Using lots of oil

- Elkhorn City , KY, USA

All maintenance performed at same manufacturer authorized dealership. My engine is currently full of sludge due the oil pressure switch under the recall not operating correctly before and after repair The was reported to dealer in October 2023 who engaged the manufacturer who authorized the repairs in May 2024 when vehicle would not hold oil at all.Car has not maintained oil level since repair.It has been in dealers since October 2024 seeking assistance from the manufacturer Recall MC-10210267-0001

- Stockbridge , GA, USA

I own a 2017 Kia Sedona with approximately 120,000. It has the 3.3L V6 engine. While driving, the vehicle lost power and would not run. The lights and the dashboard would come on, but it would not turn over to start. I took it to a mechanic, and they confirmed that the engine had seized up and would have to be replaced costing $11,000. I then had it towed to the dealership that I purchased the vehicle. They also confirmed that the engine had seized up and would have to be replaced at a significant cost. I had no warning that anything was wrong with my vehicle as the check engine light did not come on. I did hear a slight knocking the day before this happened. My husband checked the oil and added a quart of oil, which was unusual since we had not seen any oil on our driveway. I did have a warranty, but it lapsed due to being over the mileage cap by 2,000 miles.

- South Charleston, OH, USA

The Engine failed at 63,758 miles. Lancaster KIA in Lancaster, PA indicated the engine has metal shavings everywhere.

- Lancaster, PA, USA

Motor has been consuming oil.all oil and maintence was done to this vehicle.on Monday the 18of November 2024 while driving too work the motor blew up putting oil everywhere.almost cause a major accident it had too be tow back to my house.

- Dunbar, PA, USA

Engine seized. Purchased car on 9-16-24. One 9-17-24 I went to Valvoline and purchased a full synthetic oil change. Within 2000 miles driven since oil change mechanic advised that there was no oil and no leaks. Valvoline assisted my mechanic in the investigation and claimed the Sedona had a oil consumption issues. Manufacturing issues. Car shut off while driving. No light illuminated prior to the shut off and even with no oil there is no check engine light or oil pressure warning.

- Stony Point, NY, USA

My engine seized. When I took it to my mechanic they stated it was due to low compression and that Kia engines were known for this issue. He suggested I take it to a Kia dealer to have them replace the engine. I took it and I was denied the replacement. I did some research and found that this issue was in fact very popular among Kia owners. Some expressing their engines actually ignited. I also found there was a class-action lawsuit against Kia for this exact issue. I noticed all Kia models were included in the suit except for the Sedona. During my research I found a mass of Sedona owners who had the same compression issues. It baffles me why my car wasn't included when it has the exact isdues as the other models made by the same manufacturer. I would like to file a complaint in hopes that other Sedona owners have done the same, and we can bring light to this issue, and possibly a solution.

- Hawthorne, CA, USA

Engine had sudden unexplained loss of oil followed shortly after by Engine failure due to broken rod

- Passaic, NJ, USA

my engine blew while driving on the highway April 2023. my connecting rod snapped. no check engine light or oil warning light ever came on prior to this happening. I had maintained oil changes every 2000 miles since purchase. oil levels were within normal range when this incident occurred. the car showed no symptoms of this happening prior to it happening. Kia has engine recalls but my vehicle was not listed in this recall.

- Turners Falls, MA, USA

We bought this van in September of 2023. No known issues-?? we-??ve kept up on regular oil changes etc. Over a month ago a slight tap started happening when vehicle started up, took it three places and all 3 said we needed a new engine. We just hit 100k-??. Within two days of those opinions, engine seized while I was driving. No injuries but a car this new with no known issues this is not ok. Zero lights came on the dashboard. No check engine light, nothing. It-??s been in a shop for over a month while we wait for a new engine to come in. Would never ever buy another Kia. Dealership and two local places both told us they do not know what happened or why this happened.

- Joplin, MO, USA

The contact owns a 2017 Kia Sedona. The contact stated while driving 45 MPH, the connecting rod punctured the engine causing an engine oil leak. As a result of the failure, the vehicle stalled. There was no warning light illuminated. The vehicle was towed to a local dealer where it was diagnosed and determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 117,000.

- Durham, NC, USA

The contact owns a 2017 Kia Sedona. The contact stated while driving 70 MPH, the vehicle lost motive power. There was no warning light illuminated. The vehicle was able to be restarted; however, the failure recurred. The contact also stated that there was smoke coming from the engine. The vehicle was towed to the dealer where the vehicle was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 120,000.

- Katy, TX, USA

July 5, 2024 Engine started to make a noise, had inspected at a local repair shop July 9, 2024, they diagnosed it as "crack in the front valve cover due to what seems to be something internal to engine coming apart. This vehicle is going to need a new engine." No warning lights were on, no service needed lights. yes, available currently for inspection as long as I don't trade it off. safety could have been at risk if it seized up while on interstate Insurance said it wasn't covered and have not warranty insurance no symptoms, no warning lights, nothing. Driving home on Friday the 5th when 5 miles from home it felt like it was loosing power and didn't want to accelerate. then I noticed the noise. Still no lights on dash

- Liberty, MO, USA

The engine seized suddenly and put my family in danger. There are recalls on other kia engines and it is clearly an issue but KIA is not taking responsibility for it and has told us we must pay 13K for a new engine or they will give us $500 to "take it off our hands" --- this is wrong. We have kept the vehicle well-maintained and have all the records to prove this. It has just over 100,000 miles on it and we still owe money on it. KIA is putting families in danger but not acknowledging that there is a possibility of engine failure in the Sedona van. There have likely been deaths and injury as a result of this and yet, nothing is being done! Please hold KIA accountable and insist they do a nationwide recall for all engines that are affected by this defect.

- Durham , NC, USA

My engine made a knocking noise and stopped working while I was driving down the road, without any warning. Then it would not start / work. It was towed to a Kia dealership, and I have been told I need a new engine, at the cost of $10, 750. The van has 135,000 miles on it. This van has the 3.3-liter V6 Gasoline Direct Injection (GDI) Lambda Engine. The repair report from Kia states that it "needs a long block due to engine has bottom end noise and is seize up".

- Xenia, OH, USA

I was driving my 2017 Sedona and without any indication or check engine light, the motor started to make a loud knock and it ultimately seized up. Leaving me stranded. I have the oil changed per guidelines. There was no warning, no indication that the engine was going to spontaneously seize up. I was on a busy highway and was barely able to get to shoulder. I started to research this issue and found that this is a well known defect in the 3.3L lambda 2. Why isn-??t something being done about this? Completely unsafe!

- Tonganoxie, KS, USA

Engine crankshaft failure suddenly

- Doraville , GA, USA

The contact owns a 2017 Kia Sedona. The contact stated that while his wife was driving at an undisclosed speed, the vehicle made an abnormal sound and shuddered before stalling. There were no warning lights illuminated. The vehicle was towed to the residence. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 137,000.

- Bay City, MI, USA

We noticed coolant leaking. We took it to a dealer and they replaced coolant control assembly/ temperature control piece. Also the O-ring that connecting to the engine was leaking. However, this is the 2nd time we are replacing the piece in 3months (not the o-ring). We did that. And spent $900 on it. As soon as we drove it 11miles home, there was oil and coolant leaking again. Took it right back. And there was fluid in the engine. Guy believes it's the head gasket. Out car isn't running. We don't know if we should replace, or junk it and have a loss of money. We are so frustrated. We have 125,000 miles. There were no warnings, no lights, just us noticing the coolant leaking, and the reservoir being full. We have pictures and have taken it to multiple mechanics and dealers.

- Postville, IA, USA

Blown engine approx 104,0000. Metal shavings in oil.

- Boylston , MA, USA