off in the wind.

- Carson City, NV, USA

Upper grille trim piece flew off.

- Columbus, TX, USA

As I was driving down the highway, the top piece of the grill flew off, went airborne, and almost struck the vehicle behind me. When I got home, I looked to see what caused this to happen. The piece was secured by flimsy plastic clips which had broken off. This is a complete manufacturing defect which is on GMC Sierra 1500s years 2022 to present and needs to be recalled. It's happening to a huge number of people based on the reports on Facebook groups.

- Louisville, KY, USA

I was driving on the highway at approximately 65mph and the upper top moulding suddenly broke off, flew across my truck hitting my windshield, before landing in traffic. I had not had any previous damage to my truck prior to this incident. I am concerned this is a widespread issue that is creating an undue burden on the owners and potentially create unsafe conditions to nearby vehicles/pedestrians. I took my truck to the dealership as I have a warranty, but they refused to cover the cost of replacement.

- Fort Worth, TX, USA

I was driving down the highway at approximately 60 mph, and the upper front trim from above the grill flew off, struck, and cracked my windshield. Based on my research, this is a very common problem and a serious safety concern for drivers of 2022-2024 GMC Sierras. It is also a safety issue to the general public for anyone traveling or walking near this vehicle when this condition occurs. There was also an article published on gmauthority website about this common issue as well as multiple Reddit posts and GM Forums.

- West River, MD, USA

The upper molding the the grille broke off while driving at high speed and likely caused issues for following cars. After researching the issue, this is a common problem with owners of this model. It is $1,500 to get replaced.

- Houston, TX, USA

As I was driving down the road the front upper lip of my grill blew off and hit my windshield and then flew into car behind me. Looked online and this is a very common theme with GMC built in 2021 & 2022.

- Haslet, TX, USA

Grille trim piece came detached while driving on freeway damaging hood. Could have flown off and hit another vehicle. Took truck to dealership and it was replaced under warranty. Seems to be a known defect, lots of other people with same issue on Reddit.

- Cypress, TX, USA

On October 10 about 9am driving out of town on vacation for not reason at all my 2022 Sierra 1500 front upper lip of my grille broke off on freeway and we could not find it.

- El Paso, TX, USA

Driving down the road at 60 mph, the front upper grill piece just came off, flew up into the windshield and then over the cab of the truck and landed in the street. This is a known defect on these trucks and has happened in 100's of cases. When it happens it makes you react as if you had hit something with the truck, if there had been anyone behind me it could have also caused damage or made them react badly to something flying thru the air. When it happened to me I was prepared for it since I had read online of it happening to so many people. The cause is that its build with really flimsy, very thin tabs that just cant hold up to the wind speed and use needed for being mounted in the front of the vehicle.

- Frankston, TX, USA

Front upper grill trim piece flew off truck causing a safety hazard for myself and others behind me. Flimsy tabs had broken and wind ripped the trim off.

- Williamsburg, MI, USA

Upper bumper flew off driving on the highway

- Allen, TX, USA

The upper trim piece of the grille broke off while driving down the road the other day. The piece flew up onto the window creating a distraction to myself and the vehicles behind me. The problem can not be reproduced by the dealership as its broken in pieces on the side of the road. Based on internet research this is a common occurrence. The vehicle has not been inspected by others There where no warning signs, messages or symptoms of the problem prior to the failure of the grille.

- Aberdeen, SD, USA

Driving down the road and a large section of my grill came flying off the truck, hitting my windshield and the car being me. I pulled over as soon as it happened and the car that was hit kept going and did not stop. After a search on the internet it has brought up serval cases of this happening to other owners. This would of killed a motorcycle driver if he was behind me. We need action. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

- Clermont, FL, USA

The upper front grill molding flew off the vehicle while moving and the parts are available for inspection. Please see uploaded photos. The safety of motorcyclist and other vehicles following me were put at risk of being hit by a 24 inch wide piece of the upper front grill at high speed that flew off the vehicle while traveling on the highway without warning. The problem has been confirmed and reported by numerous vehicle owners like mine posted in online forms that I have attached to the upload files section of this correspondence. The vehicle was inspected for repairs by the manufactures dealership representative and a repair invoice has been uploaded. There were no warnings prior to the failure of the upper grill molding being dislodged from the front grill while the vehicle was moving.

- Oakland, CA, USA

While driving in the highway at 60 mph, the top of the front grille flew off, hit the hood, and impacted the windshield before flying off to the passenger side of the vehicle. It impacted multiple locations on the passenger side of the vehicle as it flew off. Nothing hit the grille at the time it flew off. We were driving on a busy highway. Thankfully, the cars behind us were at a safe distance. If there were a motorcycle or another vehicle, it could have seriously injured someone or caused them to swerve their vehicle. Researching this online, multiple owners of the same vehicle have experienced the same issue. Many experiencing it when traveling at highway speeds. It seems like the thin plastic tabs that attach the top grille piece to the front of the vehicle are not strong enough to hold it. No damage had been done to the grille prior to the incident. I always use a touchless car wash, so it wasn-??t loosened by that. I haven't contacted insurance or filed a police report. I'm hopeful the damage will be covered under the manufacturer warrant.

- Rapid City, SD, USA

I was driving down the interstate when the top trim panel of my grille flew off my truck. The piece flew into the traffic behind me, and fortunately, no one was injured. If there was a motorcycle behind me, the rider could have been severely injured or killed. The piece that flew off is located just above the grille and below the front edge of the hood. Multiple people have reported the same issue with their trucks. This morning, the parts department at my dealership confirmed that I was not the only customer to present this problem. There is nothing to warn of the problem before this piece flies into traffic.

- San Antonio, TX, USA

A large part of the grill on the front of my truck but broke off on it's own while I was driving. The part is called the Upper Grill Molding Part number 20863. It's about the size of a ski (5.5 ft long and 6 inches wide). It flew off and almost hit the car traveling behind me. They had to swerve off the road to avoid hitting it and almost got into an accident. After inspecting the part and how it is supposed to attach to the grill, it is apparent that is was very cheapy installed with flimsy plastic mounts and minimal glue. My truck only had 19,000 miles on it when this happened. I took it to the GMC dealer and they said the entire grill would have to be replaced because they don't sell that part separately. I researched this issue online and found thousands of other cases with the same scenario happening. This manufacturer's defect should be recalled as it poses a severe safety risk to pedestrians and other vehicles.

- Hampstead, MD, USA

A large trim piece at the top of my grill flew off while driving 70+ on the highway. I have personally seen roughly 100 testimonies with picture proof on various fb pages of others with the same vehicle experiencing the same thing. This is a known issue for the 2022-2023 model years, GM has apparently corrected the issue for the 24+ model years.

- Labadie, MO, USA

I was driving on the highway around 70-75 mph and the upper moulding on the grille flew off and hit the windshield

- Sugar Land, TX, USA