Windshield Cracked on vehicle, this is the 2nd incident and second full windshield replacement In 2 years, noth OEM.

- Cedar Rapids , IA, USA

A small horizontal crack recently appeared on my Outback's front windshield while it was sitting in a garage overnight. The crack started from the passenger side and has now crept over to the middle of the windshield. Previous to this incident, the car had been sitting unused for over a month, so there was no opportunity for rocks or other debris from the road to cause the crack. This is the second time that the windshield has developed a crack out of thin air. I have replaced the windshield at least five times since owning the vehicle, in addition to having small chips from rocks repaired twice. These incidents are potentially dangerous and could possible interfere with the vehicle's automated systems such as collision detection and cameras.

- Albin, WY, USA

Windshield developed crack without impact. Crack runs from the bottom of windshield in front of steering wheel up to the middle of the windshield, impairing visibility. This is the fourth failed windshield on this vehicle within 4 years and 60,000 miles. Average lifespan of windshield on this car is less than 12 months. Previous windshields cracked with minor hits from pebbles at highway speeds. Windshield has not been inspected by manufacturer, police, or insurance representatives, but is available for inspection.

- Chelsea, MI, USA

Have had to replace front windshield 4 times in less than two (2) years due to windshield being cracked by small debris from other vehicles passing by. These have been very minor rocks that have hit the windshield with three of the times it occurred at less than 40 mph. One occurred when I was driving in a residential area at 20 mph. One event occurred spontaneously overnight with the car sitting inside an enclosed garage. Took a picture of the latest event. Concerned that if the window cracks that easy, what would happen if I am in an accident. Subaru is aware of the problem. Windshields have not been inspected by others. No warning lamps, messages, et cetera are related to these events. Review of web comments reveal that it is not an isolated event. Seems to be a design issue and how their Eyesight system affects the windshield design.

- Tucson, AZ, USA

On 2/20, a crack appeared across the drivers side of my windshield while my car was parked. The crack is approximately 15" long extending from the lower side of the windshield, curving up toward the middle of the windshield. The crack is significant enough that it will require replacement.

- Lemon Grove, CA, USA

Heated windshield area where the windshield wipers are shorted out and caused the windshield to crack

- Taylor Ridge, IL, USA

The windshield is ridiculously susceptible to cracks. I-??m on my third windshield in 4 years. I had the windshield last replaced in October and had a new crack within a month. I didn-??t even notice anything hitting the windshield with this last crack.

- Arkadelphia, AR, USA

When in reverse, the view behind the vehicle when using the rear camera display is poor when there is a shadow behind the vehicle making it difficult to see a person, especially a child. The rear view camera in my 2016 subaru Outback did not have this problem with shadows.

- Urbandale, IA, USA

Windshield developed a crack for no apparent reason on the lower passenger side. Car was parked. Only unusual circumstance is that was a hot day.

- Claremont, CA, USA

The windshield in my 2020 Subaru Outback has cracked spontaneously twice. I had 75K Bumper to Bumper Warranty, which the dealer would not honor the first time the window broke. He said that it was warranted for repair, not replacement. I argued until he gave me a 50% discount. My windshield broke again today. I had just pulled out onto the street and was traveling about 10MPH. No rocks or stone touched the windshield. The sound of the crack startled me. I thought that there had to be an issue. Consequently as I looked online, I have discovered this is a design flaw or something as the problem is widespread. Two cracks in year is not right and it is expensive.

- Austin, TX, USA

I am replacing 3rd windshield since September 2022. This was definitely caused by a rock chip but had been resin repaired. With defroster blowing on a cool morning the windshield cracked across the lower portion. The replacement windshield cracked for no reason other than it was cold during a December night and was replaced in April. That windshield cracked spontaneously while driving in the rain one month after install. A Subaru dealer took photos or I have sent photos to them of all incidents for submission to my Subaru insurance. I have now met the maximum allowed for windshield replacement. All windshields were replaced at an authorized Subaru dealer.

- Westboro, WI, USA

Over the course of the nearly three years I have owned my vehicle, the windshield has either spontaneously cracked or cracked from a very very small chip three times. Two of these occurred while I was driving, with no debris impact with the vehicle windshield. There have been several suits filed against Subaru for similar cases, including for the 2020 Outback model. This has been three times in about two and a half years, quadruple the amount for my previous vehicle. Not only is this a vision impairment while driving and a financial burden to fix, I also worry about more catastrophic failure should anything significant impact the windshield while driving. I have had the glass repaired twice, and both times the repair technicians could not understand how such a significant crack had occurred.

- Bozeman, MT, USA

While driving on I-26, a small rock made an initially small crack in the windshield. Over time, while still driving, we watched the crack expand larger and larger, spreading with multiple new arms across the entire passenger side of the windshield. After parking at home in the garage and scheduling windshield replacement for the next day, we continued to notice the crack continuing to propagate further into the driver side. The incident happened on 5/21/23 and the windshield was replaced on 5/23/23.

- Simpsonville, SC, USA

-The windshield has cracked in the same place for no apparent reason. -The cracked windshield can affect the use of the safety systems built into the windshield. -I'm not sure how this can be "reproduced" as we are talking about a broken windshield although the windshield has been fixed already once and now, the second break has occurred. -Not inspected but replaced once. It is currently broken and can be inspected again if need be. -The first one appeared in August 2022, the second in May 2023

- Stateline, NV, USA

On May 3, 2023 (~12:30pm local time) I was driving on the highway at approximately 60mph and there was a 'pop' sound. I looked at my windshield and an L-shaped crack appeared from the base of the windshield near the wipers up to half-way on the windshield. There was no damage to the windshield to indicate a rock had hit it or the car in any way. Given the poor quality OEM windshields that Subaru has installed in past models (2015-2016) that also have had this problem, I would like to notify the NHTSA so that Subaru can be notified. When I called my dealer directly, there was not much help on the cause.

- Scottsdale, AZ, USA

A crack has spontaneously appeared at the base of my windshield after no apparent damage. The crack is spreading across my windshield and will affect my adaptive cruse control and automatic emergency breaking if it interferes with the Subaru eye-sight system at the top of my windshield. I have not taken the vehicle in for service but I did see this was an issue that lead to recalls on previous outback models but not currently a recall for the 2020 Subaru Outback. I do not have any current warning lamps or messages.

- Rocky Point, NC, USA

I'm currently on my third windshield for this vehicle. The first windshield was replaced by Subaru due to a random crack that developed on the passenger side and traveled to the driver side. No visible damage caused this to occur. The second windshield was hit by a tiny stone driving down city streets. 3 days later the same type of crack, like the first windshield, developed and moved from from passenger to driver side. We'll see how long this third windshield lasts. I've had numerous cars without this problem. Stone chips were easily repaired without major cracking occurring. There is something very odd about how fragile the windshields on Subaru vehicles are. This is not a cheap replacement due to their driver assist technology. Subaru will not replace this once they see and sign of a stone impact.

- Greenfield, WI, USA

Purchased my 2020 Outback only about two months ago. Just this last week two separate cracks started from the edge of the window on the left and lower sides. Cracks appeared out of nowhere while parked with no contact from rocks or other debris. Over the course of the last few days has spread so much that it obstructs my vision while driving. This is a common problem with this model and is a safety hazard that needs to be recalled/fixed. Have an appointment with my dealer to see if this qualifies as a manufacturer defect. However the fact is this will most likely happen again if it-??s the same glass being used.

- Rocklin, CA, USA

While driving in light rain, with no visible strike, a crack appeared on the passenger side windshield; starting below the wiper and extending upwards in an arc towards the center. This is the 3rd time a crack of significance has appeared. Coincidentally, this crack appeared less than 2 weeks after having the windshield replaced by a Subaru dealership.

- Akron, OH, USA

The windshield has developed a crack spontaneously and is spreading across the entire windshield. It started near the bottom of the window near the wipers and moving it's way up towards the top and spidered out towards the driver's side now. It continues to grow while I wait for an appointment to get it replaced.

- Yorktown Heights, NY, USA