3.5
definitely annoying- Crashes / Fires:
- 0 / 0
- Injuries / Deaths:
- 0 / 0
- Average Mileage:
- 36,361 miles
About These NHTSA Complaints:
The NHTSA is the US gov't agency tasked with vehicle safety. Complaints can be spread across multiple & redundant categories, & are not organized by problem. See the Back button — blue bar at the very top of the page — to explore more.
In the last six months three out of 4 windows on my vehicle are now held up with duct tape so that they don't fall into the channel and I can't get them up. Luckily, only one of them managed to do that and a friend managed to get it back up for me. That occurred at the end of January 2006. I could understand one- maybe- but three!!! no. This is definitely a safety issue. I suspect the only reason that my one working window, the back passenger side, is still working is because I haven't tried to put it down- or the result would be the same. I am sure that is going to be expensive to repair, so I guess I'll go with the duct tape for a while. I have also had a problem with the intake manifold, the gaskets on that were replaced in January, 2006. I was losing antifreeze from the overflow tank, and having to fill it every day. Took it to the dealer, and they found the water pump leaking and the intake gaskets leaking. They were replaced at my expense. And... the intermittent turn signal is also a problem. That has been going on for about a year now. It should be recalled for that, like you did for the 2000- 2001 vehicles. The vehicle has 70,000 miles on it. The interior trim on this vehicle is shoddy, and that is being kind. The car was purchased brand new with 23 miles on it when we got it to our house in June, 1999. In less than a year a door panel had to be replaced because it had come apart. The dashboard has been peeling for about 11/2 years because they used cheap glue to hold the covering on the plastic. I realize that you consider that cosmetic, but it shouldn't be happening: I check every Alero I see in a parking lot and there are a lot with peeling dashboards. GM should be responsible for fixing that- they caused the problem. GM caused multiple problems on this vehicle by doing it on the cheap. It is very costly to the people who own them, and it shouldn't be. I don't mind paying for routine repairs, I expect that, but these problems are not "routine".
- Summerville, SC, USA
Have had the heater resister replaced twice and the blower motor once. When going to a professional mechanic to have a third resister installed (less than a month after the second and 13 months after the first replacement), he said that water was leaking down through the windshield into the blower motor, melted a 30 amp fuse and shorted out the resistor. The mechanic said this could have caused a fire under the dashboard of the car. The blower motor encasement was drenched with water.
- Rochester, NY, USA
Within my 36,000 of driving from 50,222 to 86,119 my intake gaskets have been replaced twice. My rack has been replaced twice and will need to be replaced a third time. I am also aware that the rack was replaced while the previous owner had the car. Recently I realized why water was getting into my passenger side of the vehicle. The window seal is shifted causing the window to leak if the car is parked at certain inclines. This repair is not covered by my pre-owned vehicle warranty. All major repairs have been covered by my warranty and any additional costs have bee quote "eaten" by repair facilities.
- New Britain, CT, USA
Rear floor in car is soaked whenever there is a heavy rain.
- Romeoville, IL, USA
The dashboard material has come unglued and shrunk. The dealer said it cost $900 to fix. I contacted GM to tell them about the problem and they told me they could nothing about it. I have since seen 5 other Alero's with the same problem. I am writing another complaint letter to GM after seeing other similar reports on this website.
- Humble, TX, USA
Dash material is pulling away from the base, air bag cover is coming off of the dash. Dealer states that it will cost over $300 to repair.
- Miami, FL, USA
Consumer stated the dashboard material peeled. The consumer stated the material peeled by the passenger side air bag. The cruise control did not work and both driver side windows motor broke.
- Homosassa, FL, USA
Dashboard is peeling. Cause is unknown.
- Slaughter, LA, USA
Dashboard is peeling. Cause is unknown.
- Slaughter, CO, USA
- Davenport, IA, USA