The contact owns a 2007 Toyota FJ Cruiser. The contact stated upon inspection, the mechanic discovered that severe corrosion had formed on the entire undercarriage of the vehicle. Prior to the discovery, the contact stated that an unknown part had separated and detached from the vehicle in his driveway due to the corrosion. The dealer then took several pictures of the corrosion on the vehicle. The contact was warned by the dealer to not drive off road or use the vehicle to tow due to the failure. The manufacturer was notified of the failure and offered no assistance. The vehicle was not repaired. The failure mileage was approximately 70,000. Vin was not available.

- Washington, IL, USA

The contact owns a 2007 Toyota FJ Cruiser. The contact stated that the rear sub-frame was extremely corroded. The contact also stated the ABS warning light was illuminated. The contact took the vehicle to a local dealer, where it was diagnosed with needing the sub-frame to be replaced. The mechanic was unable to diagnose the failure with the ABS warning light illumination. The vehicle was not yet repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 204,000.

- Carmel, ME, USA

Had a virina safety inspection performed on 6-25-2020 and it was found the frame is completely rusted out. The vehicle cannot be driven due to safety reasons. 2007 Toyota Fj cruiser with 101000 miles. No accident or injury but vehicle is not operable due to structural failure could happen at any time.

- Disputanta, VA, USA

The driver foot rest (dead pedal) on this car brakes loose easily and becomes a loose object under and around the driver foot pedals. I had mind come loose while driving and didn't realize it until I attemped to stop my car and was unable to depress the brake pedal because the broken foot rest had lodged it's self under the brake pedal after braking loose. I ended up having to swerve around the car in front of me on the highway to avoid an accident, before stopping with the E-brake on the side of the highway. Extremely dangerous!

- Cloverdale, CA, USA

2007 Toyota Fj cruiser. Consumer writes in regards to vehicle poor driving visibility and other multiple defects. The consumer stated he had difficulty seeing oncoming traffic at intersections. It appeared the decision to go with a half door on the vehicle with a short frame was the root cause of the poor visibility. Also, the inability to exit the vehicle from the back seat on the passenger side, was impossible without the front passenger opening the front passenger door first. The consumer also stated space left between the end of the roof and the beginning of the rear door drained so poorly that leaves and other natural debris would build up to the point that, when it rained, water would leak into the cargo area. Also, despite the claimed gas mileage reported on the window sticker (20 mpg) the consumer never achieved more than 17.1 mpg, even though the bulk of his driving was done on the highway.

- Monticello, NY, USA

The driver's left foot rest came loose and went under the brake pedal. I was able to clear the pedal before braking. I think this could be a wide-spread issue after looking at several internet posts.

- Heath, TX, USA

The left foot rest fell off while driving and almost got stuck underneath the brake pedal.

- Portland, OR, USA

05-14-2010 I have been very concerned about this fender bulge and /cracking problem on the fj's. well it was my turn, a bulge right there on the drivers side crumple zone. Lets face it, if the crumple zone is already crumpled before you get in an accident, how is it going to help you if you get into an accident. I took it to the dealer, they contacted the fts, field technician specialist. The fts wanted to see if the fj to see if it was stock. I did have one modification. After reading everything I could get my hands from the forums members on this subject I decided to have a readylift leveling kit, installed in the front only to prevent the tires from hitting the inter fender wells. The lift only raised the front 2.25 inches and the drive remained the same. Any modification problems that Toyota may have a problem with can be handled with a copy of the magnuson ' moss warranty act of 1975. The field technician specialist checked out bulge on the driver's side crumple and they verified front inner fender was bulged and recommend the replacement of the right & left front inner fenders. 06-28-2010 I got the fj back from the body shop on Thursday the 24th. Both the apron sub-assemblies & reinforcement sub-assemblies were replaced. Under the hood I couldn't even tell if it was worked on. After all that I have read and the folks I have talked to I'm glad Toyota stepped up to the plate and fixed the problem. Let's hope it stays fixed.

- Placentia, CA, USA

The Toyota Fj cruiser develops bulges in the engine bay over time with normal driving. These are in the crumple zones and eventually rip. Toyota fails to fix this to spite having hundreds of documented cases. Mine is one of them. www.fjcruiserforums.com/forums/Toyota-fj-cruiser-polls/37556-do-you-have-inner-fender-bulges-cracking.html.

- Salt Lake City, UT, USA

Defective paint. Excessive chipping of paint on the vehicle. Especially around the front window and side panels. Not due to rocks. Looks like polka dots all over.

- Denver, CO, USA

2007 Fj cruiser has a crack on the inner fender, also referred to as an engine bay body rip. This vehicle has not been in an accident. The crack was noticed at around 39,500 miles, but may have been there earlier. No corrective parts have been installed.

- Pahoa, HI, USA

Beginning at about 2 months the paint on my vehicle started coming off. My friend has the same vehicle but 2 weeks older & has the same problem. The paint has gotten progressively worse and now my car is rusting. My friend also has rust spots on his car.

- Denver, CO, USA

The paint has been dramatically chipping off of my 2007 Fj cruiser. This was brought to the dealerships and Toyota regional managers attention immediately and it has been over a year and a half of unreturned phone calls, missed appointments and being dismissed.

- Cumberland , ME, USA

Fender apron tears and bulges in the engine bay of my Fj cruiser.

- Hesperia, CA, USA

2007 Fj cruiser was serviced by big island Toyota multiple times in 2008. February 11, 2008 - 31649 miles ' 30,000 mile service, includes under vehicles inspection. April 16, 2008 - 33007 miles ' safety check inspection, spark plug replacement, cabin filter replacement August 20, 2008 - 34418 miles ' stereo inspection for warranty issue August 27, 2008 ' 34582 miles - warranty replacement of broken stereo the February 11 service states the following parts under vehicle were marked "checked and okay": shock absorbers / suspension steering gear box / linkage and boots / ball joints / dust covers muffler / exhaust pipes / mountings engine oil and fluid leaks brake lines / hoses / parking brake cable drive shaft boots / constant velocity boots / U-joints / transmission linkage transmission / differential / transfer case fuel lines and connections / fuel tank band / fuel tank vapor vent system hoses inspect nuts and bolts on body chassis the April 16 service marked all components as app'd, including multiple components that would have required the technician to be under the vehicle. We chose big island Toyota to perform our service as we were under the impression that we were getting the best service for our Toyota vehicle. The corrosion discovered in December was so complete that there was no way it wasn't present during previous services and Toyota did not point it out when they were under the vehicle. Neglecting to call attention to the problem during previous paid services prevented us from being able to address the corrosion issue before parts began to fall off and perforate the frame. At this point big island Toyota has declared that the vehicle has no value whatsoever and they will no longer provide service to us at the dealership.

- Pahoa, HI, USA

Left and right side inner metal fenders are tearing and bulging.

- Lake Forest, CA, USA

My complaint has to do with the paint! I have repeatedly gone into Toyota to have them deal with this chipping problem. They have fixed chips only on the uprights beside the window. The chipping is occurring on all parts of the vehicle, on flat surfaces such as the hood and right and left sides. To date I have over 200 chips with 60,000 km - I have over 300,000 km on a 1997 Ford that has been driven in the same conditions that has 1/20 the chips. There is a problem with the maroon paint on this Fj cruiser. It is not going away and it appears to be a problem with the bond between the paint and the primer as best I can tell.

- Calgary, 00, USA

My 2007 Toyota Fj cruiser developed two, under the hood, wheel well/inner fender cracks, at the crumple dimples. The vehicle exhibited the body cracks at 18,000 miles. Each crack, one on the left and right, directly above each upper wheel well, where attached to the inner fender, are about 4" long and 1/16"-1/8" wide. I took the truck to Toyota where, without batting an eye, sent the truck to a body shop and replaced both the left and right inner fender assembly. This was a very major repair, costing Toyota about $8K in materials and labor. I am very concerned that this problem will reappear, after my warranty expires at 36,000 miles. I do not sport off-road this truck.

- Oakland, CA, USA

Chipping paint all over Toyota Fj cruiser and windshield looks pitted. Talked to service department and was told that their wasn't a problem with the paint.

- Katy, TX, USA

Paint failure is immediate. Vehicle is a Toyota 2007 Fj cruiser. Car was parked under mesquite tree for shade. Tree sap from tree caused paint to immediately bubble and crack and come off. Literally everywhere drop hits body and bumper is damaged, approximately 50 spots or more. Paint releases completely to primer.

- Bishop, TX, USA