10.0

really awful
Crashes / Fires:
0 / 1
Injuries / Deaths:
0 / 0
Average Mileage:
38,917 miles

About These NHTSA Complaints:

The NHTSA is the US gov't agency tasked with vehicle safety. Complaints can be spread across multiple & redundant categories, & are not organized by problem. See the Back button — blue bar at the very top of the page — to explore more.

Get notified about new defects, investigations, recalls & lawsuits for the 2004 Mini Cooper:

Unsubscribe any time. We don't sell/share your email.

problem #8

Nov 042011

Cooper 4-cyl

  • 46,995 miles
The contact owns a 2004 MINICooper. The contact stated that while traveling 35 mph, the power steering completely failed and the steering wheel seized. The vehicle had to be towed to the dealer for assistance. The dealer replaced the entire power steering system because the electronic power assist pump could not be replaced by itself. The failure mileage was 46,995 and the current mileage was 48,000. Updated 03/14/12 also, the auxiliary cooling fan was replaced. Updated 04/18/12

- San Fransico, CA, USA

Add Complaint
problem #7

Nov 252011

Cooper 4-cyl

  • miles
While driving in a 35mph zone, smoke started coming out from under the hood (bonnet). Driver noticed odd steering response shortly before smoke appeared. Repair shop noted power steering pump failure causing wiring loom fire. Research has found numerous power steering pump failures on MINICoopers. When power steering fails, driving is next to impossible given size of steering wheel and power assist design.

- Winston, OR, USA

Add Complaint
problem #6

Aug 272011

Cooper 4-cyl

  • 89,000 miles
I was just driving home from work and the power steering just went out, I did safely make it home and got the car in the garage. It has been parked since it seems the power steering comes and goes. I don't know what the problem may be for sure, but I have already had the fan assembly replaced due to it would not cut off, and killed my battery, so of course I had to replace the battery. I am taking the car in for a estimate for the steering, but it seems this is a common problem and it needs to be recalled. It cause someone to get hurt or even killed.

- Sevierville, TN, USA

Add Complaint
problem #5

Jun 012011

Cooper 4-cyl

  • miles
2004 MINICooper. Consumer states problem with power steering the consumer has spent over $4800 in repairs over the last two years.

- Mineola, NY, USA

Add Complaint
problem #4

Apr 132010

(reported on)

Cooper

  • miles
2004 MINICooper. Consumer states while driving power steering malfunctioned.

- University Place, WA, USA

Add Complaint
problem #3

Nov 252007

Cooper 4-cyl

  • Manual transmission
  • 33,542 miles
Complete and instantaneous power steering failure. There is plenty of fluid in the reservoir and there are no blown fuses.

- Los Angeles, CA, USA

Add Complaint
problem #2

Aug 242007

Cooper

  • 58,000 miles
1) no significant event leading up to failure 2) power steering pump failure, no steering ability in vehicle 3) no correction known for sudden loss of steering. Parts to be repaired believed to be steering pump and potential steering rack.

- San Jose, CA, USA

Add Complaint
problem #1

Nov 212006

Cooper

  • 83,800 miles
The steering failed on my 2004 MINICooper S with 84K mile. The power steering fan failed causing the power steering pump to burn out. This problem occurred without warning. The vehicle was nto drivable as a result of the failure fortunately the failure occured after the vehicle reached it destination and was parked.

- Olympia, WA, USA

Add Complaint