I believe that I am needing the Knock Sensor Detection System updated. I have called the dealer and they have stated that my VIN # does not have any recalls. I do have the MIL Malfunction Indicator Lamp currently on.

- Vandalia, IL, USA

The engine system in my 2025 Kia Soul malfunctioned, as indicated by the activation of the P1326 warning light. This diagnostic code typically signals serious engine issues, such as potential rod-bearing damage. Despite this warning, the authorized dealership, Jim Bone Kia of Santa Rosa, only replaced the knock sensor after I asked to conduct a Bearing Clearance Test (BCT), which they claimed passed. However, prior inspections had revealed metal debris in the oil, which strongly suggests internal engine damage. The failure to conduct a thorough investigation into the potential engine damage poses a significant safety risk, as the vehicle could experience a catastrophic engine failure while in operation. Such an event could endanger my safety and the safety of others on the road. The dealership has not reproduced or confirmed additional issues related to the P1326 code, claiming they require further symptoms (e.g., audible engine noise or a repeat warning) to proceed with deeper diagnostics. This approach delays necessary repairs and leaves unresolved safety concerns. Additionally, the vehicle-??s catalytic converter was initially denied warranty coverage, despite being included under an extended recall. This created confusion and delayed essential repairs. The P1326 warning light appeared before service, and the knock sensor was replaced, but no further proactive measures were taken to address the root cause. The vehicle remains at risk of more severe engine damage and safety hazards.

- Santa Rosa, CA, USA

purchased vehicle on 10/12/2024 was driving it home the car started knocking, and loosing acceleration on freeway. the car was smelling of very volatile gas fumes. i put some gas in car for the trip home. drove about 15-18 miles had to pullover into the v shape of the merging section of a on ramp, . could not make it to the emergency lane on the freeway. used family members road side assistance to get car home, took it to the kia dealer (car pros moreno valley) towed to them because they said had to get a appt, . which they set up for today 10/25/2024. the intake person was letting us know it was just a update as if the fuel leak and oil leak was not a part of the recall and it would cost us 9000-13,000 to fix the engine plus the diagnosis of $240 getting the run around already for a dangerous situation. the car has caught fire for other owners, of the same year and make. the customer care person stated to me it is just a oil pan leak, as if the car is safe and anything else is our problem. the car reeks of fumes and could not be safe to drive. they were questioning us about the recall as to why it was not done" we told him we were not the owners we dont know if they got the notices" no, unknown only owned the car 0n 10/12/24 for 30 minutes before this started warning lights appeared on dash after knocking and acceleration went out. car was towed and left at kia dealer today. he was talking to us as if it was our fault the car was dangerous and could blow up while driving!!!

- Perris, CA, USA

I own a 2015 Kia Soul affected by recall SC200, which addresses engine compartment fires due to oil/fuel leaks and potential engine damage. My vehicle experienced engine halts at high speeds, and Peak Kia in Littleton, CO, discovered a leaking valve cover gasket and PCV valve. Despite these issues being relevant to the recall, Kia and the dealership refuse comprehensive testing or repairs under the recall. The dealership initially suggested engine replacement but later claimed only a Knock Sensor Detection System (KSDS) update and lockup test were required. They refuse to conduct oil analysis, leak-down tests, or endoscopic inspections to rule out systemic issues or internal engine damage. The vehicle has been with the dealership for five weeks. Kia's customer service, including a case manager named Courtney, promised to review the case but failed to follow up. The District Parts & Services manager, Jacob, instructed the dealership to close my request without further testing and refuses to open a validation case or respond to emails. Kia Customer Support has promised callbacks for three weeks but has not returned them. The dealership is attempting to charge for an inspection fee and repeat systemic repairs despite these being likely covered under the recall. They have not addressed relevant Technical Service Bulletins (TSBs) ENG222 and FUE053, which provide guidance for diagnosing and repairing oil consumption and leak issues. I believe Kia and the dealership are not complying with the full scope of the SC200 recall, which mandates comprehensive inspections and repairs for any oil leaks. They are using circular logic to avoid performing necessary tests and repairs, potentially putting my safety at risk and leaving me vulnerable to future engine failure. I request NHTSA's intervention to ensure Kia and the dealership comply with the recall requirements, perform all necessary testing and repairs, and address the potential systemic issues with my vehicle's engine.

- Littleton, CO, USA

Got off of hwy traveling at 70 mph came to stoplight. Vehicle stalled. Noticed smoke, then flames. Within 2 minutes the entire engine compartment was engulfed in flames

- Greensboro , NC, USA

Having acceleration problems with the Kia and catalytic converter. I had contacted the Kia dealer but can't be seen till August but I need vehicle to go to work plus have dr appointments and can't drive the car feel like it's gonna die on me how can I get this problem recall done sooner as I need my car

- Independence, OR, USA

The Kia experienced acceleration issues and would randomly turn off while driving. A mechanic inspected and recalibrate the knock sensor. Almost immediately the car began to use excessive amounts of oil, a quart a week average, had a knock and started having acceleration issues. The Kia dealership stated that severe engine scoring had occurred likely caused by the catalytic converter. The problems began and lead to engine failure within several weeks. From March to end of May

- West Plains, MO, USA

My catalytic converter failed just under 4 years after getting the SC176 recall done in July 2020. I believe it's possible there was a step missed in the replacement of my catalytic converter related to the recall, specifically the Catalytic Overheating Protection Engine Control Unit logic that may have caused the converter to fail. I do not detect that on the attached receipt from the repair that was done for the recall. Although there were no safety issues that happened, after reading the recall and what can happen as a result of the catalytic converter failing, I am concerned for my safety if I drive it any longer in that condition. The problem has been diagnosed by my local Kia dealership on Friday 4/19/24 and that is where the car is presently. I have attached the inspection report and the cost to fix it. The vehicle has not been inspected by anyone other the Kia dealership. There was a ticking sound when I accelerated that wasn't there before on 4/3. The service engine light came on Thursday 4/4 when I was getting my routine oil changed. I changed the PCV valve and the light went off until approximately 4/17 and then I called the dealership to schedule bringing it in for the diagnosis which was 4/19. This is the only information I have at this time. Any help you can provide will be greatly appreciated.

- Kissimmee, FL, USA

The exact issue with the catalytic converter you have in the 1.6 engines my neighbor has it too. You should be replacing these not charging 2500 for repairs.

- Orlando, FL, USA

Catalytic converter failure despite recall repair (#19v120). Catalytic converters may become damaged due to overheating. This issue can increase the risk of engine stall or fire. Yes. On March 13, 2024 the vehicle was inspected by a certified Kia mechanic and it was determined that the primary catalytic converter and exhaust manifold have failed. Yes. I don't recall whether or not there was a warning light in 2019 before recall repair however there was a warning light in November 2023 continuing to the present.

- Junction City, CA, USA

The catalytic converter got pluged up from the oil consumption. The car would no longer accelerate. Yes I still have the catalytic converter.yes the safety was I went to excelrate and I almost got rear ended. It just happened out of nowhere.I took it to the Meineke's shop and they said the cat was pluged but wasn't 100% sure so I had it towed to a kia dealer and they said it was 100% the catalytic converter and it wasn't covered so it would be around $3000.Yes it was inspected by the kia dealer.It had a check engine light on but it said it was the 02 sensor. It had a little less power then normal.It seemed ok when I left the house. I drove about 40 miles. I stoped for about 5 minutes to smoke and it seemed ok in the parking lot. It's when I went to excelrate out to the street it had no power.the original cat starts getting pluged over time and causes the heat to back up on the inside of the engine and puts wear on the piston rings. There for causeing it to burn the engine oil. Inturn almost fully pluging the original cat cause the engine to have no power. I have been a professional machnic for over 24 years. so I understand how engines work. Now because of the internal damage of the engine I am putting 2 quarts of oil every 1500 miles. Which is only one week for me. Thank you for reviewing this. I hope that kia will make this right.

- Aurora, CO, USA

Starting in summer of 2021, I began to has acceleration problems with my car and a check engine light came on. It was undrivable so I took it to the closest mechanic I could make it to, Firestone. They found the catalytic converter to be the problem and I paid $1100 to replace it. Later in 2021, the catalytic converter went out again and I had to have the engine coil and spark plugs replaced. I took it back to Firestone to replace it under warranty. During 2022, the check engine light came on again and again it was the catalytic converter. I got it replaced under warranty again. During this replacement, Firestone let me know that my engine was the source of why the catalytic converter keeps going out. The compression was too low and the engine was causing the catalytic converter to overheat. I took it to the dealership to have it diagnosed to see what was wrong in the engine. They claimed to have run diagnostics in the entire engine and only found that the engine coil and spark plugs needed replacement. I had both of those things replaced already the year before. They did not identify any problems with the new catalytic converter or any other part of the engine. The check engine light came on and my catalytic converter has gone out again and caused me to lose acceleration on a one lane each way 60mph road on my way to work. I suddenly slowed way down and cars had to swerve around me. I pulled off onto a farm road to let traffic by and then had to hobble to AutoZone nearby with my hazards on to get my check engine light codes read. It came up that the cat converter was having issues. I looked up to see if my car had any recalls and none were found. I did find that there was a major recall for Kia souls 2012-2018s for some piece of the engine that was causing catalytic converters to overheat. Many individuals who had this recall done to their vehicles also had to have engine coils and spark plugs replaced based on a forum regarding this recall.

- Corvallis, OR, USA

My car lost power going up hill on Interstate 5 and ended up seizing up. I could not bring the car to highway speeds I had to drive home using side roads. A mechanic said the car appears to be consuming oil and degraded the catalytic converter. I had to have my catalytic converter replaced. I had the recall done on my car for the catalytic converter issue identified for 2015 Kia Souls. I attempted to get repair from my dealer, Gweke Kia, under this recall but they refused and said I would be charged for the repair and diagnosis. I asked for an oil consumption study to see if the car qualifies engine repairs or replacement under my warranty but they informed me they would charge me approximately $1200 for an oil consumption study.

- Chico, CA, USA

My car is not part of the catalytic converter Recall and I don't understand why. My catalytic converter is not functioning properly and I am getting code p0420 and this makes no sense why I am not part of the recall. My engine and everything matches up to all these recalls and I am scared my car is going to explode. I already have a sick child and all I need is something to happen while driving these defective vehicles. Please make me understand why I am not included in the upgrade for that catalytic converter. I am tired of these issues. I want to out this poor company on making poor vehicles like everyone else. They are supposed to be safe and I should not be afraid to drive my car thinking something will happen.

- Schaumburg, IL, USA

While driving at 55 miles per hour, the engine suddenly ceased, emitting black smoke, causing components to melt and necessitating the replacement of the short block. Consequently, the catalytic converter is now malfunctioning, likely due to the misfires the engine experienced.

- High Falls , NY, USA

The KIA company is denying me the anti theft software. What can I do?

- Tucson, AZ, USA

The car stalls constantly and has been going on for years. Kia had claimed to have fixed the problem that they had fixed the problem however they never did because the car has been continuing to stop in the middle of the road. This car is very dangerous and it has no recalls on it. The catalytic converter is a problem and even though it has been a problem for Kia souls mine is not listed in the recall. Needless to say that this has put me and my child in immediate Life-threatening danger multiple times.

- Brick , NJ, USA

My catalytic converter went out on my Kia while driving unexpectedly and I have heard of a lot of other Kias in my year have the same issue.

- Aurora, CO, USA

NHTSA recall for reference number 19V120000. Engine and engine cooling exhaust system: Emission control: Catalytic convertor and my Kia Soul 2015 did not have this changed out. Kia is saying that is is not a recall but this issue is a recall because if my car blows up and some one dies I am sueing Kia for this issue/

- Aiea, HI, USA

This would be the third time of car breaking down without any warning. When there is a problem with the car there is never no indication that there are any problems. No warning lights, no nothing car just breaks down.

- Maple Grove, MN, USA