I was drove my car home one night and the headlights were working fine. I went in the house changed and got ready to leave again when I turned on my headlights they did not come on. Thought maybe it was the bulbs that went out but the bright lights worked. Had the bulbs check they were fine, I also checked the fuses to make sure that was burnt out. After a week the lights still were not working took it to a car mechanic and the analysis showed some sensor. He replaced the sensor and it did not fix the problem my low beam headlights are still not working.

- Norfolk, NE, USA

Headlights do not project a beam as far as when vehicle was new. Nightime driving on rural roads during deer season is hazardous. Saturn dealer has installed updated wiring harness to correct repeated premature daytime running light failures and coincidently or not, the headlights have performed poorly since then. Discussed this with Saturn dealer and service manager said he has lots of complaints about poor headlight performance from the Ion. I know my Saturn Ion headlights performed satisfactorily at first, but have degraded. The electrical system and my vision are both fine. The supension has not been altered and the vehicle has not been involved in an accident. I replaced factory halogen bulbs with sylvania silverstar 9007 bulbs and illuminated field is brighter, but still does not extend down the road much farther. At speeds over 55mph, on a dark rural highway, I can overdive my headlights. Emailed Saturn and they have never heard of my problem and did not offer a solution, but will listen to determine if this is a "trend". I'm afraid to drive this vehicle at night.

- Grantsburg, IL, USA

Throttle froze during the winter months. Consumer contacted manufacturer, and was told that because warranty expired they will not make any repairs without consumer first paying for it. Also, headlight covers were covered with a film that made visibility difficult. On 3-7-04 the vehicle was involved in an accident. When the consumer took her foot off the gas but the vehicle did not slow down. The vehicle began to slide then rolled over. The driver sustain double whiplash and left shoulder muscle spasms. The vehicle was not totaled. On 6-16-04 the front passenger side wheel bearing was replaced.

- Mio, MI, USA

Daytime running lights have shorted out 3 times since purchasing the vehicle in May 2003.

- Heathsville, VA, USA

Headligh movement, distracting to dirver as light beams hit object the beam appears to be gittering. Distracting also to vehicles in front of you as drivers continue to look in mirror. Saturn dealership stated they do not have a fix, that is is this way by design. Headlight mounts to mounting panel with (2) pins going through upper ear in mounting panel and then upper and lower ears on headlight assy. And into lower ear of mounting panel. Appears to much play in the pin to mount area, this will worsen over time as metal pin in plastic ears will become larger from the shaking. This occurs even of smooth road beds.

- Fredericksburg, VA, USA