10.0
really awful- Crashes / Fires:
- 1 / 2
- Injuries / Deaths:
- 4 / 4
- Average Mileage:
- 195,510 miles
About These NHTSA Complaints:
The NHTSA is the US gov't agency tasked with vehicle safety. Complaints can be spread across multiple & redundant categories, & are not organized by problem. See the Back button — blue bar at the very top of the page — to explore more.
Filled up gas tank and had fuel odor inside car and fuel leaking outside the car until fuel level was around 3/4 of a tank. I believe that mine falls under all the other problems listed for fuel leaks for other W211 Mercedes. The extended warranty for this was only allowed for original owners and not for anyone that purchased used.
- Wichita Falls, TX, USA
Battery light came on so it was charged then reconnected, everything good, turn key to on position everything good, turn key to start and bang! loud bang and white smoke everywhere, engine continued to smoke for several minutes after explosion, hole in front of engine
- Temecula Ca, CA, USA
Squeaky front suspension.
- Suwanee, GA, USA
Their a strong smell of gas smell inside the car
- Coppell, TX, USA
When I fill the tank wits gas(not topped off) when I drive it hom park it in garage it smell of a strong gas order. Afresh drivibg a little ( to use gas) it goes away, happens each time I fill.
- Tucson, AZ, USA
The contact owns a 2005 Mercedes-Benz E320. While the vehicle was stationary, diesel fuel leaked onto the ground. The contact noticed an odor of fuel inside the vehicle, which caused headaches for the occupants. Mercedes-Benz in daytona beach, Florida was made aware of the failure. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was 129,000.
- Ormand Beach, FL, USA
In 2015 we started to notice the smell of gasoline following filling the tank with gas. The smell of gasoline is so strong that we had to open our garage doors to vent the fumes. No gasoline was spilled during refueling. There is no visible gas leak on the garage floor. The vehicle is a 2005 Mercedes-Benz E320 with only 44,000 miles. After researching this problem we discovered numerous other owners of this model Mercedes have experienced the same problem. Mercedes has no recall for this fuel fume defect and any repair is not within the original warranty period. NHTSA action #EA13003 summary test & analysis by Mercedes-Benz shows no risks of fire or passenger safety. This is bs as fuel fumes within an enclosed area, such as a garage where a natural gas hot water tank exists, could cause a fire. NHTSA needs to require Mercedes-Benz to recall the vehicles affected by this defect.
- Henderson, NV, USA
8/4/16 vehicle had strong smell of gas inside after fillup. Went away after half full. Noticed recall in online doc's and took to Mercedes of san diego where tank mod, cable harness, bracket, seal ringx2, insulation under seat were replaced no charge under warranty. 6/20/17 vehicle quit when approaching residence. Then wouldn't start but cranked. Same symptoms next day. Towed to mb san diego diagnosed fuel pump components failed $1,000 w/no offer to cover under recall. I further reviewed same internet doc's which show fuel pumps, filters, fuel level senders are covered under mb 15 yr. Unltd miles warranty. Will call service writer in morning to advise they should cover repairs, tow plus rental car while I was researchng.
- San Diego, CA, USA
Purchase this car in February 2017 smells like gas is seeping out from somewhere. Stopped in the middle of highway. Now having problems with starting car and airbag suspension light is on.
- Dallas, TX, USA
Fuel sending unit leaking fuel - strong odor of gasoline. I see that many other W211 style Mercedes Benz owners are complaining about the same thing. I took it into my mechanic and he says that the sending unit is leaking and this has been an going problem with these vehicle. Mercedes needs to recall this for safety reasons and do the right thing. Please add my complaint to the pile of complaints already received by your Agency.
- San Jose, CA, USA
When filling up the gas tank I sell gas and odor fills up the garage. The smell usually goes aways when the car has been driven and gas tank is not full. This week I filled the gas the tank up and gas was leaking and could not park it in the garage.
- Bowie, MD, USA
The car has fuel (gasoline) vapors inside and outside of the car. The fuel sending unit or the fuel pump in the saddle gas tank under the back seats leaks gasoline and the smell makes me sick. I am afraid the car will explode if the vapor is present at the combustible ratio of gasoline to air.
- Old Lyme, CT, USA
Car has a very strong gas smell inside the cabin. Upon removal of back seat it appears wet with gas. This problem started on February 5, 2016 on my E320 (2005) Benz and the odor started to give me headaches. I took car for shampoo and then consulted with mechanic who removed back seat and found wet area with gas.
- Brooklyn, NY, USA
I have a 2005 E320 Mercedes Benz. Every time we fill the tank we get a strong gas smell inside the vehicle. After we drive the vehicle for a while with the windows open the smell dissipates. The smell is coming from under the rear seats. I suspect the seal on the gas tank has failed. This is a design flaw that should be taken care of by the manufacture. It is not a normal wear and tear item. My concern is fuel fumes can impair ones driving ability and leaking fuel can create a safety hazard. With the number of complaints that I have come across I feel that there should be a re-call to correct.
- Carson City, NV, USA
Hello, I was concern about my car every time I fill up my gas to full tank every time I park my car inside the garage it smell gas and smell badly..im worried it might cause fire because my water heater is inside the garage..so pls. Let me know if any recall for my car..thanks
- Midland, TX, USA
Sensed strong gas odor at fill up. Investigate online and found that this car has this known issue but it is not a recall.? had mb mechanic look and found leaking gas under rear seat near fuel pump.
- Toms River, NJ, USA
The contact owns a 2005 Mercedes Benz E320. The contact stated that after the vehicle was refueled and parked, a fuel odor emitted from the vehicle. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was 82,000.
- Laconia, NH, USA
Replaced battery (30 days ago) and now warning light comes on saying I need to replace the battery every 10 miles and will not go off. Brake lights (ABS and esp) lights comne on and nothing is wrong when it is being repairs. Filled up my car yesterday and strong gas fumes in the car and in my garage. Made me nauseated. Read this was recall for that year and model.
- Morrow, GA, USA
Re complaint number 10778442 since the last report the situation has gotten much worse. Initially the gasoline fumes would occur while the tank was more than 1/2 full. Now the fumes are very very strong when the tank is full but remain strong even as the fuel indicator nears the empty mark. This this the only vehicle I own and my family and myself cannot remain in the car for more than a few moments. The fume are overpowering and this is a major health concern wise as well as a chance of fire.
- Ellenwood, GA, USA
- Wahiawa, HI, USA