Kia engine recall engine knocking sound followed by full loss of power on the highway ( in motion) and all dashboard lights lit. With mainly engine and oil lights lit first. I coasted to a parking lot off the exit I was on and the engine started smoking once in park. The cabin and engine smelled of burning. All of my newly changed oil was burnt up as well. Car would not turn over when I pushed the start button. Car maintenance is kept up to date. A few months prior my engine malfunction light kept coming on and I had it looked at turner Kia during an oil change on 4/3/17 and they stated they didn't know what the issue was and continued to allow me to drive the vehicle. The engine malfunction would come on time to time since that date.

- Boiling Springs, PA, USA

1) 59,000 miles engine has developed rough idle when stationary. Idle is worse under load conditions. RPM fluctuates between 500-550 when in drive. Idle at 600 when in park. Momentary loss of power when accelerating. There is a NHTSA recall on the 2.4 gdi engine. Kia dealers claim the engine is normal. What are the symptoms when the engine is starting to fail. 2) intermittent engine won't start. Electronics activate, but engine does not start. Kia dealers continue to claim everything is normal since they cannot duplicate the problem. Have been stranded due to engine not starting.

- San Jose, CA, USA

When I cold crank it the engines sound very very loud rattle and settles to a loud rattle after about getting warmed up with the engine vibrating which could also be seen. I took it in warmed up & the technician stated after a review, he didn't hear a rattle or a knock (thats a lie, I am going back again & review with the tech) I also hear a rattle from the left cv axle when the trac control comes to play, turning on a hard right & a thump when pulling hard on a wet pavement on a green light. This cold crank rattle cannot be heard on other Optimas when I ask to hear them start the other cars up. This is ridiculous this is a 30000 mile car & should be having a vibrating engine & a cold crank rattle or any rattle at all when warmed up, it should be smooth.

- Chicago, IL, USA

I have taken my vehicle in for a test due to their engine recall campaign in Nov/Dec 2017. My car passed their "so called" listening test, but I am still uncertain if that test is adequate. I am concerned because what I have read from other people is that the engine quits at highway speed without notice even after passing the test. I put my family in this car almost on a daily basis and I am very concerned for safety.

- Fairfax, VA, USA

The contact owns a 2014 Kia Optima. The contact stated that the manufacturer had not notified him of NHTSA campaign number: 17V224000 (engine and engine cooling) within a reasonable time frame. The dealer (Kia country of savannah, 1 park of commerce blvd, savannah, ga 31405, (912) 335-4176) was contacted to schedule a recall repair, but the part was not available. The vehicle was not repaired. The manufacturer was contacted to determine when the part would be available. The contact had not experienced a failure. Parts distribution disconnect.

- Hinesville, GA, USA

The contact owns a 2014 Kia Optima. While driving 35 mph, a clicking noise was heard coming from the engine compartment. The engine warning indicator illuminated. The contact coasted the vehicle to the side of the road. The contact powered off and restarted the engine, but the noise grew louder. The vehicle was towed to rodeo Kia (10685 papago fwy, avondale, AZ 85323, (623) 298-1200), but was not diagnosed or repaired. The VIN was included in NHTSA campaign number: 17V224000 (engine and engine cooling). The manufacturer informed the contact to take the vehicle to rodeo Kia for the repair. The approximate failure mileage was 78,000.

- Phoenix, AZ, USA

The contact owns a 2014 Kia Optima. The contact heard an abnormal ticking noise coming from the vehicle. The failure occurred without warning. The contact received notification of NHTSA campaign number: 17V224000 (engine and engine cooling). The parts to do the repair were unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. Turnsviller Kia (2900 NJ-42, sicerville, NJ) was contacted and stated that they could not replace the engine prior to a failure per Kia policy. The manufacturer was made aware of the issue. The failure mileage was approximately 52,783. Parts distribution disconnect.

- Lawnside, NJ, USA

Driving down the highway when my 2014 Kia Optima started to make a knocking sound with smoke coming from engine. Pulled over and turned vehicle off and not long after engine caught on fire. My car was a total loss. Found out after the fact that car had recall on it. Contacted Kia Consumer Affairs and they did nothing to explain why this would have happened. * (recall related incident)

- San Antonio, TX, USA

On Sunday 02/11/2018 my car died getting off the highway doing 70mph. I was able to get to a safe place car is a 2014 Kia and has 46,763 miles on it. Had it towed to the dealership. It's also part of the recall notice I received 10/04/2017, 17V224. Call Kia 3 times on 02/19/2018 first time I was saying that my car still wasn't fixed from the long block that was replaced on Thursday that was still making funny noises and that there was a sweet burning smell. Was told by the 1st person I talked to give it time and it will work itself out. That sweet smell was the oil burning off of the engine that they just replaced and that it was no big deal. I call back not even an hour later to say my heat stopped working they told me that I would have to have a diagnostic run on it and then it will cost me $99 and if they determine wasn't part of the engine work they had just done. That person made a 10 a.M. appointment for 2/20/2018. Since my heat wasn't working I had to keep using my wipers and fluid, because the defrost wasn't working. When home I went to put more windshield wiper fluid in the car I noticed that they did not put coolant in the car which is needed to cool the engine so it doesn't seized up stall or blowup. So when they replace the engine they didn't put coolant in the car which is needed. So now I'm having the car towed back to Kia so they can make sure that this engine isnt shot now also. That's also the reason the heat stopped working I'm sure. I've been driving this car since I got it back on 02/15/2018 with no cooling probably driven it 20 hours since I'm a lyft driver. So after they put in a replacement long block because of the recall this Thursday 02/15/2018 they didn't put coolant or antifreeze in the car so II blew the new engine and also messed up my starter. Had it towed back to the dealership 02/19/2018

- St. Paul, MN, USA

WE STARTED REPORTING ISSUES THIS PAST JULY TO OUR DEALERSHIP, KIA RIVERGATE IN MADISON, TN. THEY HAVE HAD OUR CAR IN THREE TIMES AND KEEP TELLING US THERES THINGS "WE" NEED TO FIX.MY CAR IS STILL ON WARRANTY AND IS UNDER A TOTAL ENGINE RECALL. THE CAR STARTED WITH A KNOCKING SOUND IN THE ENGINE AND HAD ISSUES WHEN WE WOULD ACCELERATE. THE CAR DID NOT WANT TO ACCELERATE AT ALL CAUSING US TO STALL IN THE MIDDLE OF THE HIGHWAY SEVERAL TIMES. THEY TOLD US NOTHING WAS WRONG BUT THEY REPLACED A SENSOR. THE CAR CONTINUED TO KNOCK AND STALL. I ASKED THEM IF IT WAS MY TRANSMISSION AND THEY SAID NO, IT'S FINE. THEY SAID WE COULD TRY REPLACING THE BATTERY AND THEY CHANGED THE OIL (AT OUR EXPENSE). THE CAR HAS HAD BATTERY REPLACED THREE TIMES BECAUSE THEY TOLD US THAT WAS THE ISSUE THE FIRST TWO TIMES. THE CAR HAS GOTTEN MUCH WORSE IN THE LAST FEW MONTHS. THE LAST TIME WE TOOK IT IN TO THEM THEY ARE NOW SAYING THAT IT MIGHT BE THE FUEL INJECTOR. ONCE AGAIN THEY ARE STATING THAT WE MUST PAY FOR IT. I'VE CALLED THEM BECAUSE THE CAR HAD HUGE CLOUDS OF SMOKE COMING OUT THE BACK AND IS SHAKING EVEN WORSE. ONCE AGAIN THEY SAID THERE'S NOTHING THEY CAN DO. I TOLD THEM WE ARE HAVING TO ADD OL 3 TIMES A WEEK WITH NO SIGNS OF A LEAK. MY CAR IS ONLY 3 YEARS OLD AND I REPEAT, MY CAR IS STILL UNDER WARRANTY AND IS ON A RECALL FOR SEVERAL ISSUES INCLUDING THE ENGINE. NOW MY CAR ISN'T DRIVABLE AT ALL. IT STARTED SHAKING TO THE POINT OF THROWING US FORWARD IN THE CAR AND SMOKES LIKE IT IS ON FIRE AND THE CHECK ENGINE LIGHT WILL NOT GO OFF AT ALL, SO YOU'RE TELLING ME THERE'S NOT AN ENGINE ISSUE? [XXX]. EVEN A FUEL INJECTOR WOULD BE CONSIDERED PART OF THE ENGINE BECAUSE IT HAS TO RUN THROUGH THE ENGINE TO MAKE THE CAR RUN. I'D LIKE TO KNOW WHY KIA IS NOT HONORING THEIR WARRANTIES OR RECALLS. MY NEXT STEP IS TO CALL AN ATTORNEY AND SUE KIA. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

- White House, TN, USA

TL-contact owns a 2014 Kia Optima LX.... recall letter from Kia regarding engine replacement... defect causes engine to stall.... contact filed complaint through Kia... engine of vehicle has not stalled yet... contact upset with Kia service.... Kia stated engine needed to go through testing before engine is replaced.... contact had state check engine light came on while driving then went off. 1recallsassociated with this VIN Mar 31,2017 manufacturer recall numbersc147 NHTSA recall number17V-224 recall statusrecall incomplete summarykia motors America, Inc. Is conducting a safety recall campaign to inspect, and if necessary, replace the engine long block assembly on the following vehicles: * all 2011-2013 my Optima vehicles equipped with the 2.4L gdi and 2.0L turbo-gdi engines produced from August 12, 2010 through September 27, 2013; * all 2014 my Optima vehicles equipped with the 2.4L gdi and 2.0L turbo-gdi engines produced at kmmg from August 28, 2013 through May 15, 2014; * all 2012-2014 my sorento vehicles equipped with the 2.4L gdi engines produced from April 19, 2011 through February 10, 2014; * all 2011-2013 my sportage vehicles equipped with the 2.0L turbo-gdi engines produced from December 30, 2010 through August 30, 2013. Metal debris may have been generated from factory machining operations of the engine crankshaft and may not have been completely removed from the crankshaft's oil passages during the cleaning process. It was also determined that the additional machining processes of the crankpins safety risk if the warnings are ignored and the vehicle continues to be driven, the bearing may fail and the vehicle could stall while in motion. An engine stall at higher speeds can increase the risk of a crash.

- Jacksonville, FL, USA

On 10/24/17, while driving on cr 46 in sorrento heading home at 1800 hrs, my 2014 Kia Optima LX completely shut down at 55 mph for no reason. Lost power. I was able to put emergency flashers immediately and pull to the side reducing speed and completely stop the car. After that, was able to restart the car. Waited a few minutes after inspection in the engine compartment. No indication nor any visible signs of trouble. Was able to continue my drive at a much lower speed and flashers on as a precaution.

- Deltona, FL, USA

The contact owns a 2014 Kia Optima. After the vehicle was parked, the contact was unable to restart the vehicle. The contact stated that the electrical system failed. The vehicle was included in NHTSA campaign number: 17V224000 (engine and engine cooling). The vehicle was not taken to be diagnosed or repaired. Neither the dealer nor the manufacturer were contacted. The approximate failure mileage was 48,700.

- Splendora, TX, USA

The contact owns a 2014 Kia Optima. While driving various speeds, the temperature gauge moved sporadically without warning. The vehicle was taken to the dealer (kings Kia 9600 kings auto mall rd, cincinnati, oh 45249 (513) 677-6700) where it was diagnosed with a sporadic temperature gauge that needed replacement. The temperature gauge was replaced, but the failure recurred a week later. The vehicle was taken back to the dealer where they replaced the thermostat. The contact stated that the issue persisted, but the check engine indicator illuminated and the sporadic temperature gauge continued to fail. The contact mentioned that the vehicle was at the dealer for three weeks. The instrument panel was replaced, but the failure continued. The contact received notification of NHTSA campaign number: 17V224000 (engine and engine cooling), but failed to notify the dealer of the recall. The manufacturer was made aware of the failure. The failure mileage was approximately 49,500.

- Cincinnati, OH, USA

The contact owns a 2014 Kia Optima. The contact received notification of NHTSA campaign number: 17V224000 (engine and engine cooling). The part was not available within a reasonable time frame to schedule the recall repair. The dealer (moritz Kia fort worth, 8501 West fwy, fort worth, tx 76116 (817) 560-6000) did not give a specific date for when the part would become available. The manufacturer could not provide an estimated date for when the contact's vehicle would receive the recall repair. The contact had not experienced a failure. VIN tool confirms parts not available. Updated 08/22/17

- Fort Worth, TX, USA

Bought car brand new at 30K miles whiite smoke starting coming out the exhaust. Took it to Kia dealership and they told me I had to furnish all my oil change receipts bc there was sludge in my oil. They told me I needed a new motor, a brand new car?! I would accelerate and the smoke would come out and when I started the car the smoke would come out. Just today my engine light came on and my car started sputtering. I recently went to 2 different Kia dealerships and not one sales rep mentioned the recall, nor the other 2 that were related to this vehicle.

- Cleveland, OH, USA

Took my vehicle in for a engine recall. It only took 10 minutes. No explanation on what was the process to check a recalled engine. No details on how and what was done to check the engine. This an indication that Kia is trying to save money. Also NHTSA should indicate on it's website before the remedy, indicate the process being used to check the engine. All they stated was pass.

- Deltona, FL, USA

Engine recalls. There is a knocking noise coming from the engine and sounds like a diesel engine. Kia says this is normal but others do not sound like this. Wondering if there is more to this recall than what they are willing to admit.

- Bentonville, AR, USA

Engine rattles between 1000 to 2000 rpms.

- Deltona, FL, USA

My cars engine started making a knocking noise during idle and at highway speeds. This is very concerning because I do need my car everyday to get my 18 month old daughter to daycare and then to work. The default answer from the dealership is "we don't hear anything" which is total bs, you can clearly hear it knocking. I don't want my cars engine to have a catastrophic failure during rush hour traffic when I am with my daughter. That could cause us to be in a very serious accident which I dread. Kia needs to own up to the problem and get it fixed and stop worrying about the money they will lose due to fixing it. I am glad NHTSA exists, it keeps big powerful companies like Kia in check. Any help will be greatly appreciated. Thank you [xxx] information redacted pursuant to the Freedom Of Information Act (FOIA), 5 U.S.C. 552(B)(6).'

- Bernalillo, NM, USA