Issues began in November of 2024 Began with a a oil consumption test and failed. Submitted for a new engine due to high oil consumption 3 quarts in 1,000 miles. Waited 6 months for a new engine to be available. July 2025 noted oil leaking brought in for repair and stated it was a boot joint that was leaking. Multiple return trips to repair since oil was still leaking. Check Engine light came on in, September and a faulty sensor in engine was noted (for mixing air and gas?), replaced sensor. Oil still continues to leak and after insisting they take the entire engine out to figure out where it was coming from a leaking faulty oil plug was noted on the rear side of the engine.

- Forest Lake , MN, USA

I am the 3rd time owner of this palisade. Car was bought after a transmission replacement at 27,000 miles. (Second transmission). At around 70,000 miles, we started to have oil consumption problems/ignition coil problems. After a slew of tests and other recommend procedures that cost us money out of pocket, hyundai recommended to get a new engine. We get the new engine. They call to tell us the new engine is done, and proceed to share the transmission is bad and it needs a new one (3rd transmission). They are asking us to pay for the transmission as well. We want a buy back as we think this is a lemon car. 3 transmissions and a new engine under 85000 miles is not good and definitely grounds for investigation. These repeated failures make it unsafe/unreliable for us to drive our 6 month old baby in, let alone my wife and my myself.. We request and investigation/buyback.

- Bowling Green, KY, USA

Our motor has been consuming a lot of oil, we were told that Hyundai knows about the issue and that there is nothing they can do. We got sold a poor excuse of a warranty in which they never told us that the warranty would not cover oil consumption, but we have the -??best-?? warranty they had. Our car has died GOING DOWN THE ROAD WITH MY 4 kids and WIFE! Cars had to swerve to avoid a collision, 5 times this has happened but yet they will not do anything! We will be seeking legal help!

- Cambridge, OH, USA

Engine started burning oil at 65000 miles. It has now run almost completely out of oil twice at about 4200 miles since last oil change, not even close to reaching the manufacturer recommended interval of 7500 miles between oil changes. On top of the engine consuming oil at an alarming rate, there are no warning indicator lights that turn on to let you know your oil level is critically low.

- Shorewood , IL, USA

On roadtrip with family to daughter-??s soccer tournament. Car started to shift funny then engine light turned on along with warning display saying something was wrong with the engine. We were only hour into driving so drove hour back home to dealership/service for Hyundai. They looked over the car and reported that we did the right thing by bringing it back and not continuing our roadtrip with it. The thermostat wasn-??t working which would cause issues to engine with overheating and putting my family at risk with driving it on road trip with engine overheating.

- Jeannette , PA, USA

Engine stall from excessive oil consumption. Oil and engine light not turning on prior to stall.

- Dix Hills, NY, USA

Vehicle started rattling at 96k miles with no check engine light. Performed diagnostics and found that the vehicle had zero oil inside. Determined that there was no sign of an oil leak and that the engine had internally consumed all of the oil. The rattling still exists and when reported to Hyundai, they sent me away and said to come back after 1k miles to see if it-??s consumed 1.1 quarts and only then they will clean the engine and see if that helps and if after another 1,000 miles I still am consuming oil, they will replace the engine. They are refusing to provide a loaner vehicle throughout this process as well.

- Round Rock, TX, USA

Vehicle Information: Year: 2020 Make: Hyundai Model: Palisade Component(s): Air Conditioning System / A/C Compressor Problem Description: The air conditioning compressor on my 2020 Hyundai Palisade has failed and does not function properly. The A/C system does not blow cold air, making the vehicle extremely uncomfortable and unsafe in hot weather conditions, especially with small children riding in the vehicle. Hyundai has issued a Technical Service Bulletin (TSB) regarding a known defect with the A/C compressor in this model. Despite this, the dealership and manufacturer have refused to cover the repair or replacement under warranty or goodwill, even though this is clearly a widespread and acknowledged defect. I was quoted nearly $5,000 for the repair, which I cannot afford. Safety Concern: While the issue may appear to be only comfort-related, lack of functioning A/C creates real safety risks: Heat-related health concerns in hot climates, particularly for small children and elderly passengers. Reduced visibility if the defroster system does not work properly (since the A/C system is needed to remove moisture and fog from windows). Timeline of Events: Vehicle purchased: Purchased December 2023 First noticed issue: [XXX] Brought vehicle to dealership: [XXX] Dealer confirmed issue with A/C compressor but refused repair, citing that only certain VINs or conditions are covered, even though a TSB exists. Request: I am filing this complaint because Hyundai is aware of this widespread A/C compressor defect (per their TSB) but is not providing proper warranty coverage or resolution. This places an unfair financial burden on consumers and presents a potential safety hazard, especially for families with small children who cannot safely ride in extreme heat without a functioning A/C system. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

- Glendale, AZ, USA

many palisade owners and I have a same issue that the vehicle shaking when applying the brake the the car slipping jerking forward. that is really unsafe for us. please review this case

- Garden Grove, CA, USA

Transmission issues. Many people are experiencing this and have had to replace transmissions on these!!! Help!

- Minneapolis, MN, USA

The vehicle experiencing excessive oil consumption without any external leaks. Since February 2024, I have repeatedly reported this issue to the dealership. They required me to complete multiple 1,000 mile oil consumption tests and eventually performed a combustion chamber cleaning. Despite this, the oil consumption problem continues. As of today, after driving only 3,700 miles, the engine oil level was so ow that the dipstick did not register any oil at all. No warning lights or dashboard indicators ever came on to alert me to the low oil level. The dealership has acknowledged my concerns but stated that Hyundai considers this "normal specs". I strongly disagree, as the amount of oil being consumed poses a safety risk if the engine fails while driving. The problem has been confirmed by the dealer during inspections, but no permanent repair has been offered. The ongoing issue creates a serious risk to both my safety and the safety of others on the road due to potential engine failure from lack of lubrication.

- Kenner, LA, USA

Safety Complaint Summary: I am filing a safety complaint regarding my 2020 Hyundai Palisade SEL AWD, ~96,000 miles). This vehicle has suffered three major powertrain failures under 100,000 miles: - Full engine replacement (due to excessive oil consumption, unresolved for months) - AWD system repairs - Now requires a full transmission replacement When my engine began burning oil, Hyundai-??s service department charged me ~$500 and sent me back on the road without disclosing that this was a known issue. I continued running out of oil multiple times until an independent mechanic diagnosed the defect. My family was unknowingly placed at risk while Hyundai delayed resolution for 8 months. Diminished Value: The repeated nature of these failures not only raises safety concerns but has also destroyed the market value of the vehicle. Even after a transmission replacement, the Palisade remains a car that no buyer would trust -?" which underscores the seriousness of these systemic safety risks. Relief Requested: I ask NHTSA to review whether this defect pattern represents a broader safety issue and whether Hyundai should have disclosed the known oil consumption defect earlier and should investigate why a vehicle is suffering three powertrain issues and if this is a wider problem with the car type/year. A notice to consumers should be issued so we are not driving around in an unsafe car.

- Fairfield, CT, USA

SUV is consuming oil prior to 5000 miles. I went to the dealer in June after noticing my SUV shuttering and almost shutting off while accelerating and it was noted that all of my oil was gone. I was instructed to get an oil change. I came back a month and a half later and all of my oil was gone again and it had been less than 5000 miles since the last oil change. I was instructed to get another oil change and come back in 1000 miles. It has been 3 weeks and I came back 1000 miles later with most of the oil gone. Diagnostic showed internal damage and the valve seal is leaking internally. There were no warning lights. I am waiting for further inspection by the dealer.

- Hialeah, FL, USA

The contact owned a 2020 Hyundai Palisade. The contact stated that while driving at approximately 65 MPH, he heard an abnormal popping and hissing noise. The contact stated that he started to smell a burning odor. The contact was losing forward momentum. No warning lights illuminated. When he applied the accelerator pedal, the vehicle continued to slow down. The contact pulled off the highway, stopped the vehicle, and turned off the engine. The contact stated that almost immediately, smoke was issuing from under the front end. The contact stated that the vehicle burst into flames. The police and fire department were called. The fire was extinguished using chemicals. The police and fire departments issued reports. The vehicle was towed away to an impound lot. The contact stated that he had the transmission replaced in 2024. The manufacturer was not informed of the failure. The failure mileage was approximately 150,000.

- San Antonio, TX, USA

While merging onto a highway, my 2020 Hyundai Palisade abruptly lost all engine power and stalled. This immediate and complete failure occurred at a critical moment, posing an extreme safety risk. All dashboard warning lights illuminated, but provided no specific diagnosis. The vehicle was towed to a dealership, where technicians determined the engine was consuming oil at an abnormal rate, despite a lack of visible leaks. I was instructed to participate in an "oil consumption test, " a three-part process that required multiple oil changes and inspections over several months. Each time, the vehicle had burned over a quart of oil-?"a clear indication of a defect. Despite this evidence, Hyundai denied my warranty claim, accusing me of negligence for being unable to produce oil change records between 29,600 and 46,900 miles. This is a common and unacceptable tactic used to avoid accountability for a widespread issue. My experience is not isolated. Hundreds, if not thousands, of owners of 2020-2023 Hyundai models, including the Palisade, report identical engine oil over-consumption issues and subsequent power loss. This issue is a **severe safety hazard** that can lead to sudden, catastrophic engine failure and potential accidents. Hyundai's refusal to acknowledge this defect and issue a recall is **gross negligence**. They are knowingly allowing thousands of unsafe vehicles to remain on the road. There are currently federal lawsuits against Hyundai for this very issue. The transportation authority must force Hyundai to issue an immediate recall and remedy this critical defect before a tragedy occurs.

- San Antonio, TX, USA

On [XXX], while driving on the freeway, my 2020 Hyundai Palisade suddenly malfunctioned and went up in flames without warning. My young son was in the vehicle with me. Within moments, smoke and fire spread rapidly, forcing us to stop in traffic and escape before the fire fully engulfed the car. The entire vehicle became a total loss. This was a terrifying, life-threatening situation. My safety and my son-??s safety were at extreme risk. If my other family members had been in the car, the outcome could have been catastrophic. The emotional trauma from this event is significant and continues to affect us. The incident was reported to the San Antonio Fire Department, who responded to the scene and documented the fire. Their reports confirm the vehicle fire: Incident Report #[XXX] and SAFD Case #[XXX]. After researching, I discovered that similar fires have been reported in Hyundai vehicles, raising concerns that this is part of a wider safety defect. Families should not have to fear their vehicle spontaneously igniting on the road. At the time of the fire, there were no warning lamps, error messages, or symptoms that suggested the vehicle was unsafe. The failure happened suddenly and without warning. The vehicle has not been inspected by Hyundai at this time, but it is available for inspection upon request. I am urging a full investigation into Hyundai-??s design and safety practices, as this fire placed lives in immediate danger. This was not just a mechanical failure-?"it was a potentially fatal event that could have resulted in severe injury or loss of life.

- San Antonio, TX, USA

Follow-Up Complaint -?" Engine Failure on 2020 Hyundai Palisade (VIN: [XXX] ) I am following up on a previous complaint regarding a complete engine failure in my 2020 Hyundai Palisade. I purchased the vehicle from CarMax in 2023 and was never made aware of any known engine issues. I also signed the required Lemon Law disclosure form at purchase, which did not indicate any concerns with the engine. My vehicle experienced a sudden and total engine failure, despite being properly maintained. This failure mirrors the symptoms of engine problems that have led to multiple Hyundai recalls in other models with similar engine configurations. Although my VIN is not included in the current recall list, my engine failure is consistent with those affected, indicating a broader issue that Hyundai has not fully addressed. The engine failed prematurely and unexpectedly, which is both a serious safety hazard and a financial burden. I am now stuck with an inoperable vehicle and costly repair needs due to a failure that appears to stem from a manufacturer defect. This situation reflects a pattern of engine-related issues across Hyundai vehicles. I urge NHTSA to investigate whether the 2020 Palisade should be included in Hyundai-??s ongoing or expanded recalls. Hyundai must be held accountable for engine defects-?"regardless of whether a VIN is currently listed. I am requesting that this matter be escalated and reconsidered. Sincerely, [XXX] VIN: [XXX] Purchased: 2023 from CarMax Mileage at failure: [Insert Approx. Mileage] Phone: [XXX] Email: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

- Fairburn, GA, USA

Vehicle stalled and suddenly went into park mode from drive mode and lights started flashing along with engine light. Not idling properly, or shifting properly, has to be towed to dealership. 2020 with only 72,000 miles.

- Camas, WA, USA

My car has been diagnosed, by a dealership, with excessive oil consumption due to a faulty piston ring which caused there to be no compression in cylinder 1. Initially my car had smoke coming from the tailpipe, then it started to shake while idling and the check engine light came on (delearship cleared it), then it overheated on me while going down the road with no warning whatsoever. Each time there was no oil on the lipstick. This is dangerous for people to not have any warning as to when the car is going to overheat until its already overheating. It could potentially set on fire while going down the highway with my [XXX] and [XXX] old. As soon as I put oil in it, it runs totally fine. I have voice recordings to confirm the diagnosis. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

- Tennessee Colony, TX, USA

This vehicle has excessive oil consumption, and the low oil light does not light up to tell you that you are low on oil. I only noticed that I was low on oil because the engine starts knocking and started to stall. I had the oil changed according to all service intervals and at one point the dealership told me my car had no oil left in it. I just had it changed, drove about 2k miles and already had to put more oil in because it didn't even show any oil on the dip stick. This is a safety hazard as well as an environmental problem with these vehicles burning this much oil. This started happening around 80-90k miles on the engine.

- Saint Cloud , FL, USA