Vehicle has stalled without warning at least 12 times over several years. This happens at any speed and has always happened in hot weather. The last several times were on a busy, curvy highway with no room to pull off road and almost led to an accident. The Villager's fuel pump becomes very noisy when trying to restart engine. After about 15 to 20 minutes it will restart. Please inform me of what the problem could be. It has never happened in cold weather. I am afraid an accident could happen. There is no warning at all.

- Morenci, AZ, USA

Vehicle has stalled 7-8 times at any speed, dealer cannot remedy the problem.*akwhile starting the vehicle, consumer smells gas, the fuel pump failed, consumer had it replaced, and is seeking reimbursement.

- Worcester, MA, USA

While driving vehicle started choking and then it cut off. Contacted dealer, cannot find cause.

- Queens, NY, USA

While driving oil light came on, and then al loud noise came from engine, causing engine to drag. Consumer had oil change twice, and fixed problem temporarily.

- Belfair, WA, USA

Check engine light illuminated, dealer stated egr valve was dirty and needed cleaned, however light illuminated again and with an unusual noise, consumer learned that engine was to be replaced and monies should not have been paid for egr valve cleaning and belt tensioner replacement, consumer is requesting reimbursement for those repairs, after engine repair consumer noticed od off light flashing, check engine light illuminated, whining noise from engine, and power steering made noise as steering wheel was turned, all of this happened before consumer put vehicle in drive and feels these additional failures are due to the installment of the new engine.

- Staten Island, NY, USA

Consumer experiencing motor problems.

- Perth Amboy, NJ, USA

A day after taking vehicle for manufacturer's recall awf40C-F 00 S 59 repairs filler hose had to be changed because it could cause a fire. When consumer was driving about 40 mph engine started jumping. Then, caught on fire just like it said in recall. The vehicle had exhaust leak at the manifold. The consumer says he does not know the cause of the fire.

- Greenbelt, SC, USA

Engine died $5000 repair secret service warranty to replace not honored by dealer.

- Upper Marlboro, MD, USA

Engine noise, kind of loud. Also, engine light came on. Contacted dealer, and the dealer said they should replace tensioner. After the defective tensioner was replaced, the dealer indicated that the engine needed to be replaced as well. However check the engine light came on and stayed on after the engine was replaced. The air bag light was flashing continuously.

- Staton Island, NY, USA

Head control module wire harness in back of the dash panel burned up. Wires were completely melted. Several electrical related problems: Battery failure, open circuit in main engine harness to egr solenoid, overhead light failed, power door locks were operating by themselves, power locks would not lock with the switch, rear windshiled wiper switch failed and rear wipers would not stop even after fuse was removed, sliding door would not open with remote or switch. Check engine light illuminated. Power steering pump noisy and was replaced. Air conditioner motor failed. When locking vehicle with key, horn would operate, keyless entry had just been installed.

- North Providence, RI, USA

Engine oil light intermittently flashing when engine is cold (after starting). Oil light goes off after engine is warmed up. Intermittent excessive "engine noise" when engine is cold (after starting). Mercury dealership indicates "sludge" in engine, recommends replacement of engine. Last oil change at 29000 miles and previously at 24600 miles. Dealership is indicating engine damage is due to inadequate maintenance (I.e. oil change frequency). Ford issued a letter January 1997 (recall 96M89) which describes "piston slap" noise problem and offered to extend engine warranty to 7 years or 100,000 miles. Dealership is contending that the engine damage is not due to this recall but owner maintenance. I would like to know if you can provide additional detail on the 96M89 recall notice and whether or not the engine defect covered by the recall could precipitate the engine damage I am experiencing at 40,700 miles. While I understand this issue is not safety related any assistance you could provide would be appreciated.

- Farmington Hills, MI, USA

Engine oil light intermittently flashing when engine is cold (after starting). Oil light goes off after engine is warmed up. Intermittent excessive "engine noise" when engine is cold (after starting). Mercury dealership indicates "sludge" in engine, recommends replacement of engine. Last oil change at 29000 miles and previously at 24600 miles. Dealership is indicating engine damage is due to inadequate maintenance (I.e. oil change frequency). Ford issued a letter January 1997 (recall 96M89) which describes "piston slap" noise problem and offered to extend engine warranty to 7 years or 100,000 miles. Dealership is contending that the engine damage is not due to this recall but owner maintenance. I would like to know if you can provide additional detail on the 96M89 recall notice and whether or not the engine defect covered by the recall could precipitate the engine damage I am experiencing at 40,700 miles. While I understand this issue is not safety related any assistance you could provide would be appreciated.

- Farmington Hills, MI, USA

Engine oil light intermittently flashing when engine is cold (after starting). Oil light goes off after engine is warmed up. Intermittent excessive "engine noise" when engine is cold (after starting). Mercury dealership indicates "sludge" in engine, recommends replacement of engine. Last oil change at 29000 miles and previously at 24600 miles. Dealership is indicating engine damage is due to inadequate maintenance (I.e. oil change frequency). Ford issued a letter January 1997 (recall 96M89) which describes "piston slap" noise problem and offered to extend engine warranty to 7 years or 100,000 miles. Dealership is contending that the engine damage is not due to this recall but owner maintenance. I would like to know if you can provide additional detail on the 96M89 recall notice and whether or not the engine defect covered by the recall could precipitate the engine damage I am experiencing at 40,700 miles. While I understand this issue is not safety related any assistance you could provide would be appreciated.

- Farmington Hills, MI, USA

Engine oil light intermittently flashing when engine is cold (after starting). Oil light goes off after engine is warmed up. Intermittent excessive "engine noise" when engine is cold (after starting). Mercury dealership indicates "sludge" in engine, recommends replacement of engine. Last oil change at 29000 miles and previously at 24600 miles. Dealership is indicating engine damage is due to inadequate maintenance (I.e. oil change frequency). Ford issued a letter January 1997 (recall 96M89) which describes "piston slap" noise problem and offered to extend engine warranty to 7 years or 100,000 miles. Dealership is contending that the engine damage is not due to this recall but owner maintenance. I would like to know if you can provide additional detail on the 96M89 recall notice and whether or not the engine defect covered by the recall could precipitate the engine damage I am experiencing at 40,700 miles. While I understand this issue is not safety related any assistance you could provide would be appreciated.

- Farmington Hills, MI, USA

No summary listed for above vehicle.

- Cedar Park, TX, USA

When buying van I noticed a loud clacking noise in engine on cold starts. I said I didn't want car. They said if they put a new engine in car (23,000mi)would I buy it. I said yes. They put a rebuilt engine in van instead and didn't tell me. Now has 31,0000 miles on it and is clacking again plus shakes car violently first 6 to 8 seconds when starting cold. (intermittently) mechanic said it has bad piston problems. Ford Motor Co. Refuses to correct problem. Says it's out of warrenty. Why should I have to pay to replace the second bad engine in that car. They replaced a bad engine with a bad engine. I suggested trading car in for another one and they reluctantly offered me $4,000 to $5,000 max as trade in because the car had a bad engine. I was willing to purchase a new 1999 Villager($22,000+). I'm being screwed badly by a company that refuses to acknowledge it has an engine program problem. Help me please. Dave mc manus.

- Concord, NC, USA

I was getting on the expressway over in the passing lane the van made a noise I turn down the radio to listen I lost pressure the van shut down. I had oil, water I just dont under stand what happen I was told that I need an engine never had a warning sign and I always keep my oil change and other item acorrding manufacuturer.

- Riverdale, GA, USA

Driving down the road at approximately 15mph engine stalls. Also when opening passenger's side door something triggers inside the lock mechanism, which causes the door to automatically lock.

- Reno, NV, USA

While making a turn through an intersection the steering and brakes failed, the driver coasted to the side of the road and tried to turn the key, the vehicle did not start, then the driver turn the vehicle off and restarted the vehicle and it started.

- Raleigh, NC, USA

While driving at highway speed and for a long period of time, the vehicle stalls unexpectedly almost resulting an accident. Won't restart for about a half an hour. Been to dealer numerous times. Dealer cannot determine problem. Cause unknown.

- Louisville, KY, USA