Wasn't on a main road was coming down a driveway and heard a noise thought maybe it was built up snow but the car just fell apart the trailing arm/ cross member came right off the car had to get it towed to my home

- Peru, NY, USA

Some time between approximately between 12:00 am and 4:00 am on 2/1/2020, the vehicle caught fire on it's own (it was parked and off) and badly burned our garage/home causing extensive property damage to the garage and interior of our home.

- Tampa, FL, USA

The contact owns a 2007 Hyundai Elantra. While driving 40 mph, the rear axle detached from the vehicle. There were no warning indicators illuminated before the failure. The contact stated that the rear axle was rotted and there was frame corrosion on the rear side of the frame. The contact had the vehicle towed to riverhead Hyundai (1800 old country rd, riverhead, NY 11901, (631) 369-0600) and was advised that nothing could be done. The manufacturer was not notified. The failure mileage was 120,000.

- Riverhead, NY, USA

Passenger visor failed a few months ago. Driver visor failed shortly after (around 60,000 miles). This appears to be a known problem with Hyundai's manufactured after 2007. Dealer would charge $176 per visor, but absorb the cost of installation. One passenger banged her head when getting in the car. Driver's visor has fallen on my head several times -- a hazard in my opinion.

- Tucson, AZ, USA

Driver side sun visor fall off during driving and few months later passenger side sun visor also fell off during the driving.this is a safety hazard while driving against the sun or bright light. There is no secured fit to attached sun visor, attached only with the electric wire going inside thru visor.manufacturing/design defect.

- Cerritos, CA, USA

The rear suspension cross member rotted where the control arm attaches to it and broke free. The control arm then fell down and the entire rear tire and suspension was dragged underneath the rear end of the car. The metal that the control arm attaches to is very thin and the only thing under the car that is not undercoated is that suspension cross member. If this part broke free at 55mph I may not have survived the crash. It broke free as I turned into my driveway, more than likely from the twist of the turn.

- Narrowsburg, NY, USA

At my 30,000 mile maintenance work ($600.+), I was called back to shop to show me "very dangerous" corrosion around rear axle/frame parts. I bought this car new from same dealer and was sold a $800. Warranty rust-proofing application. It was clear that where no coating was applied, rust was there and I was told it would be risky driving the car. The low millage and no history of the car being driven in salt water conditions, I was amazed at its condition.(I grew-up in the North rust-belt) I retired close to the South ocean area but never had a car with such advanced rust. (several cars) the dealer refused to honor the warranty and Hyundai's warranty does not cover it. I think poor quality of metal was used in the manufacturing of this vehicle. It's obvious the dealer is also at fault and refuses to honor his warranty. I guess that is a legal problem that I'm stuck with. The possible safety problem comes under your concern for sub-standard manufacturing.

- Kitty Hawk, NC, USA

Yet another door handle has fallen off my 2007 Hyundai Elantra! this is #4. this vehicle is only 4 yrs old, and yet 4 of the door handles have broken off. The prior complaints I have filed have been 10400898 and 10280729. I am really disgusted with how Hyundai is treating this. Hyundai tells me that it happened because of the cold. 2 of the door handles fell off in winter months of December and February. 2 fell off in the summer months of July and August. When I mentioned this, they backtracked and blamed me for ripping them off... I am a 150 lb, 47 yr old woman. I do exercise, but I am not a gorilla! I've never had any other vehicle loose a single door handle, let alone 4 of them! I am upset that I am blamed instead of them looking and researching the problem! I am not a certified Hyundai technician, but I can see that each and every one of them have broken in the exact same spot on the plastic! it has a little pin it rides on and the plastic breaks right there each and every time. I've seen it. The Hyundai technician should have been able to see it also. But they claim it is not a part or vehicle problem. Hyundai claims that I have been tearing the handles off in some way! if that is true, I sure wish I knew how I was doing it so I could quit wrecking my car! it is out of warranty, so they don't care nor are they interested in making sure it doesn't happen to me (or anyone else!) again. Too bad, we aren't required to do anything now, so go away is the response they gave me when I sent them a letter...do not purchase a Hyundai!

- Stevensville, MI, USA

I own a 2007 Hyundai Elantra. I have had 3 door handles break on this vehicle. The first two were on the passenger side and broke off in the summer 2 yrs ago, within a month of each other. They were covered by warranty and repaired after a small fight with the dealership. The last one broke in February of this year. The vehicle has been garaged every night, no matter the weather. I've never had more than one door handle break on all the cars I've ever owned; and that car only had one handle break! Hyundai says they won't fix the latest broken one, since I am out of warranty. I know the door handles have all broken in exactly the same place each time. The part of the handle that holds the handle onto the car is made of plastic, and the inside of that part breaks at exactly the same place. As this part is required to keep the handle on the vehicle, I believe it should be made of material that can handle some wear and tear. I think this plastic is just unable to withstand normal daily usage! I posted the first two breakages earlier, so that is on here some place. I'm hoping to see Hyundai back up their products, but I don't think they will. Someone needs to look into this and see if I'm the only one-as they claim-or if this part is indeed unable to perform correctly-as I believe is true!

- Stevensville, MI, USA

Two door handles have broken on my 2007 Hyundai Elantra. Both of them were on the passenger side of the vehicle. They both broke at the same place, a plastic part inside the small piece that the handle fits into. (this small piece stays on the car while the door handle lifts up.) the back door broke off in July, while the front door handle broke this weekend, in August. I am concerned that the driver's door handle will be next!

- Benton Harbor, MI, USA