10.0
really awful- Crashes / Fires:
- 0 / 2
- Injuries / Deaths:
- 0 / 0
- Average Mileage:
- 37,582 miles
About These NHTSA Complaints:
The NHTSA is the US gov't agency tasked with vehicle safety. Complaints can be spread across multiple & redundant categories, & are not organized by problem. See the Back button — blue bar at the very top of the page — to explore more.
I just pulled out of quick trip after putting $60 in gas in and right about 35 mph around 1500rpm I heard a loud "pop" the Jeep shut down, then flames came from both sides of my Jeep, almost burning my leg. (I had the doors and top off the vehicle.)
- Sapulpa, OK, USA
Every time I fill my fuel tank gas leaks out all over the Jeep body the bumper, my feet, and not just a little but a lot!
- Green River, WY, USA
When I fill up the vehicle, gas flows backwards out of the filler neck and pours down the side of the vehicle onto the ground. I loose at least 12 ounces.
- St Louis, MO, USA
When filling the Jeep up for the 1st time since buying it fuel was spit back out when it was full.
- Cypress, IL, USA
Every single time I go to fill up my 2008 Jeep Wrangler sahara gas spills down the side and onto the ground. When the pump clicks off it is already over-filled and spills everywhere! I've tried holding it at different angles and pushing it farther in but nothing works except not filling up my vehicle entirely. This is a serious fire risk and not to mention the way the fuel is ruining the paint and discoloring my bumper!
- Middleton, ID, USA
The fuel spills back during refueling.
- Greenbelt, MD, USA
Upon filling up the vehicle, fuel rushes out of the inlet and onto the fender guard, body, and bumper and on the ground. This has happened repeatedly at every fill up. After the first three times this happened I caught as much as possible from the spill = 3 pints +. it shoots all over my hands, arm, and leg. Very dangerous and hazardous having gas all over me.
- Morganton, NC, USA
Gas spews out and does not shut off correctly when tank is full. Keeps shutting off gas when it is not full causing it to take an extremely long time to fill, but will not shut off when tank is full and will spit back gas and over flow.
- Diboll, TX, USA
Problem occurs when fueling. Auto pump shutoff does not work with this gas tank filler, fuel sprays out of fill up. Only time fuel does not spill out if you very slowly add fuel and stop before tank is full.
- Wailuku, HI, USA
When refueling, the vehicle ejects between 1 tblsp and 1 pint of fuel from the filler neck depending on the pump, outside temperature, and fuel level prior to filling. Fuel is ejected a distance of up to 6' (observed). Fuel is only spilled when the tank is filled and at termination of the procedure. Warm temperatures eject more fuel. This occurs 100% of the time and I need to warn attendants so they don't get fuel splashed on them. We are in Oregon where self-service is not allowed.
- Philomath, OR, USA
The contact owns a 2008 Jeep Wrangler. The contact stated that while refueling, fuel spewed out of the filler neck. The vehicle was taken to the dealer where it was found that the fuel tank had failed. The vehicle was repaired. The manufacturer was made aware of the failure. The failure mileage was 28,064 and the current mileage was 62,700. Updated 04/09/13
- Defuniak Springs, FL, USA
Had been smelling raw gas inside and outside vehicle for several months. Finally tracked down to fuel line coming from gas tank. Plastic elbow under driver seat (RHD postal Jeep) has pinhole and has been squirting a fine stream of fuel onto bottom of vehicle. If it had squirted on exhaust or any other hot surface, it would surely cause a fire. Wonder if any other elbows have failed on other vehicles, and also if there are any fuel line elbows in the engine compartment? could be explanation for engine fires that are being investigated. Local Jeep dealer had replaced fuel tank on 10-19-11 due to a recall about fuel spilling out of filler tube after fuel handle clicked off. Never noticed gas smell before the tank was replaced.
- Cumberland City, TN, USA
When filling up the gas tank, if allowed to fill completely it will puke gas back out after the automatic pump shut off. Enough gas to run down the side of the Jeep and on to the ground. Since the first time it happened it will do it every time if I do not stop it early.
- Whitesboro , NY, USA
The contact owns a 2008 Jeep Wrangler. The contact stated that after refueling the vehicle, fuel spewed out of the filler neck. The vehicle was taken to the dealer who diagnosed that the filler neck and fuel valve needed to be replaced. The manufacturer was made aware of the failure who did not offer any assistance since the vehicle was no longer covered under warranty. The vehicle was not repaired. The failure mileage was 16 and the current mileage was 26,000.
- Reno, OH, USA
The contact owns a 2008 Jeep Wrangler. The contact stated that when refueling the vehicle, fuel will spill out leaking all the over the ground. The vehicle was taken to an authorized dealer where the vehicle was diagnosed as needing a new fuel tank. The vehicle was not repaired. The failure mileage was 70,000 and the current mileage was 75,000. Updated 05/08/12
- Simpson, IL, USA
The contact owns a 2008 Jeep Wrangler. While refueling, the contact noticed fuel was spilled from the vehicle. The contact called the dealer and was informed the the check valve in the fuel system may need to be replaced. The vehicle was not repaired. The approximate failure mileage was 26,000.
- Jefferson , GA, USA
Fuel overflow issue. When filling up my gas tank at the pump fuel will spray from the gas tank before the fuel nozzle shuts off. This has occurred at multiple gas stations and multiple pumps and is now occurring every time I try to fill my tank.
- Lafayette, CO, USA
Spits fuel from filler when refueling.
- Rock Valley, IA, USA
Every time I fill up with gas, the gas flows out of the fuel tank all over the car, me and the ground. This happens right before the tank is full and it doesn't shut the gas pump off.
- Macomb, MI, USA
- Sapulpa, OK, USA