Transfer case gasket leaks. According too mechanic I talked with, this is a constant problem on the 1996 model Jeep Grand Cherokee.

- Winston-Salem, NC, USA

Owner of 1996 Jeep Cherokee - problems with transfer case began in 1998-1999, at 50, 000 miles. Transfer case has been replaced and rebuilt on 3 occasions. Feb 25, 2003 took vehicle to dealership - same problem, need to replace transfer case again. Have been advised that once our warranty expires, they will not warranty the transfer case replacement. Will be happy to provide details and records of over 17 repairs to this vehicle. After second transfer case replacement contacted Chrysler because we felt this was a defective part. Each time it is replaced or repaired, the repair does not last. Daimler Chrysler representative refused to meet with us to review problems.

- Greenfield Center, NY, USA

1996 Jeep Grand Cherokee has failure in transfer case. This is evidently a consistent problem with this vehicle. No evidence of recall. Total cost to repair is approximately $1100. The vehicle would not shift out of 4 wheel drive.

- Stafford, VA, USA

Consumer rear axle and transfer case failed at the same time. Nlm

- Grand Junction, TN, USA

The front and rear axles broke, vehicle is also locked in 4 wheel drive. Nlm

- Chapel Hil, NC, USA

Transfer case makes a grinding noise and will not engage unless you back up the vehicle.

- Bluewell, WV, USA

While shifting gears from 4 wheel hi to 4 wheel low and back, the transfer case makes a grinding noise.

- Encinitas, CA, USA

Vehicle transfer case makes a grinding noise. Four wheel drive will not engage unless vehicle is placed in reverse and allowed to move backwards.

- Bluewell, WV, USA