I started smelling a little gas in the 20th. And on the 21st it got a lot worse so I took it to the dealership. This is the same place that replaced the engine because it failed and it was a recall. I let them know of the recall and they said it is not covered. They told me it was the high-pressure fuel line that connects to the pump. I have provided a picture of what the tech said.

- Sandy, UT, USA

My vehicle had Hyundai Safety Recall 227 (fuel tube replacement) completed on December 7, 2022. After the recall repair, the same fuel-system symptoms returned. A Hyundai dealership diagnosed failure of the high-pressure fuel pump and high-pressure fuel pipe and stated the condition was critical and a safety risk due to fuel system involvement and potential fire hazard. Hyundai Motor America declined assistance, citing vehicle age and mileage, despite this being a recurring fuel-system safety issue following a recall repair. The vehicle continues to present fuel-related safety concerns, and operating the vehicle poses a potential fire risk. In addition, the estimated repair cost exceeds $2,000, which represents a significant financial hardship for a safety-related defect that occurred after a recall repair. I am submitting this complaint due to concern for vehicle safety and the recurrence of a fuel-system defect after a manufacturer safety recall.

- Frisco, TX, USA

Theres a know recall for this issue. Recall 189 AND 227 for hyundai. Fuel leak right by the regulator on the hose. Mine is doing the exact thing. My motor isnt covered for some reason. Same make and model. So id like to make a complaint and make it know the exact same issue is happening STILL, 2013 hyundai sonata and they wont cover it. So if another recall could be opened to help others. I mean its the exact same issue.

- Las Vegas, NV, USA

We were sitting in our car at a Hardees drive through when we noticed smoke coming out from under the hood. I pulled forward to a parking space and opened the hood. Flames shot up at least 6 feet. I quickly ran a short distance into the fast food place and right near the door was a fire extinguisher, which i grabbed and put the fire out with. The fire burned for about a total of 2-3 minutes, and did not do excessive damage. Coil packs and wiring harness got most of the damage. With the hood closed, you cannot even tell there was a fire. I had the car towed to Grayson Hyundai for the recall part, but then entered a claim to Hyundai. Long story short, they stalled me for over a month and then denied the claim. Citing no damage to the cam. Unlike most of the fires with this carline, my car fire was put out very quickly. The recalled fuel line/tube was not damaged much at all. You could inspect the part and see the wear on it and tell it was the culprit. It didn't take a trained mechanic to see this. After i put the fire out and it cooled, i tried starting it, and there was fuel squirting out from the recalled part. There is absolutely no doubt that the recalled part was the cause of the fire. But Hyundai has given me a denial letter that does not state the reason for denial. The Hyundai rep on the phone told me it had to do with no damage to the cam. I then asked, Thats because i got the fire out so fast right? and he said no, didn't have anything to do with it. But he lied. First of all, the cam has nothing to do with the cause of the fire. a damaged cam only happens when the fire was long lasting and severe. They should have inspected the obvious recalled part right in front of them. This denial is completely unprofessional and hints of a concerted effort to categorically deny claims. They don't usually have this much evidence, they did this time and still blew it. had i let it burn to the ground, =approved

- Strawberry Plaines, TN, USA

So my car started to stall when I started it an when I started goin down the road like it wanted to die. Then I started to smell gas very strong so had a code tester put to my car an i have 6 permanent codes. An not only that im smelling oil strong an noticing big oil spots under my car. So I look under the hood an behind the turbo I see oil behind an underneath the turbo. I definitely didnt feel safe driving but now its not even drivable. I purchased it couple months ago from an individual an i cant belive the amount of problems this car has. Im a single mom an trying to support my family an its hard to now with a non running car. I've put quite a few parts hoping it would fix some of the problems an nothing has. I absolutely love the car an very beautiful but unfortunately to many problems with it. Eninge, gas leaks, timing

- Rochester, IN, USA

Unknown, caught fire. ?

- Irmo, SC, USA

On [XXX], in Washington, D.C., my 2013 Hyundai Sonata experienced sudden engine failure, leaving the vehicle inoperable. My goodwill repair request was denied within 30 minutes, without a proper inspection of the rod bearings (a known failure point covered under the TXXI extended warranty) or the fuel pipe recall-?"a known issue that could pose a fire hazard. Hyundai cited suspected maintenance neglect, but I have documentation of regular synthetic oil changes. Despite having over 200,000 miles, a Firestone inspection from September 2024 confirmed the vehicle was in good condition prior to the failure. Additionally, Hyundai Theta II engines are widely known to suffer from excessive oil consumption, a defect that can lead to premature engine failure even in well-maintained vehicles. Hyundai has replaced engines in vehicles with similar mileage under the same extended warranty, yet in this case, no proper inspection was conducted before denial. Safety Concerns: The fuel pipe recall was not inspected, raising concerns about whether unresolved recall defects are leading to engine failures or fire risks. The airbag clock spring, covered under Hyundai-??s TXXA extended warranty, was not inspected, despite the airbag light being illuminated, potentially affecting airbag deployment in a crash. The vehicle failed without warning lights or error messages, creating an unsafe situation. Hyundai-??s failure to inspect recall-related issues before denying repairs could impact other affected vehicles on the road. I request that the NHTSA: Ensure Hyundai properly inspects recall-related components before denying repairs. Investigate whether Hyundai is improperly denying warranty and recall-related repairs, even in cases where similar vehicles have received replacements. Determine if the unresolved fuel pipe recall and airbag clock spring defect pose broader safety risks. This issue has been reported to Hyundai corporate, but no proper inspection has been performed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATIO

- Washington, DC, USA

The vehicle has begun to vibrate/shake badly but manageable. When a code reader was connected to the vehicle both codes 7E9 and 7E8 showed up. Upon researching, information has been found that these specific vehicles have been known for recalls due to fuel hose issues. If I continue to drive this vehicle without the issues being resolved which is not my fault, I jeopardize my son and I-??s lives as well as any potential future passengers.

- Pompano Beach, FL, USA

After starting, got a warning stating check hybrid braking, do not drive. When going forward, brake pedal went to floor, heard heavy grinding noise and vehicle stopped accelerating. Had to use the emergency brakes to avoid an accident. Hyundai says they can-??t find a problem. Now I can-??t even drive it back to the dealer! Did an internet search and many other hybrid owners have reported the same issue. I just want to have Hyundai buy the car back at this point. It only has a little over 50,000 miles on it.

- Wilson , OK, USA

2013 Hyundai Sonata engine caught on fire after being replaced TWICE.

- Rancho Cucamonga , CA, USA

My low pressure fuel hose has a leak. The amount of gasoline that is spraying on my spark plugs and engine is concerning. The gas fume smell coming in through the vent was horrible. After finding this leak I came to the conclusion that I am very lucky My car didn-??t catch fire while I was driving. For some reason there is already a recall in place that includes my vehicle year but does not include my vehicle Vin. How do I get my vehicle included in this recall so that it can get repaired? The recall in question is NHTSA number 227 or 22V -?" 314. At this time, the car is sitting in my driveway and I am not inclined to move it until I know it can get repaired. At that time, I will have it towed to the dealership.

- Litchfield Park, AZ, USA

While accelerating on the highway, several warning lamps (battery, engine, others that I forget) came on. When I pulled over the hood was smoking, and a fire flared up after I opened the hood. My son and I escaped the car with no injury. Still waiting for report from insurance company.

- Ooltewah, TN, USA

Car smells like it-??s burning, been told it-??s oil. Dealership after seeing leakage on the engine replaced the valve gasket. Car still smells like it-??s burning and apparently there is no leaking. I went to the same dealership to inform them and they recommended replacing a hose but not a guarantee it will fix the overall problem which is smelling of burning. I-??m concerned! I-??m 37weeks pregnant and don-??t want to inhale burning or any other chemicals pre and post postpartum with a newborn

- Verona , NJ, USA

Wires, reverse osmosis system unauthorized and unknown

- Winston Salem, NC, USA

While driving the car at freeway speeds it died and quit running, and the engine compartment began smoking, and a fire ensued under the hood. Gasoline could be smelled before it started fire.

- American Fork, UT, USA

The engine went into smoke and caught on fire. Resulting in damage to the vehicle ultimately causing to be totaled.

- Manteca, CA, USA

What component or system failed or malfunctioned, and is it available for inspection upon request" The Car continues to have inconsistent acceleration, hesitation, and sometimes lurches forward. On two occasions, the car felt like it was just going to turn off while driving. I was driving about 75 mph on I295 and driving about 15 mph on a residential road during the second occurrence. How was your safety or the safety of others put at risk" I feel as though I am not in complete control of the acceleration but am mostly concerned with the car stopping on it's own. I am very scared I'm going to be hit by the car(s) behind me. Has the problem been reproduced or confirmed by a dealer or independent service center" Yes. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? I have an appointment in October for the car to be evaluated by a dealer. I hope it doesn't happen again before then. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear" The only time a warning lamp came on was during the second episode when the car felt like it was going to turn off; the engine light came on and immediately off.

- Lawrence Township, NJ, USA

My 2013 Hyundai Sonata lost acceleration power while on the road requiring an emergency departure from the road and it fails to acceleration beyond. Placed vehicle in park and attempted to proceed home but was only able to drive 5 to 10 mph max creating a dangerous situation for my fellow commuters and myselt. After about a few block I let the vehicle cool down and attempted to proceed home. The car would only go up to 5 mph requiring me to avoid rear end collisions. Ultimately, requiring a tow vehicle to bring it home. Our neighbor indicated it is the MAP sensor which was changes with no improvement to the car's acceleration issues. Checked all the fluids and assured they were correct. This vehicle has place me and others in a dangerous and potentially fatal situations.

- San Antonio, TX, USA

This incident singled happen in a 20 or so miles on my way home commute, no freeway drive. I was driving pulling out of a parking street when I notice the vehicle tendency to pull me forward, even though I was preparing to stop. It continue to have this issue at a stop sign and traffic light. at first it was mild pull as if you are being towed. Sporadic pushing forward, but when I turned to the left I notice that the engine pick up speed on its own and the issue was exacerbated on turns to left and right. The issue continue to the point I stayed at a safety distance from other cars and the pull began to be more aggressive. I was driving slow at that point. With hazards lights on. On arrival to my home driveway and upon putting the car on park the engine RMP jump so high that scared me! The car sounded as if it would take off by its self. I had the foot on my brake and did not pump at that point. I took car to the dealership the next day and it continue to pull at sporadic times I drove slow and cautiously. Noticing that the pull got worse driving on a straight street versus the day before only on turns having more aggressive forward acceleration pulls. The dealer has check the car and has not been able to detect the problem with computer codes and apparently have not been able to reproduce the issue after driving the car. The mechanic, told me to take pictures of engine light if when I drive it has issues, and the light comes up. But not other solution was given.

- El Dorado Hills, CA, USA

HE99 P cabin filter DR Break LightV Air Filter Oil Leak Poss Oil Pan. Now having engine problems and my car was taken to Pennsylvania. My car started smoking.

- Baltimore , MD, USA