Second windshield cracked with no impact. This I-??d the second time within a year that this has happened to me. Like last time the crack isn-??t on the outermost layer, and if you run your finger along the crack it feels completely smooth. This is quite frankly unacceptable with how expensive these windshields are to replace.

- Orem, UT, USA

I have replaced the windshield for a second time resulting from a (non-impact) stress fracture coming from the passenger side A Pillar. It seems to be exactly the same spot as previous. The crack is large enough to put a credit card in at the start then wanders in varying directions with a finer crack. This time an aftermarket glass was available which I was told is thicker and more durable that the OEM glass. I am told Subaru has extremely thin OEM glass which they are having industry problems with. If it has any significance there is a dent in the passenger door jam B-Pillar which was there from new and painted over. It seems to be a result of manufacturing robotics possibly. I do not know if this is a clue to two windshields stress cracking.

- Hope Valley, RI, USA

Windshield glass broke spontaneously and randomly with no impact associated with the crack. The crack extends all the way across the windshield.

- Cincinnati, OH, USA

Went out to driveway and started car. Heard a ping. a few minutes later the windshield started to crack from drivers side bottom corner upward across the field of vision. At first it was about a foot long but spread to about 3 feet. No sign of impact.

- Oak Lawn, IL, USA

Windshield cracked on passenger side starting below the lower interface to the plenum. Crack was not caused by impact by debris nor a collision.

- Howell, MI, USA

I washed my car the night before and put it in the garage where it usually is parked at night. Upon getting in to start it and go to work noticed a 6inch crack start from the lower center part of the windshield. There was no impact as it was literally sitting inside my garage all night long. It looks like it stars from below the trim.

- Monroe, WA, USA

My husband bought this vehicle in 2021. It was brand new and since we have had it we have had to replace the windshield many times! We are now going in for its 6th replacement this week! This will be the 4th one that we have had to pay a deductible. The first time it happened the dealership replaced it because it happened within a short time of purchasing it. The second time, we were told to contact Subaru of America and they said to go back to the dealer. When we did, the dealership says it would only cover the first one so we had satellite do it through an insurance claim. Fast forward 2 years and like I said earlier in this complaint we are getting a 6th one put in on Friday! Just ridiculous from my standpoint. My husband loves his car and usually doesn-??t like to be confrontational so I am the one doing this complaint! I also use the Outback every so often.

- Vancouver, WA, USA

While driving on a Saturday heard a popping sound and watched a crack start at bottom center of windshield travel up about 7" and arc to the right. Has now spread about 13" towards passenger side. No impact occurred to cause this. On Monday took vehicle to our dealership so they could take pictures and check it out. Said they would talk to the Subaru District Manager and let me know about replacement. Dealership called me to say they agreed to replace as long as I paid a $250 deductible. This doesn't seem right when this is an issue that many many people are having. This was my third Outback and will now be my last. I can't support a brand that won't step up to take care of something that is obviously a serious issue.

- Huntsburg, OH, USA

I-??ve been reading about easily cracked windshields on Subarus, and sure enough, my windshield cracked this morning. To be clear, there is a tiny impact point from probably a pebble or something, but the glass should not have cracked that easily. Probably about an 8 inch J crack right in the center bottom of the windshield. I-??m in the process of talking with Subaru to see if it will be covered.

- Statesboro, GA, USA

1. 2022 Outback windshield, on passenger side, has cracked twice in the same spot. We bought the vehicle brand new. It currently has 9300 miles on it. The vehicle is driven approx. 8 miles a day and sits in our garage 95% of the time. 2. Safety & visibility is affected as the crack spreads across the windshield. 3. Yes, I paid a Subaru service center $1600 to repair the windshield in January 2024. By May, it was cracked again in the same spot. The problem has been reproduced SEVERAL times as confirmed by this Reddit chat [XXX]. Yes, the first crack was inspected by Subaru service technicians. 5. No warnings. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

- Valencia, CA, USA

Windshield suffered a large stress crack while parked overnight. Came out to an 18-?? stress crack in the morning. A long, single, curved crack with no point of impact. Later in the day, still while parked, the stress crack extended half the width of the windshield. Took the car to the dealership and was informed that the windshield is not covered under warranty.

- Long Beach, CA, USA

In the two years I have had this vehicle, I have had to replace the windshield twice. The first time, a pebble hit the windshield and a 6-8 inch crack immediately appeared, The crack increased in size over days and nearly went across the whole windshield. Because this was a few months after purchase, Subaru replaced it. Now in March 2024 and another pebble hit the windshield, this one so small i didn't even see it and a 8 inch crack immediately appeared. The crack increased in days as well. Subaru would not cover it and told me to go through my insurance. I waited to get it repaired and during this time another pebble hit the glass. Again, another 6-8 inch crack. Subaru refuses to take responsibility that this is a manufacturer issue. I've had 3 other Subaru vehicles and this never occurred.

- Mundelein, IL, USA

Windshield cracked when vehicle was traveling at a slow rate of speed, in the rain while on an on/off ramp. It has already been repaired. Crack went across the windshield right in my line of vision. The dealer examined the car and stated that at some point, the windshield was hit and that it just eventually cracked. There was no warning prior, I had not noticed any nicks prior to the crack.

- Leonardo, NJ, USA

While on highway 880 north bound. A rock was thrown towards our windshield while going through construction zone.

- Newark, CA, USA

While parked and without impact from any object, the windshield cracked causing visibility issues for the driver leading to unsafe driving conditions for those inside and outside the vehicle. The problem is a common issue among many Subaru vehicles. The issue has been reported but not yet inspected. There were no warnings before the issue appeared.

- Manchester, TN, USA

A crack developed in the windshield on the passenger's side spontaneously. We got in the car in the morning and noticed it. There are not any chips/indents where a stone/rock may have started the damage, but starts at the edge of the windshield. It started about 8 inches and now it is about 20 inches in less than 24 hours. We called our insurance company to ask about repairing it. Our deductible is $1000 so we will need to pay most all of it out of pocket. They let us know that unfortunately they've been seeing similar issues with other policyholder's subaru windshields the past 5 years or so and for us to contact the Subaru corporate office. We will be having it replaced by Safelite.

- Morganton, NC, USA

2 Spontaneous damaged windshields.

- Midlothian, VA, USA

I parked at a store, i came out an hour later and there was about a foot long crack in my windshield. I asked to look at the security footage of the store and there was no contact from anything or anyone with the windshield. There is not point of impact, the windshield simply cracked on its own on the passenger side. There was absolutely no sign of any damage before this and i had recently had inspection at the dealership and there was no mention of any issues with the windshield. I reached out to the salesman who sold me this car from the Subaru dealership about 3 months ago and he said they could not help. I reached out to Subaru Customer Advocacy and they are contacting dealership, I have not heard back.

- Toms River, NJ, USA

I parked the vehicle at a local restaurant in the sun. The windshield cracked from midpoint passenger side to middle and f windshield. No impact from rock or other item and I had the car in sight at all times while in the restaurant. This is a defective part. When I bought the car I paid extra to have a special coating put on at the dealership due to a known thin glass problem on Subarus.

- Imperial Beach , CA, USA

Windshield spontaneously cracked while parked overnight in garage. Crack originated on passenger side in the middle of windshield starting at the end of the panel and running to middle of windshield horizontally. No chip, damage, impact happened. It literally cracked on its own overnight. Husband is a window engineer and said either the glass is not sustainable for the span of the windshield or the seal is faulty and it dislodged/shifted the glass causing a pressure crack. Subaru has no recalls but this is a common problem according to this website and hopefully someone can address this because it-??s a safety issue and happens without impact or damage.

- Little Falls, MN, USA