I am reporting a serious safety defect regarding my 2022 Kia Sorento Hybrid (Mileage: 91,661). The vehicle was diagnosed with an internal short in the EGR (Exhaust Gas Recirculation) Control Unit (Error codes P0404, P049D). Upon inspection, significant engine oil intrusion was found inside the EGR unit. The EGR system is designed to handle exhaust gases only; the presence of liquid engine oil indicates a critical failure in the powertrain system (likely the PCV system or turbocharger seals) which is forcing oil into the intake/exhaust tract. Safety Risk: This defect causes the EGR system to short-circuit, which can lead to unpredictable engine performance, reduced power, or sudden engine stalling while driving. Any sudden loss of power on a highway poses a severe risk of a rear-end collision. Furthermore, oil intrusion into electrical components increases the risk of thermal incidents or localized fires within the engine bay. Despite the vehicle being within the 10-year/100,000-mile Powertrain Warranty, the dealership (Suntrup Kia South) is refusing coverage, claiming the EGR is not a powertrain component, while ignoring the fact that a powertrain failure (oil bypass) is the root cause of the damage. I request NHTSA to investigate this "oil intrusion into EGR" issue as it appears to be a systemic defect in Kia-??s hybrid powertrain that compromises vehicle safety.

- Saint Louis, MO, USA

While driving from Phoenix to Tucson in midday traffic, the vehicle displayed a "Check Transmission" error message. Immediately following this warning, the vehicle experienced a significant loss of motive power while navigating a busy intersection. The car would not shift gears appropriately to maintain speed or move out of the path of traffic, which created an immediate risk of a collision. I was able to avoid an accident, but the vehicle's inability to accelerate or change gears left me stranded in a hazardous location. Component Failed: Transmission/Transmission Control Module. Safety Risk: The sudden loss of power in an intersection put me and other drivers at risk of a high-speed side-impact or rear-end collision. Warning Symptoms: The "Check Transmission" message appeared moments before the failure. Inspection Status: We have had the recall taken care of on January 25, 2023 with 8810 miles at Peoria KIA initially. The incident happened on December 6, 2025 and the vehicle was taken to Royal KIA on December 6, 2025 for inspection.".

- Peoria, AZ, USA

The contact owns a 2022 Kia Sorento. The contact stated that upon starting the vehicle, the vehicle failed to accelerate while depressing the accelerator pedal. There was no warning light illuminated. The contact restarted the vehicle; however, the failure persisted. The contact called a mobile mechanic to the residence, and the mechanic diagnosed the vehicle with a defect in the transmission. The mechanic informed the contact that there was a recall on the model vehicle related to the transmission. Upon investigation, the contact discovered NHTSA Campaign Number: 22V760000 (Power Train); which was linked to the failure. The contact called several dealers in the area and was informed that the vehicle was not included in the recall. The manufacturer was notified of the failure, and the contact was provided with the same information as the dealer. The vehicle was not repaired. The failure mileage was approximately 55,000.

- Parlier, CA, USA

My check engine light came on and my SUV started sputtering so I pulled over called my Husband who came and had it towed to Langdale Kia of Valdosta, Ga.

- Valdosta, GA, USA

2022 Kia Sorento LX started off with rpm acceleration randomly. It progress and started happening multiple times during a ride. Took it to Jake Sweeney Kia dealership, they were not able to pick up on any codes. They said they tried a flight recording and couldn-??t record data, but not even 15 minutes off the lot the symptoms proceeded. Now the vehicle is trying to shift gears while in drive. I-??ve provided videos and the dealership responded back and said, -??After speaking with my manager about this situation I can't really do too much until it becomes a constant issue. I know that isn't what you want to hear but at this time without a check engine light or it happening all the time there isn't much I can accomplish for you.-?? Not only is this a safety hazard for myself and my child this is negligence on Kia and Jake Sweeney Kia Florence.

- Cincinnati , OH, USA

2022 Kia sorento under 86,000 miles is jerks intermittently but no codes are being shown. Currently at the dealership and tech suspects transmission, which has been reported by numerous consumers of this issue but the recall was only applied to certain Kia sorentos and it should be broader.

- Cincinnati , OH, USA

While driving my 2022 Kia sorento on the interstate a sudden check engine light illuminated and the car totally stalled out with a severe decrease in power causing me to almost be rear ended by interstate traffic before I could get off the road safely. After taking the vehicle to the dealership for diagnostics I was informed there was a P1C2D03 trouble code which is associated with the 8 speed dual clutch transmission indicating an internal fault in the electric oil pump of the TCU. Upon further investigation we find out this code was associated with a safety recall that went out for this particular Kia model and transmission. The original owner took this car in to have the recall repaired back in 2023 without the fault code showing or any issue presenting from the vehicle. They were simply taking it in to clear the recall they were sent. While it was at the dealership they flashed the system like they were supposed to do according to the campaign instruction and sent them on their way. Fast forward to now and I am getting this same fault that the recall was sent out for but I have the code which according to the campaign instructions Kia was supposed to replace the transmission due to a mfg defect. Kia is refusing to replace the transmission now saying the recall can not be reopened and since I am the second owner and my warranty is expired I will have to pay over $5,000 for a replacement.

- Meadowview, VA, USA

The vehicle will sometimes, after shifting from park to drive, roll backwards if on an incline, even while gassing. If not an incline when this occurs, the vehicle will not move forwards. This typically lasts for a few seconds before the transmission engages. This happens intermittently; the first time it happened to my family member, it almost caused an accident. Kia has attempted to repair this defect three times but has been unsuccessful. During the last repair attempt, the Kia tech told me that they-??ve seen multiple vehicles with this issue, and that it is -??normal-?? for Kia.

- Irvine, CA, USA

The engine light came on and then two hours later the entire system started flashing and the engine started stalling. The car would not accelerate and had to be taken to Kia. This is the SECOND time this has occurred. The first time, the engine froze and I could not accelerate on the highway. I barely got to the side and had to get towed to Kia. Please, please investigate this vehicle and the power train.

- Frederick, MD, USA

Thermal Module went out, causing car to not accelerate when pressing on the gas pedal. Mileage at 76,000

- Belvidere, NC, USA

Vehicle lost power and transmission failed. Vehicle only has 36,000 miles. Dealer is denying recall from manufacturer.

- Utuado , PR, USA

Transmission loses power.Does not go foward after being in park. Have to turn off car and start it again making weird noise never heard before when it starts and when you turn it off. Has happened several times while driving.

- Aurora, IL, USA

The contact owns a 2022 Kia Sorento. The contact stated while driving approximately 60 MPH, the vehicle started losing motive power. The contact stated that the accelerator pedal was depressed; however, the engine revved without the vehicle responding as needed. The contact stated that the check engine warning light was illuminated. The contact pulled over and turned off, and restarted the vehicle, and was able to drive the vehicle to the local dealer. The dealer diagnosed the vehicle and determined that a cylinder was clogged, and the engine needed to be serviced. The vehicle was repaired; however, the contact stated that later while driving approximately 40 MPH, the vehicle started losing motive power. The contact stated that the "Service Transmission" warning light was illuminated. The contact had taken the vehicle back to the same dealer where it was diagnosed and determined that the transmission had failed and needed to be replaced. The vehicle was repaired. The contact drove the vehicle back to the residence, restarted the vehicle, and shifted into reverse(R), and the contact heard an abnormal grinding sound with the "Transmission System Error" message displayed. The contact had the vehicle towed to the same dealer; however, the vehicle was not yet diagnosed or repaired. The manufacturer was informed of the failure. The contact researched online and related the failure to NHTSA Campaign Number: 22V760000 (Power Train); however, the VIN vehicle was not included. The failure mileage was 56,941.

- Apopka, FL, USA

Vehicle jerks and goes into a neutral mode while driving. Vehicle shifter still shows it's in "Drive", but vehicle stops moving. Once I drift over to the shoulder of the road, I can shut the engine off and restart. Then it moves. Twice this has happened now. Once on December 13, 2024 and again on January 24, 2025. I reported this to my dealership, Gurley Leep Kia with the first incident and they said it was just a fluke. They did not pursue inspecting anything on the vehicle, knowing some 2022 Sorento's were involved in a transmission recall. In both incidents I was driving on an incline. My VIN currently doesn't have a recall on it, but should. This could result in a crash.

- South Bend, IN, USA

Engine light came on while driving. Solid light. Car started to vibrate and felt like it would stall. Engine has only 38,000 miles. Kia Greenway Certified Technicians at Hickory. They charged me $200 for the diagnosis. They later said the check engine code was due to bad fuel injectors, I paid $950 for that service. That day I took the car out and after 5 minutes of driving it I had to go back to Kia to tell them my check engine light was on again. Now they said they had to drain the gas because the tank was damaged, They charged me $900 and $350 for the spark plug replacement, but none of that worked. The car continues to have problems and they don't know what it is. There is some defect in this car model that should be investigated because I have read on internet forums and I am not the only one with this complaint.

- Nashville, TN, USA

I have had this happen 4 times now with my Sorento hybrid where the gas engine does engage with the drivetrain, leaving only the electric motor providing power. All incidents have occurred where I was sitting idle with the vehicle on. All incidents occurred when I had the vehicle in ECO mode. 2 of the 4 incidents have warnings about pulling over immediately because the hybrid battery was nearly depleted. The only resolution I've had is to pull over or come to a complete stop on the highway and restart my vehicle. Afterwards, the vehicle runs normally. I have not brought this up with a Kia dealer due to others I've discussed with saying Kia does not know what is happening. The circumstances that replicate this problem are probably difficult to recreate.

- Louisville , NE, USA

The contact owns a 2022 Kia Sorento. The contact stated while driving 70 MPH, the forward camera was obstructed. The steering over corrected while turned off. The vehicle was accelerating and decelerating independently. The Forward Collision Avoidance system engaged without an object being nearby. Additionally, the driver-??s side seat belt randomly unlatched. There were no warning lights illuminated. The vehicle was taken to the local dealer, who was unable to duplicate the failure. The vehicle was taken back to the local dealer, who diagnosed and determined that the transmission and seat belt needed to be replaced. The vehicle was repaired, but the failure recurred. The manufacturer was contacted, who opened a case but declined to buy back the vehicle. The failure mileage was approximately 28,660.

- Shepardsville, KY, USA

While parked on a residential street. I started car and put it in reverse. Car would not reverse when I applied gas. I shifted to drive. Car would not go forward when I applied gas. Repeated attempt to reverse. No movement. Shifted into drive and after applying more pedal, almost to floor, car lurched forward. In just about 30 minutes later car again would not move when reversing. It did go forward in drive the second time. The Kia dealership has been dealing with a complaint regarding the car going into limp mode while merging in traffic...an on going problem since the car was at 25,000 miles. They have "reset" the transmission according to a recall notice but say they can not replace transmission without a "code" that verifies it is the transmission. This is a new issue but also unable to pull any codes. There is a definite safety concern with driving this car. What can I do.

- Granbury, TX, USA

The vehicle began misfiring while driving on the highway. The check engine light turned on. The vehicle shook violently when the gas pedal was pressed. The vehicle was unable to accelerate and required the driver to pull over on the side of the highway. This issue has presented itself several times since the original incident. After multiple visits to the dealer, the issue has NOT been resolved. The check engine light has been caused by code P0301 (misfire cylinder 1) as well as P0304 (misfire cylinder 4). Spark plugs and ignition coils have been replaced by the dealer, but the issue still persists. Forcing the vehicle to pull over and being unable to accelerate on the highway is risk to the driver's safety as well as the safety of other vehicles on the road. The vehicle also now struggles to start and begins misfiring when left off overnight and started cold.

- Salem, VA, USA

10/19/2022 -?" Vehicle stuck in drive and would not shift out of drive. Vehicle towed to the dealer and not touched for a day and a half. Dealer found walnut lodged in shifter column which was preventing the shifter from going into park. Dealer also performed software update on vehicle. 10/21/2022 -?" Picked up vehicle and it was shifting very hard through every gear, returned to the dealer for further repairs. 10/26/2022 -?" Picked up vehicle again and performance improved but it still shifted hard and lurched when coming to a stop and when going in reverse. Dealer stated that they had retrained the transmission and performed another software update related to the transmission. I told them that I was driving out of town tomorrow morning for 10 days and that this was the only vehicle I could take and asked if they could provide a rental. Dealer stated that the current issues would not cause any long-term damage and that I could bring it back when I got back in town and that they would take care of it then. 11/17/2022 -?" Returned vehicle to dealer to correct the previous issues, they said that they did another software update and that it is shifting properly. Performance has improved but the vehicle would still lurch when going into reverse and occasionally when coming to a stop. 12/22/2022 -?" Returned vehicle for scheduled maintenance and safety recall for the transmission. Another software update was performed and transmission has been working without issue so far. 4/18/2024 - When driving while accelerating we experience a significant loss of power and it will not accelerate as normal. I can have the pedal nearly to the floor and it will barely move. When this occurs you can see the @ symbol flashing on the dash but no other warning lights or indicators. This is the 6th time this happened since February of this year and it has happened 3 times while on the on ramp to the freeway. This has continues to occur at least 3 times a week every week.

- Carroll, OH, USA