1997 Mazda Millenia
TSBs (Technical Service Bulletins)
Technical Service Bulletins (TSBs) for the 1997 Millenia are official communications between Mazda & their dealerships that describe processes for troubleshooting or fixing certain common problems. All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
-
TSB #0600103
TILT STEERING WHEEL STUCK IN UP POSITION. *TT Read More »
-
TSB #00198
CONDITIONS WITH STEERING WHEEL SLIGHTLY OFF CENTER. *YC Read More »
-
TSB #0600101R1
SUBJECT REGARDING TILT STEERING WHEEL INOPERATIVE. *JG Read More »
-
TSB #0200201
SOME VEHICLES MAY EXHIBIT A CREAK OR SQUEAK NOISE FROM THE REAR SUSPENSION WHEN DRIVING AT LOW SPEEDS, ENTERING DRIVEWAYS, DRIVING OVER SPEED BUMPS IN PARKING LOTS, OR DRIVING ON ROUGH ROADS. Read More »
-
TSB #00-003-18-3480
Mazda North American Operations has approved an additional on-car brake lathe as an option for MNAOauthorized equipment. The Pro-Cut On-Car Brake Lathe has been added to the MNAO authorizedequipment program. Read More »
-
TSB #00-003-18-3480a
Mazda North American Operations has approved an additional on-car brake lathe as an option for MNAO authorized equipment. The Pro-Cut On-Car Brake Lathe has been added to the MNAO authorized equipment program. Read More »
-
TSB #00-004/12
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #01-006-21-3779a
This service bulletin provides testing and charging procedures in order to promote proper battery maintenance, to deliver new vehicles with fully charged batteries, and to reduce unnecessary battery replacement cost. Read More »
-
TSB #01-004-19-3558
On some vehicles, a sulfur smell or 'rotten egg' odor may be noticed coming from the exhaust system. The odor is usually noticed after a cold start, fast idle, extended periods of idling and full throttle acceleration. Read More »
-
TSB #970716004/97
INFORMATION AND INSTRUCTIONS ON IMPROVING THE PRODUCTIVITY OF HIGH-TENSION LEADS. *YC Read More »
-
TSB #0101602
SUBJECT REGARDING CAMSHAFT INSTALLATION INFORMATION. *TT Read More »
-
TSB #01599
INFORMATION REGARDING PISTON STANDARDIZATION FOR VEHICLES WITHIN CERTAIN VIN RANGES. *TT Read More »
-
TSB #00598
EXPERIENCEING A METALLIC TAPPING NOISE HEARD FROM THE RIGHT ( REAR ) CYLINDER HEAD EXHAUST CAM AREA. *YC Read More »
-
TSB #00298
SUBJECT REGARDING MALFUNCTION INDICATOR LIGHT (MIL) ILLUMINATION WITH DTC ( S ) P0300 THROUGH P0306. *YC Read More »
-
TSB #97102300797
VEHICLE EXPERIENCING A OIL LEAK AT VALVE COVER. *YC Read More »
-
TSB #970716006/97
DESCRIPTIONS OF TYPICAL ENGINE NOISES. *YC Read More »
-
TSB #001/97
TAPPING NOISE WHEN ENGINE IS COLD. *TW Read More »
-
TSB #01600
SUBJECT REGARDING INSPECTION PROCEDURE - WATER PUMP LEAK. *TT Read More »
-
TSB #01-016-18-3522
On some vehicles, a sulfur smell or 'rotten egg' odor may be noticed coming from the exhaust system. The odor is usually noticed after a cold start, fast idle, extended periods of idling and full throttle acceleration. Read More »
-
TSB #0100316
SULFUR SMELL FROM EXHAUST SYSTEM. Read More »
-
TSB #00204
EVAPORATIVE EMMISSIONS AND RECIVER ADAPTERS. *EH Read More »
-
TSB #0100602
SUBJECT REGARDING FUEL PUMP ASSEMBLY AND RELATED COMPONENT REPLACEMENT GUIDELINES. *SLC Read More »
-
TSB #0101601
SUBJECT REGARDING DIFFICULTY INSTALLING FUEL PUMP INTO NEW FUEL TANK. *TT Read More »
-
TSB #0100701R
EXPERIENCING MALFUNCTION INDICATOR LAMP ILLUMINATION OCCURING WITH DIAGNOSTIC TROUBLE CODE P1455 STORED IN MEMORY. Read More »
-
TSB #01698
SOME VEHICLES MAY EXHIBIT AN INTERMITTENT FUEL GAUGE INACCURACY WITH OR WITHOUT DTC P1455. *YC Read More »
-
TSB #02298
CUSTOMER MAY COMPLAIN OF INTERMITTENT FUEL GAUGE INACCURACY WITH OR WITHOUT DTC P1455. *YC Read More »
-
TSB #00198
COMPLAINTS OF TACH NEEDLE STUCK ON WRONG SIDE OF STOPPER PIN. *YC Read More »
-
TSB #00198
SUBJECT PERTAINING TO TACH NEEDLE WHICH IS STUCK ON WRONG SIDE OF STOPPER PIN. *YC Read More »
-
TSB #012/97T
TACH NEEDLE STUCK ON WRONG SIDE OF STOPPER PIN. *TW Read More »
-
TSB #MT-002-22
Radio Unlocking Codes. Read More »
-
TSB #01-005-21-3778
The Mazda DCA-8000PM is required for all warranty battery testing. If the Mazda DCA-8000PM is not used, incorrect battery testing may result in unnecessary battery replacement. Read More »
-
TSB #01-006-21-3779
This service bulletin provides testing and charging procedures in order to promote proper battery maintenance, to deliver new vehicles with fully charged batteries, and to reduce unnecessary battery replacement cost. Read More »
-
TSB #09-002-21-3770
In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer Read More »
-
TSB #09-003-20-3671
In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer. NOTE: Tampering with a motor vehicle odometer is strictly prohibited by Federal, and State laws. Read More »
-
TSB #01-001-19-3551
This service bulletin provides testing and charging procedures in order to promote proper battery maintenance, to deliver new vehicles with fully charged batteries, and to reduce unnecessary battery replacement cost. Read More »
-
TSB #01-002-19-3552
The Mazda GR8-1291 is required for all warranty battery testing. If the Mazda GR8-1291 is not used, incorrect battery testing may result in unnecessary battery replacement. Read More »
-
TSB #0100504
MALFUNCTION INDICATOR LAMP ILLUMINATION WITH DIAGNOSTIC TROUBLE CODE (DTC) P0325. *TT Read More »
-
TSB #0101003
MALFUNCTION INDICATOR LAMP ILLUMINATION WITH DIAGNOSTIC TROUBLE CODE P0325 STORED. *TT Read More »
-
TSB #01-006-21-3779a
This service bulletin provides testing and charging procedures in order to promote proper battery maintenance, to deliver new vehicles with fully charged batteries, and to reduce unnecessary battery replacement cost. Read More »
-
TSB #01-008-18-3451
This service bulletin provides testing and charging procedures in order to promote proper battery maintenance, to deliver new vehicles with fully charged batteries, and to reduce unnecessary battery replacement cost. Read More »
-
TSB #01-009-18-3452
The Mazda GR8-1291 is required for all warranty battery testing. If the Mazda GR8-1291 is not used, incorrect battery testing may result in unnecessary battery replacement. Read More »
-
TSB #0100416
Battery Maintenance Read More »
-
TSB #0100516
Battery test procedure requirements using the GR81291 Read More »
-
TSB #0102504
BATTERY TEST PROCEDURE REQUIREMENTS. *TT Read More »
-
TSB #001/97G
MAINTENANCE FREE BATTERY - DIAGNOSTIC AND CHARGING PROCEDURE. *TW Read More »
-
TSB #003/97G
WIPER MOTOR INOPERATIVE - CIRCUIT BREAKER ACTIVATION. *TW Read More »
-
TSB #001/97AD
KEY REPLACEMENT PROGRAM. *TW Read More »
-
TSB #09-009-19-3566
In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer. NOTE: Tampering with a motor vehicle odometer is strictly prohibited by Federal, and State laws. Read More »
-
TSB #09-035-17-3080
In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer. NOTE: Tampering with a motor vehicle odometer is strictly prohibited by Federal, and State laws. Read More »
-
TSB #0900716
Speedometer replacement procedure Read More »
-
TSB #00998
SUBJECT REGARDING FUEL / TRUNK OPENER SWITCH MAY BECOME LOOSE. *YC Read More »
-
TSB #009/97S
SUN ROOF LOWER PANEL COVER LOOSE. *TW Read More »
-
TSB #0900403
REAR WINDOW DEFROSTER GRID LINE REPAIR PROCEDURE. *TT Read More »
-
TSB #002/97T
BLOWER MOTOR FAN SPEED INCORRECT - BLOWER MOTOR INOPERATIVE. *TW Read More »
-
TSB #0800306
NON GENUINE ACCESSORIES AFFECT AIR BAG OPERATION. *KB Read More »
-
TSB #007/97T
PARTS REPLACEMENT AFTER AIRBAG DEPLOYMENT. *TW Read More »
-
TSB #00598
INFORMATION REGARDING SEAT BELT EXTENDERS. *YC Read More »
-
TSB #09-014-18-3443a
When encountering a vehicle with paint damage, refer to the "Mazda Pocket Paint Guide" to determine cause, prevention, remedy, and warranty coverage (if applicable). Read More »
-
TSB #09-014-18-3443
When encountering a vehicle with paint damage, refer to the "Mazda Pocket Paint Guide" to determine cause, prevention, remedy, and warranty coverage (if applicable). Read More »
-
TSB #01299
SUBJECT REGARDING PAINT DAMAGE - IRON PARTICLES / INDUSTRIAL FALLOUT / ACID RAIN. *TT Read More »
-
TSB #00498
SUBJECT ON REAR CONSOLE LID SURFACE PEELING. *YC Read More »
-
TSB #97102302097
PRE-PAINTING PREPARATIONS FOR FRONT AND REAR BUMPERS. *YC Read More »
-
TSB #09-002-21-3770
In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer Read More »
-
TSB #09-034-18-3430a
In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer. NOTE: Tampering with a motor vehicle odometer is strictly prohibited by Federal, and State laws. Read More »
-
TSB #09-034-18-3430
In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer. NOTE: Tampering with a motor vehicle odometer is strictly prohibited by Federal, and State laws. Read More »
-
TSB #005/97S
RATTLE NOISE FROM REAR SEAT BACK. *TW Read More »
-
TSB #0102702
MALFUNCTION INDICATOR LAMP ILLUMINATION WITH DIAGNOSTIC TROUBLE CODE P0300 TO P0306. *TT Read More »
-
TSB #09-025-21-3824
This service bulletin provides information regarding the proper use of the driver??A?A?s floor mat to avoid any potential interference with the foot pedals. Read More »
-
TSB #SA-041-21
Accessory instructions can be found on OneMazda under Dealer Resources - Parts & Accessories. The links provided below can be used for quick access: For 2016 models and newer: NOTE: Instructions are found under the "Attachments" section ... Read More »
-
TSB #07-001-21-3775
A musty/mildew type odor may come from the vents when the air conditioning (A/C) system is operating. It is most noticeable when the A/C is first turned ON. Read More »
-
TSB #09-002-21-3770
In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer Read More »
-
TSB #09-003-20-3671
In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer. NOTE: Tampering with a motor vehicle odometer is strictly prohibited by Federal, and State laws. Read More »
-
TSB #00-001-18-3446a
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Read More »
-
TSB #00-003-18-3480a
Mazda North American Operations has approved an additional on-car brake lathe as an option for MNAO authorized equipment. The Pro-Cut On-Car Brake Lathe has been added to the MNAO authorized equipment program. Read More »
-
TSB #09-014-18-3443a
When encountering a vehicle with paint damage, refer to the "Mazda Pocket Paint Guide" to determine cause, prevention, remedy, and warranty coverage (if applicable). Read More »
-
TSB #09-034-18-3430a
In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer. NOTE: Tampering with a motor vehicle odometer is strictly prohibited by Federal, and State laws. Read More »
-
TSB #00-001-18-3446
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Read More »
-
TSB #0901216
Paint damage Mazda pocket paint guide Read More »
-
TSB #00-002-14-2936
MAZDA NORTH AMERICAN OPERATIONS RECEIVED MANY REQUESTS FROM OUR DEALERS ASKING US TO APPROVE ADDITIONAL ON-CAR BRAKE LATHES AS AN OPTION FOR MNAO AUTHORIZED EQUIPMENT. Read More »
-
TSB #SB-09-005-13
MAZDA: ON SOME VEHICLES, TO AVOID POTENTIAL INTERFERENCE OF FOOT PLACED ON PEDALS, INFORMATION IS PROVIDED REGARDING PROPER USE, AND PLACEMENT, OF DRIVER'S FLOOR MAT. VARIOUS MODELS AND MODEL YEARS. Read More »
-
TSB #09-005-13-2781
THIS SERVICE BULLETIN PROVIDES INFORMATION REGARDING THE PROPER USE OF THE DRIVER?S FLOOR MAT TO AVOID ANY POTEN-TIAL INTERFERENCE WITH THE FOOT PEDALS. Read More »
-
TSB #00-004/12
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #0900416
PROPER USAGE OF DRIVER'S FLOOR MAT. Read More »
-
TSB #0902604
SPEEDOMETER REPLACEMENT PROCEDURE. *TT Read More »
-
TSB #00700
CIGARETTE LIGHTER DOES NOT WORK OR STAY IN POSITION. *TT Read More »
-
TSB #00-001-18-3446a
Mazda has developed factory recommended scheduled maintenance services that support all major vehicle systems. Read More »
-
TSB #09-035-17-3080
In accordance with Federal regulations, follow the procedure listed below when replacing a speedometer. NOTE: Tampering with a motor vehicle odometer is strictly prohibited by Federal, and State laws. Read More »
-
TSB #0000216
Mazda guidelines for factory scheduled maintenance Read More »
-
TSB #0100416
Battery Maintenance Read More »
-
TSB #0100516
Battery test procedure requirements using the GR81291 Read More »
-
TSB #00-001-13-2748A
MAZDA HAS DEVELOPED FACTORY RECOMMENDED SCHEDULED MAINTENANCE SERVICES THAT SUPPORT ALL MAJOR VEHICLE SYSTEMS. Read More »
-
TSB #00-001-13-2748
MAZDA HAS DEVELOPED FACTORY RECOMMENDED SCHEDULED MAINTENANCE SERVICES THAT SUPPORT ALL MAJOR VEHICLE SYSTEMS. Read More »
-
TSB #00-004/12
SUMMARY TO BE PROVIDED ON A FUTURE DATE. Read More »
-
TSB #00-004-12-2741
MAZDA HAS DEVELOPED FACTORY RECOMMENDED SCHEDULED MAINTENANCE SERVICES THAT SUPPORT ALL MAJOR VEHICLE SYSTEMS. Read More »
-
TSB #09-002-19-3554
This service bulletin provides information regarding the proper use of the driver's floor mat to avoid anypotential interference with the foot pedals. Read More »
-
TSB #09-019-18-3450
This service bulletin provides information regarding the proper use of the driver's floor mat to avoid any potential interference with the foot pedals. Read More »
-
TSB #0100316
SULFUR SMELL FROM EXHAUST SYSTEM. Read More »
-
TSB #09-034-14-2956
IN ACCORDANCE WITH FEDERAL REGULATIONS, FOLLOW THE PROCEDURE LISTED BELOW WHEN REPLACING A SPEEDOMETER.NOTE:?MAZDA VEHICLES ARE MANUFACTURED WITH TAMPER-PROOF SPEEDOMETERS. Read More »
-
TSB #09-027-14-2935
THIS SERVICE BULLETIN PROVIDES INFORMATION REGARDING THE PROPER USE OF THE DRIVER?S FLOOR MAT TO AVOID ANY POTENTIAL INTERFERENCE WITH THE FOOT PEDALS. Read More »
-
TSB #SB-09-005-13
MAZDA: ON SOME VEHICLES, TO AVOID POTENTIAL INTERFERENCE OF FOOT PLACED ON PEDALS, INFORMATION IS PROVIDED REGARDING PROPER USE, AND PLACEMENT, OF DRIVER'S FLOOR MAT. VARIOUS MODELS AND MODEL YEARS. Read More »
-
TSB #011/97
A/C ODOR AND BLOWER NOISE DUE TO FOREIGN SUBSTANCE. *TW Read More »
-
TSB #008/97
USE OF A/C TRACER DYE. *TW Read More »
-
TSB #00307
AVAILABILITY OF NON-REQUIRED TOOLS. *KB Read More »
-
TSB #
INFORMATION ON FUEL INJECTOR(S) REPLACEMENT GUIDELINES. *SLC Read More »
-
TSB #0100301
SOME VEHICLES MAY EXHIBIT MALFUNCTION INDICATOR LAMP ILLUMINATION WITH DIAGNOSTIC TROUBLE CODE (DTC) P0420 / 0421 OR P0430 / 0431 STORED IN MEMORY WITH NO DRIVEABILITY CONCERNS PRESENT. Read More »
-
TSB #00298
SUBJECT REGARDING MALFUNCTION INDICATOR LIGHT (MIL) ILLUMINATION WITH DTC (S) P0300 THROUGH P0306. *YC Read More »