Catalytic converter and oil leak which is causing the vehicle to lose power. The catalytic converter was replaced in 2024 and now is bad again in 2025. Oil consumption has been a problem since 2024. Hyuandi is refusing to repair the vehicle. Despite the engine making a knocking noise and the check engine light is flashing the vehicle is still under the 150,000 power train warranty

- River Forest, IL, USA

Limp mode, knocking, engine light. Only has 62,768 miles on it. I can't fill out campaign 966 or 982 on the official web site for extended coverage.

- Weirton, WV, USA

Engine making knocking sounds, losing power, no indication of low oil levels until very low.

- Cottonwood Heights, UT, USA

Fitzgerald Countryside Hyundai - address is 27419 US Hwy 19 N, Clearwater, FL 33761 refuses to fix a recall on my unsafe car. Check engine light flashing due to code P1326 which is an issue detected by KSDS that monitors unusual engine vibrations and is designed to prevent engine damage

- Largo, FL, USA

High oil consumption, Taken to dealer for oil consumption test, Have to drive vehicle 1000 miles, Then take vehicle back to dealership to see how many quotes of all I-??ve burnt or lost recheck oil levels

- Exton, PA, USA

The vehicle is experiencing excessive oil consumption and increasingly severe engine performance symptoms. The oil level drops rapidly between changes, but the loss is not due to external leaks. The engine burns oil internally, causing residue buildup and damage to other components -?" specifically the intake manifold and catalytic converter, which the dealer has now recommended replacing. These issues align with the symptoms addressed in Hyundai Campaign 966 (Engine Monitoring / Knock Sensor Detection System), which is intended to detect early bearing wear and related oil consumption defects. However, the dealership refused to perform the required campaign diagnostics (bearing inspection, KSDS verification, and oil-consumption test) without charging a diagnostic fee. Even though the engine has not yet fully failed or entered limp mode, the excessive oil consumption is already causing secondary damage to emissions and intake components. If left unresolved, this can escalate to engine seizure, catalytic converter overheating, or exhaust-related fires due to unburned oil entering the converter. These are clear safety hazards that can result in loss of power, smoke, or fire while driving. Multiple Hyundai owners have reported identical problems -?" excessive oil loss, residue damage to emission systems, and dealer refusals to perform Campaign 966 inspections. These patterns indicate a systemic engine defect that leads to downstream component failures, not isolated wear. Replacing the manifold or converter does not correct the root cause, as oil consumption continues after replacement and will likely damage new parts. The dealer-??s refusal to perform the manufacturer-??s required diagnostics and their attempt to charge for unrelated repairs prevent proper defect identification. This is a serious and ongoing safety issue affecting Hyundai Tucson and other models with the same engine family.

- Del Valle , TX, USA

While almost at a complete stop in the process of putting my 2019 Hyundai Tucson in park at my friends home to drop her off, the car involuntarily surged/accelerated forward over a cement curbing and landscaping timber and slide down a small incline into a tree and landscaping boulder! After looking on line concerning the malfunction it seems there are abundant claims from other 2017-2019 Hyundai Tucson owners that have experienced this exact mechanical defect under this frightening description of a surge or acceleration out of the drivers control! It's the craziest, scariest thing ever. We have taken the car in for a recall concerning the check engine light regarding the catalytic converter prior to this incident. The car is well cared for and maintained and has never been in any accident.

- Kaysville, UT, USA

Car has had shaking during acceleration and a noise (rattle/knock/tapping) from the engine for last 18 months. Dealer -??could not find any issues-?? until July 31st 2025 when the engine broke down with a P1326 code (connecting rod bearing failure) and the engine seized. Vehicle is under class action class with extended 150k 15 year warranty on engine for this concern. Had recall performed for the knock sensor detection system as required by class action. Dealership first asked for most recent oil change record (provided) and than informed that Hyundai declined repairs due to full maintenance records not being submitted. Have now submitted full maintenance records to dealer and Hyundai directly since I purchased in 2023 as certified pre owned. All maintenance performed as per factory recommendations In manual. Hyundai still declining repairs without any explanation.

- Hicksville, NY, USA

On a busy highway, my car broke down. It was due to the rod bearings, specifically, the Hyundai Theta "extended warranty"/recall issue, or "recall" issue. There is currently a class action lawsuit against Hyundai. I had the car towed to Hallmark Hyundai in Nashville, TN. I, however, live in Louisville, KY and I was making a road trip to Nashville, TN. I was told by the Service Rep in Nashville that they couldn't provide me with a loaner vehicle because I would be driving it, back home, out of state to Louisville, KY. I paid for a rental car out-of-pocket. Hyundai Corporate told me it would take 60 days to get reimbursed. I picked up the car at the beginning of July, 2025, after the engine was replaced by Hallmark Hyundai. I was told by Hallmark Hyundai that a service employee performed a test drive but it was immediately noticeable to me that there were still issues. I noticed the gears shifting abnormally and problems with acceleration once I first started driving it, post repairs, but assumed I would be told to give it time. Today, [XXX], the car began to have difficulty accelerating once again, and the engine light illuminated. I couldn't accelerate beyond 45 mph. I phoned Hyundai Corporate Customer Care, relayed the issues, and said I needed a rental car the following morning for a job pre-hire meeting and couldn't pay for one since my credit card was already maxed out due to the first out-of-pocket rental. They refused. They told me to work it out with my local Hyundai dealership. The problem with all of this is that the consumer still incurs many hardships even though the car manufacturer is at fault and the dealerships don't always follow the settlement requirements of providing alternate transportation, a loaner or rental. The manufacturer and dealers are not held accountable and settlements that purport consumer recourse are more geared towards the manufacturer staying in business than the consumer being compensated fairly. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (F

- Louisville, KY, USA

There is a significant issue for engine oil consumption that may cause the engines to seize up and require repairs and or replacement. To that end the vehicle purchased has a 15 year 150,000 mile extended warranty included. The vehicle is now in for additional repairs related to the same issues and verification if a new engine will be required.

- Jamestown , NC, USA

My catalytic converter failed at roughly 70k miles (confirmed by mechanic and replaced). I have now been having transmission issues ever since, starting with the rpms jumping up on their own when trying to downshift (reproduced by mechanic) and ending with the car fully going into limp mode while in the middle of driving on the highway at speed. The former never triggered a light or produced codes, and with the latter the CEL flashed three times at the very start of the breakdown, and then went off and never came back on, despite the obvious problems the car was having.

- Frederick, MD, USA

I took my vehicle to my mechanic for inspection check up. My mechanic told me and supplied paperwork from their scans that the P0420 sensor in the cat converter was shot again (3x in 5 years) and needed to be replaced. The engine light had come on 3 weeks beforehand and I had it read and knew what it was. They sent me to Hyundai dealer as it was under warranty with documentation. I get to Hyundai dealer tell them it needs the sensor for inspection and an investigation for oil leaking from back of the engine. I also told them I was adding 2-3 quarts of oil between oil changes. They told me my mechanic over filled oil by.5 quarts and that's why the engine leaked. They investigated after I disputed by saying an oil change had been performed the day I brought it to them and found a bad head gasket, fuel pump seal, and oil pan seal. They charged my extended warranty for those repairs, shut off engine light for cat converter sensor without replacing it, and made me do an oil consumption test of 1000 miles. Car was still not inspected at this point. After 35 miles check engine light comes back on. Cat converter sensor P0420. I take it back in. They tell me they won't replace it until the oil consumption test is done because they need to know if oil is coming through the exhaust pipes (it was). I complete the test and go in. They tell me engine is burning.5 quarts of oil/1000 miles which is acceptable and as long as I complete oil changes every 5000 miles I will be fine. They then tell me if I want sensor replaced I'm 800 miles over warranty so I have to pay $2400 to replace. Called corporate they're only willing to cover half the repair as "good will" for the cat converter and was quoted $1300 by the dealer in question. Almost a month and still not fixed and still can't get car inspected because the check engine light is tripped by the P0420 sensor in the cat converter. It's the only vehicle my family has. I'm forced to pay to have transportation.

- Canandaigua, NY, USA

Knock sensor keeps throwing codes, the car will not accelerate over 20mph and under 2000 rpms

- Burlington , KY, USA

- replaced catalytic convertor twice - Check engine light on, needs another catalytic convertor - Exhaust fumes are coming back into my car through the AC vents, I-??ve had to pull over due to being nauseas and extremely dizzy. - The dealership will not answer my phone calls, but will answer another phone because I have called from another phone and they picked up immediately - Was told from a service advisor that they would not help me -?? unless the car blew up -?? - My car did recently,8/8/24, shake aggressively, the check engine light flicked rapidly and a strong puff of fumes came through my car - They will not help me because they stated that my rod bearings are not rotted therefore I do not qualify for assistance and everything would come out of pocket, the engine replacement, the catalytic convertor due to me being a few thousand miles outside of my 100,000 warranty. - I have the invoice stating oil is leaking profusely out of my engine - I was told within the last 2 weeks that if my car was to actually seize, Hyundai is not responsible bc when they kept telling me to bring my car in, they kept diagnosing it so they quoted me at about $5k to fix everything.

- Cresco, PA, USA

-??ve replaced the catalytic converter two times, the check engine light is on so it says I need another catalytic converter, that was in June 2024. The car was at the shop yesterday, needs catalytic converter and oil is pooling all throughout the car, fumes from the exhaust are coming back into the car which makes me physically ill. The engine revs and slows down by itself, it goes through oil on such a regular basis that I have to carry a full size jug of oil with me at all times because I need to put it in before I leave work and when I am on my way back home, the dipstick will be dry.

- Cresco, PA, USA

When u try and pull out in traffic the Car hesitates and kicks to pick up and go. Had a few mechanics look at it and was told it is the Torque Converter With the Vehicle only having 19,000 miles on it.it is a huge safety issue and Hyundai is saying my Tucson has no warranty on it. So what I till crash and sue Hyundai?

- Columbus, OH, USA

I was driving approx 55mph on [XXX] in my 2019 hyundai tucson when the check engine light came on and the engine started to stall. I felt the acceleration dying down in the middle of busy highway traffic. Gray smoke started coming from the hood cracks. I luckily was in the right lane already, so when I could I veered off to the shoulder and the car quit. The smoke was increasing badly. Ppl from the highway were yelling its going to blow up get away from it! I was so scared. I grabbed my phone and keys and ran as far as I could while dialing 911. Within a couple minutes flames were swallowing the entire engine and front of the car. I am furious. I researched online and hyundai has had many similar incidents with this car and other with this engine ! These need to be banned and taken off the road before they kill anyone else. Ppl have been injured and killed from similar situations just like mine. I thank God I made it out of this horrific situation alive. But now I have no car and am at risk of losing my job and then housing. I thought I would have this car for years. Now I'm traumatized and without transportation. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

- Kings Mountain, NC, USA

I was driving on the highway when my vehicle started decelerating and shutting down completely. I ended up safely pulling over because it could-??ve been a serious accident and called FHP they tested my car code p1326 came up I had it towed to the dealership where they assured me I had the extended warranty and that the car should be covered and I don-??t have to pay out of pocket. What the dealership told me would take 2 days has now been almost a month and still counting. I-??ve had 3 denials for engine replacement due to being outside of warranty with Hyundai even though I have the extended warranty. The dealership has sent pictures and spoke with my case manager at Hyundai to confirm that the engine failure was due to the bent connecting rod bearing that is again covered under warranty. They came back and said other codes populated showing the cause was not the rod bearing but that has to be false. One of the other codes was regarding coolant and I-??ve never had any issues with my car overheating or anything prior to my engine shutting down on the highway. I never had any flashing lights or warning signals on my dashboard. This was very unexpected and I refuse to pay for a repair that I didn-??t cause especially when this is consistent with Hyundai and their engines. This is a 2019 I should not have any issues. I need a solution quick

- Tampa, FL, USA

The components that failed are the engine and transmission and parts associated with the functionality of these parts. It is currently in the shop but will be available for inspection upon request once repairs are complete. My safety and others were put at risk when these malfunctions occurred (driving incredibly slow on the highway could cause an accident, accelerator malfunctioning that might break, broken down late at night hours from home, parts catching fire from leaking oil, etc.). The problems have been acknowledged by my warranty company and the two repair shops that have serviced it. My car was inspected by Geico Insurance Company after I got rear-ended and needed to file a claim, however, the inspection was not specifically on my engine/transmission. The warning dash lights didn-??t seem to come on until it was too late, especially during the transmission issue. I was driving around for days leading up to this issue thinking it was acting weird because it was due for an oil change but when I got one and nothing improved, I knew something was wrong. The check engine light did not come on until the car started to actively shut down and not move when I pressed the gas. The full detailed complaint is attached and receipts for repairs are available upon request. Attached is an overview of parts and pricing from the warranty company for the two claims.

- Daytona Beach, FL, USA

I have to add oil to my every 2 days.. there is no leaks and I get frequent oil changes. Also acceleration to meet state limits my Rpm go super high not wanting to shift. Again no leaks and have checked so there is good transmission fluid in

- Conneaut, OH, USA