10.0

really awful
Crashes / Fires:
1 / 0
Injuries / Deaths:
1 / 0
Average Mileage:
97,184 miles

About These NHTSA Complaints:

The NHTSA is the US gov't agency tasked with vehicle safety. Complaints can be spread across multiple & redundant categories, & are not organized by problem. See the Back button — blue bar at the very top of the page — to explore more.

Get notified about new defects, investigations, recalls & lawsuits for the 2003 Toyota 4Runner:

Unsubscribe any time. We don't sell/share your email.

problem #107

Oct 012020

4Runner

  • miles
I purchased this 2003 Toyota 4Runner in 2018 under what I assumed was prime condition, for a vehicle that spent the majority of its life in Nebraska/Kansas before I moved to Texas in 2021. At 87,400 miles at the time of purchase, the vehicle had no visible damage to the exterior besides a few paint chips, some minor hail damage and scratches, and some easily fixed surface rust in the paint on the tailgate. The previous owner had driven it leisurely and had kept the miles low after 15 years. The car has had some mechanical issues, but nothing out of the ordinary outside of some regular maintenance over the first few years. Being close to 100,000 miles, the timing belt and pump was replaced around 98,000 miles. Other issues have been fixed periodically, please reference the attached files. After joining a Toyota 4Runner 4th Generation Facebook group and seeing a post about another's issues with rust damage in October 2020, I decided to take a look at my own frame. I then inspected my own vehicle, and found significant frame rot damage. It is extensive, with significant rust to the frame, with large holes and soft patches that question the integrity of the frame and the safety of the vehicle on the road. Every time I hit a small bump or pothole, I fear the frame will crack and I will lose control as others have. I have not sought out professional repairs due to the extensive cost, and am awaiting the outcome of a current class action lawsuit by the Bell Legal Group. The 4th Generation Toyota 4Runner (2003-2009) is built on the exact same frame as the Toyota Tacoma of that era, yet while the Tacoma was recalled for frame rot, the 4Runner was not included, which I believe to be a gross oversight in previous legal proceedings. The 2003-2009 Toyota 4Runner is a reliable vehicle, but poses significant frame rot issues much earlier than should be expected.

- Austin Texas, TX, USA

problem #106

Aug 092022

4Runner

  • miles
There is severe rust on the frame, the rear is listing by 3/4 of an inch due to suspension rust, parts of the frame are perforated and lots of rust can fall out of drain holes when tapped. I am unable to steer the truck due to the intermediate steering column rust. The Tacoma was recalled for the same reason, I am assuming the 4runner has not been recalled because it was manufactured in greater numbers, and therefore more costly to repair, the danger of the severe rust is the same in both vehicles.

- Hillsborough, NJ, USA

problem #105

Dec 222021

4Runner

  • miles
Stabilizer bar connecting the axle to the frame rusted off. I was driving only 25-30mph at the time, luckily. The vehicle swayed violently almost causing an accident and nearly forcing me off the bridge I happened to driving over. Very fortunate no one was hurt and nothing was damaged from the incident. You can imagine the tragedy if that had happened on the highway driving 75mph! Major accident, innocent lives damaged or lost. This is a very dangerous vehicle not only to the driver and passengers but also to anybody that happened to be innocently in the path of an out of control Toyota 4runner. Toyota Please fix this, for your safety and everyone else on the highway. People should be warned!!

- Greenville, MI, USA

problem #104

Dec 222021

4Runner

  • miles
Stabilizer bar connected to the frame rusted off, back passenger side! Causing the vehicle to sway uncontrollably, due to the low rate of speed, I was able to regain control of my vehicle and not drive off the bridge I was driving over at the time or crash into another vehicle. The engine runs great, everything works, the vehicle still looks good but the frame is rusting out from underneath it! Toyota Needs To Make It Right!

- Greenville, MI, USA

problem #103

Apr 012017

4Runner

  • miles
The rust and corrosion underneath the vehicle continually gets worse year after year. The main components of vehicle relating to the engine, powertrain and suspension underneath vehicle are corroded; holes exist in the frame of the truck through out. The frame of truck is rotted due to not being sealed properly during the manufacturing process. Due to the rust and corrosion on the frame of truck, it is impossible to get work done on exhaust and muffler areas. I will send pictures for your reference. This makes driving a safety concern for myself and my son. At this time, I am unable to purchase a new car and do not have money to replace/fix the frame of truck. Inevitably, this problem will get worse and may cause a safety concern for myself and others on the road. I called Toyota on 4/12/22 and was told that there is not a recall for this issue and that any repairs would have to be paid by me. I then proceeded to call the number given to me by the representative to call 800-331-4331 for the Toyota Corporate office. I spoke to Blake who gave me the same answer, there was not a recall on this vehicle for rust/corrosion on the frame of vehicle. At this time, Toyota charges $150 just to check car and unfortunately, I don't have those funds to pay such a fee. I asked Blake if there was a way, Toyota can check without charging a fee and his answer was no. Currently, there is not any warning lights on, but with increased time and pressure of exhaust pipe and muffler will create more problems. I cannot have the exhaust system fixed until the frame of truck is replaced. My car was checked by an independent shop.

- New Windsor, NY, USA

problem #102

Apr 152021

4Runner

  • miles
I own a 2003 Toyota 4Runner with very low mileage for its age. It has been garage kept for most of its life. I was experiencing difficulty steering, and when I took the car to a mechanic, it was determined that the frame was prematurely rusted and rotted to a dangerous level putting my life at risk while driving it.

- Bonita Springs, FL, USA

problem #101

Sep 092021

4Runner

  • miles
I have not actually had an incident yet, but have been advised by the Toyota service team that I should no longer tow trailers and should consider not driving it at all due to frame rust/perforation in front of the rear control arms. This has been a well cared for vehicle that is in otherwise great shape (It has had every repair the dealership has ever recommended) the vehicle was bought per the dealerships claim that it could be driven "forever" as long as the dealership takes care of it. And now I'm faced with a massive expense to repair or replace the vehicle.

- Lincoln, NE, USA

problem #100

Aug 032019

4Runner

  • miles
The main rust issues are claims arising out of a pending class action lawsuit pleadings-€™ that the Toyota Manufacturer perform at no cost inspections, in addition to dire emergency needed replacement of including my 2003 Toyota 4Runner frame because of premature rusting of the undercarriage-my vehicle-€™s frame due to improper treatment against rust corrosion during manufacturing-inadequate rust protection, which has lead to severe excessive rust corrosion significant enough to affect structural integrity, compromising the vehicle-€™s safety, stability & crash-worthiness, & poses a dangerous risk.

- Washington , DC, USA

problem #99

Sep 012020

4Runner 8-cyl

  • Automatic transmission
  • 185,000 miles
The contact owns a 2003 Toyota 4Runner. The contact stated that while driving at limited speeds of 45 mph, the vehicle would wobble and swerve and was very unstable. The vehicle was taken to a Certified Auto Mechanic Shop and an independent mechanic who diagnosed that the failure was caused by severe rusting, perforation and corrosion of the rear subframe and suspension system. The vehicle was also driven to Muffler Shops in Bladensburg, MD on 8-20-2021, and on 10 -22-2021 to Hyattsville Toyota's Certified Toyota Collision Center for Repair Estimates of $4,000 and $7,268. The vehicle frame manufactured by Dana Holding Corporation which really requires fixing or replacing was not yet repaired. The Toyota manufacturer and local dealer Global Auto Outlet were notified of the failure. The approximate failure mileage was 1 85,000. The used vehicle was purchased from Global Auto Outlet in Temple Hills, MD for $9,552.24 on 8 -1-2019 with 175,000 miles on the odometer. The windshield had a crack in it, the air conditioning & emergency brake didn't work. The Complainant hadn't noticed the perforated excessive rust corrosion on the undercarriage of the vehicle until numerous months afterwards. Moreover, at the time of the purchase the Owner also didn't notice that the spare tire carrier was rusted, as well as undiscovered that the wrong size 265/65/17 spare tire it was held in was perforated and flat. After the purchase of the vehicle shortly later, the exhaust tailpipe rusted broke first and the muffler had to be replaced which costed $258.79. The Owner was nervously forced to operate a more than unsafe motor vehicle for up to 6 months.

- Washington, DC, USA

problem #98

Jun 292021

4Runner

  • miles
At the end of June 2021, while driving I experienced a loud clunk and grinding noise, with reduced control of steering and brakes on my 4Runner. I took the 4Runner to a Goodyear Automotive Service Center on Woodward Avenue in Royal Oak, Michigan, who told me that the vehicle was not driveable due to severe rust damage of the frame that resulted in a broken sway bar. I thought I should take it to the closest Toyota dealership in Troy, Michigan for advice and they responded that the vehicle was beyond repair and that a new frame would cost around $20,000. I could not leave my car there, and risked driving it home, where it has been parked ever since.

- Alanson, MI, USA

problem #97

Jul 012014

4Runner

  • miles
No Accident - Items need to be investigated for Safety Defects on Toyota's. 1> Front Brake Calipers (constant freezing of the front brake calipers). 2> Dash Cover (excessive cracking on the dash covers especially areas that contain airbags). 3> Fuel Pump Connection (on top of fuel tank, connection to fuel pump appears to create a short, which in turn causes vehicle to stall also could cause a fire). 4> Excessive Frame Rust (frame has excessive rust outside and inside which is causing frame to fail. this is a manufacturing issue). These are ongoing issues with Toyota that have been reported and nothing is being done about it. Multiple 4runners are having big time Excessive Frame Rust, which are causing the frame coming apart during highway driving. These photo's show the rust on the outside and inside, all metal is having rust issues. Paint has been applied to cover said rust but it still reappears with-in a few months. Best way to contact me is via e-mail.

- Woodbridge, VA, USA

problem #96

Jun 202021

4Runner

  • miles
I heard a loud noise (scraping-dragging) from the bottom of the engine area while driving on the highway This was a very dangerous and scary incident Pulled over and My fiancé checked under the engine A very large metal piece was dragging the road I did not hit a bump or anything. A body shop mechanic informed me that the chasis of the 4 runner was in extremely bad condition The 4Runner will not pass inspection because of this condition I respectfully request help in this matter

- Phila , PA, USA

problem #95

Jun 162021

4Runner

  • miles
Frame is rotted out and brake lines attached to the frame as well as every suspension component. Car failed inspection deemed unsafe to drive. This problem has been addressed for Tacoma, tundra and sequoia but not 4runner. These frames have the same issue as those and needs to be repaired by Toyota due to lack of rust and corrosion protection. There-€™s no reason 4runner should be overlooked for the same issue as the other full frame trucks.

- Patchogue, NY, USA

problem #94

Mar 012021

4Runner

  • 215,000 miles
Frame is completely rotted out rusted, gas tank straps are rotted/rusted. Rear sway bars are rotted off the frame. This vehicle has the same frame issue as the Tacoma and sequoia frames that are on recall.

- Audubon, NJ, USA

problem #93

May 052021

4Runner

  • miles
Adding my name to the list of people who have experienced excessive and premature frame rust on their 4runner, potentially causing unsafe conditions which could lead to a collision. Toyota addressed this problem for the Tacoma, sequoia, and Tundra of the same years, and they should do the same for the 4runner.

- Corinne, UT, USA

problem #92

Apr 232021

4Runner

  • 189,000 miles
I have been in contact with Toyota several times over the past 4 years about rust issues with this frame, but the refuse to fix it. They recalled the Tacoma, Tundra and sequoia of the same year for this reason. The frame rusts and falls apart. While driving up my road I felt the rear of the car shift to the side, I turned around and went straight home to find the frame at the rear passenger tire broken. I have attached a picture of the broken area, but can send more pictures of the entire frame if needed.

- Palmerton, PA, USA

problem #91

Apr 072021

4Runner

  • 150,000 miles
The frame is rusted beyond repair and the vehicle has spent the majority of its life in a N underground garage protected from the elements, as well as in Florida. It has very low mileage, and no other serious problems.

- Bonita Springs, FL, USA

problem #90

Apr 022021

4Runner

  • 136,000 miles
Extreme rust and corrosion in frame, suspension components. This will lead to catastrophic failure at some point if holes and frame deterioration is not addressed quickly.

- New York, NY, USA

problem #89

Jan 292021

4Runner

  • 205,000 miles
Frame is rusted out, excessive rust throughout the entire frame and suspension components. Sway bar mounts for rear axle have rusted out vehicle is unsafe to drive

- Audubon, NJ, USA

problem #88

May 222020

4Runner

  • miles
Extreme corrosion of frame and brackets

- Chicago, IL, USA

Read the next 20 complaints »