The contact owns a 2004 Nissan Titan. The contact stated that on two separate occasions, the cv axle located on the front differential detached from the vehicle while driving at various speeds, without warning. The contact had yet to take the vehicle to be serviced or diagnosed. The manufacturer was notified of the failure and informed him that there was no recall on the vehicle. The contact was also informed that the vehicle was out of warranty and no further assistance was offered. The vehicle was not repaired. The failure mileage was approximately 135,000.

- Tustin, CA, USA

Shackle on right side peeled off the frame stud and drove the spring and shackle assembly through the truck bed

- Orting, WA, USA

This will be the 3rd rear differential on this truck. The first blew on warranty at approx 10K miles. Now with 56K miles the 2nd dana rear axle has blown. I don't off road and tow only a motorcycle trailer. This is obscene, time consuming and very costly ($3,630) to fix and days waiting away from home. This isn't right.

- Grants Pass, OR, USA

This is the second time in over several months that my driver side drive axle for my 4X4 has pulled its self out. It was fixed once on my dime and is now going to be fixed on my dime again it is a dangerous failure that could cause my suspension to lock up an rip my wheel off then leading to a serious accident. It needs to be addressed and the NHTSA has done nothing to pursue this. Another problem that Nissan will not cover is the rear axle seals that blow out due to a faulty design which may also lead to a serious accident, they will not address any of these issues under a recall an there are thousands of people that are suffering from these issues from 04-010 for the axle seals and model years 04-08 for the axle shaft pulling out from the 4X4 causing serious damage to internal and external parts. This needs to be addressed an the NHTSA is doing nothing about it.

- Annapolis , MD, USA

Fourth right rear axle seal. Second in two weeks.

- Daphne, AL, USA

Catastrophic failure of the leaf spring on driver side rear of the vehicle.

- Wichita, KS, USA

The contact owns a 2004 Nissan Titan. The contact stated that while driving approximately 5 mph, the vehicle shook violently without warning. The vehicle was taken to a dealer where it was diagnosed that the front and rear differential and axles needed to be replaced. The manufacturer was made aware of the failure. The vehicle was not repaired. The approximate failure mileage and current mileage was 138,000...updated 03/18/13 the consumer stated also the rear end was locking up. Updated 04/26/2013

- Exeter, RI, USA

While replacing lifetime warrantied suspension which was not honored by Nissan or tenneco, I found the rear pinion seal to be leaking severely, and rear axle seal leaking in wheel assembly. Possible source of "ticking" noise from differential, which until then I thought were exhaust heat shields. This condition could cause catastrophic drivetrain failure while vehicle is in motion. The fluid leaking from axle seal can reduce effectiveness of braking components. Other owners have described inadequate engineering & possible use of substandard differential materials & components along with axle vent assemblies which could create internal pressure conditions that could cause seals to fail.

- Flint, MI, USA

The contact owns a 2004 Nissan Titan. The contact stated that while the vehicle was being inspected at the dealer for an unrelated issue, the dealer noticed that both front lower control arms were damaged. The dealer stated to the contact that the vehicle was unsafe to drive due to the damage of the front lower control arms and the possibility of a crash occurring. The contact took the vehicle to a local mechanic to have the front lower control arms repaired. The contact referenced NHTSA campaign I.D. number: 10E019000 (suspension:front:control arm:lower arm) but was advised by the manufacturer that the vehicle was not included in the recall. The failure mileage was 60,000.

- Tuftonboro , NH, USA

Failure of front control arms, according to Nissan website (many other vehicles were recalled for same, not mine) this could result in collision. Mechanic stated the wheel would come off with failure. Nissan dealership discovered the weld was failing and told me they had to be replaced, but that while 1800+ vehicles were shown to be affected by this issue, my VIN number was not on list. Nissan needs to expand their recall.

- Tuftonboro, NH, USA

The contact owns a 2004 Nissan Titan. The contact was driving 35 mph and noticed an abnormal noise from the rear of the vehicle. The contact inspected the failure and discovered that the rear differential seals and the gear box were leaking at the brake cylinder. The vehicle was taken to the dealer who advised that the entire real differential needed to be replaced. The manufacturer was notified of the failure who advised that they would return his call at a later date. The contact attempted to speak with the manufacturer for two weeks but they would not return his call. The VIN was unavailable. The failure mileage was 53,000.

- Saint Paris, OH, USA

The rear axle seals are leaking and has caused my rear brakes to slip due to the differential oil getting on my brake pads and rotors. This is my second encounter of this problem and Nissan still refuses to do anything about it.

- Denton, TX, USA

The contact owns a 2004 Nissan Titan. The contact stated the rear axle seal leaked and began spraying differential fluid on the brakes while driving 70 mph. When the failure occurred the braking distance increased on the vehicle. The contact took the vehicle to a dealer who stated the rear axle seal leak was very common. The dealer stated the entire rear axle needed to be replaced in order to remedy the failure. The contact did not replace the rear axle. The failure mileage was 75,000.

- Greensboro, NC, USA

The rear universal joint has failed. I took to the vehicle to a mechanic for inspection on or about 9/2/10 and I was told that the U-joint had 3 big pieces of metal laying in the bottom of the housing. I then had the vehicle towed to hubler Nissan in indianapolis, in and the service department confirmed the previous findings. Hubler stated that they would have to replace the complete rear axle. The approx. Cost would be $2,500-$3,000.

- Greenwood, IN, USA

2004 Nissan Titan; rear axle seal leaking: 1. in shop for tire rotation, mechanic saw fluid from rear axle on inside of my wheels. 2. not sure how longs its been leaking. Appears to be an on going problem for other Nissan Titan owners (multiple seal replacements). Consequences are fluid can leak onto brakes causing a braking failure which could result in a crash and possible death. 3. nothing done to correct the problem. Contacting mechanic today. *Nissan needs a recall on this*

- Fenton, MO, USA

Only 65,000 miles on my truck and no modifications. Right rear seal leaking, pinion seal is shot and front left axle needs to be replaced. Nothing covered under warranty. I am looking at a $3,000 repair bill on a 4 year old truck that has never been off road and doesn't have high miles. My exhaust manifold also cracked at about 60000 miles. This was able to be replaced under warranty.

- Waynesboro, PA, USA

The contact owns a 2004 Nissan Titan. The contact noticed lubrication on his driveway. The dealer stated that the transfer case, rear axle seals, and brake shoes were faulty and needed to be replaced. The current and failure mileages were 71,000.

- Summerville, SC, USA

I have a 2004 Nissan Titan and at approx. 50,000 miles my rear axle seals went out causing oil leakage!

- Magalia, CA, USA

I nearly rolled my truck yesterday at 75mph. The rearend locked up and I nearly lost control of the vehicle. I have since done some research only to find out that this is a huge issue with the 04 Nissan Titans! this could have cost me or another innocent person their life! now I am left to face a repair bill of $3500 for a new dana rearend, Nissan and dana Corp need to be held accountable for these cheap, unreliable rearends!!! please help!

- North Port, FL, USA

The contact owns a 2004 Nissan Titan. The contact stated that the steering wheel began to shake and rattle. The vehicle was taken to the dealer several times, but they insisted that there was no failure. The vehicle was taken back to the dealer and the steering failure was able to be duplicated. The steering rack force was adjusted; however, the failure persists. The manufacturer stated that the vehicle is five months out of warranty and will not offer any assistance. The current mileage was 24,800 and failure mileage was 16,021. Updated 07/07/08. Updated

- Webster , NH, USA