The contact owns a 2004 Lincoln Aviator. While the contact was driving approximately 55 mph smoke circulated through the vents inside of the vehicle; and the vehicle was driven to the side of the road. The contact stated the smoke originated from the engine compartment. The vehicle was towed to an authorized dealer where the technician advised that the front end differential had deteriorated. The vehicle was repaired at the owner's expense. After the service repair the vehicle was test driven and the failure recurred. The technician performed further diagnosis and repaired the vehicle. The failure continued to occur on four separate occasions which was repaired at the owner's expense. The manufacturer was notified of the front end differential failures and they accepted liability for the radio and steering column repairs that failed to function correctly due to the differential failures. In addition, the contact stated that the front tires were replaced in March of 2009; and five months later the tires had worn to the metal in result of the defective front end differential. The tires were replaced. An independent mechanic informed the problem originated from inexpensive Korean parts in the transfer case. The transfer case and U joint were replaced in the vehicle. The contact expressed anyone driving the vehicle life was in danger because of the safety defect. The failure mileage was 80,000. The VIN was unavailable. Also, there was a crack under the rear liftgate. There was recall on the rearlift. However, the consumers VIN was not included. The entire shifting mechanism had to be replaced, the steering wheel would vibrate while making a turn. Updated 12/17/10

- Fairfiled, CA, USA

The back hatch panel cracked was fixed, the steering not right some times its hard to steer. Main problem is cylinder coils going bad alot. Now #8 coil went bad and has been replaced 2times, and its still in the shop they cant find out why it keeps coming up #8 still misfiring.. they think its the head now. I understand Lincoln has had so many problems with this that they have allowed a 10yr. Extended warranty on all the coils. Is this right ? I want Lincoln to do something. I am so mad right now. I will never buy another Lincoln. Help me.

- Wilmington, OH, USA

2004 Lincoln Aviator. Consumer states that the liftgate cracked in the middle of the door. The crack is about as long as an index finger. Upon inspection it was determined that the crack was stress and several panels had been replaced in the past.

- Atlanta, GA, USA