2020 Toyota RAV4 Hybrid
TSBs (Technical Service Bulletins)
Technical Service Bulletins (TSBs) for the 2020 RAV4 Hybrid are official communications between Toyota & their dealerships that describe processes for troubleshooting or fixing certain common problems. All vehicle manufacturers are required by U.S. law to make their TSBs available to the public.
-
TSB #T-TT-0582-19 Rev
TT: Customer states that there is a squeak or groan noise from the steering column area when turning the steering wheel. Read More »
-
TSB #T-TT-0582-19
TT: Customer states that there is a squeak or groan noise from the steering column area when turning the steering wheel. Read More »
-
TSB #T-TT-0616-20
TT: Some customers may experience an abnormal steering sensation (?pulling?, ?drifting?). Condition may be more pronounced with ADAS systems (LTA, LKA, DRCC) turned on or after a cold soak. Read More »
-
TSB #T-TT-0623-20
TT: Some 2019-2020 model year RAV4 and RAV4 HV vehicles may exhibit a front brake squeal/squeak noise when braking at low speeds. Read More »
-
TSB #T-SB-0009-19_Rev
TSB: Long-term or off-site storage requires special care to keep vehicles factory fresh and ready for delivery. Read More »
-
TSB #T-TT-0614-20
TT: Some 2020 model year models equipped with A25A-FKS or A25A-FXS engine may exhibit a MIL ON with one or more of the following DTCs (P26CB71, P26CA14, and P26CA31) and/or coolant leak from electric water pump body or electrical ... Read More »
-
TSB #T-SB-0023-20
TSB: Some 2019 ? 2020 model year Avalon Hybrid, Camry Hybrid, and RAV4 Hybrid vehicles may exhibit a MIL ON condition with a ?Hybrid System Malfunction? message displayed and one or more of the following DTC(s) that represent an over ... Read More »
-
TSB #T-SB-0074-20
TSB: Some 2003 ? 2020 model year Prius, Prius C, Prius V; 2006 ? 2019 model year Highlander Hybrid Vehicle; 2007 ? 2020 Camry Hybrid Vehicle; 2013 ? 2020 model year Avalon Hybrid Vehicle; 2016 ? 2020 model year Mirai and RAV4 Hybrid ... Read More »
-
TSB #CUSTOMER SUPPORT
DE: Toyota has received customer reports of certain 2019-2020 model year RAV4 HV vehicle fuel gauges displaying less than full and/or total fuel dispensed is less than expected, when the fuel nozzle automatically clicks off. Read More »
-
TSB #CUSTOMER SUPPORT
RE: Toyota has received customer reports of certain 2019-2020 model year RAV4 HV vehicle fuel gauges displaying less than full and/or total fuel dispensed is less than expected, when the fuel nozzle automatically clicks off. Read More »
-
TSB #20TE04 - RAV4 HV
DL: Toyota has received customer reports of certain 2019-2020 model year RAV4 HV vehicle fuel gauges displaying less than full and/or total fuel dispensed is less than expected, when the fuel nozzle automatically clicks off. Read More »
-
TSB #20TE04 - RAV4 HV
RL: Toyota has received customer reports of certain 2019-2020 model year RAV4 HV vehicle fuel gauges displaying less than full and/or total fuel dispensed is less than expected, when the fuel nozzle automatically clicks off. Read More »
-
TSB #CUSTOMER SUPPORT
RL: Toyota has received customer reports of certain 2019-2020 model year RAV4 HV vehicle fuel gauges displaying less than full and/or total fuel dispensed is less than expected, when the fuel nozzle automatically clicks off. Read More »
-
TSB #CUSTOMER SUPPORT
RL: Toyota has received customer reports of certain 2019-2020 model year RAV4 HV vehicle fuel gauges displaying less than full and/or total fuel dispensed is less than expected, when the fuel nozzle automatically clicks off. Read More »
-
TSB #20TE04 - RAV4 HV
RL: Toyota has received customer reports of certain 2019-2020 model year RAV4 HV vehicle fuel gauges displaying less than full and/or total fuel dispensed is less than expected, when the fuel nozzle automatically clicks off. Read More »
-
TSB #CUSTOMER SUPPORT
RL: Toyota has received customer reports of certain 2019-2020 model year RAV4 HV vehicle fuel gauges displaying less than full and/or total fuel dispensed is less than expected, when the fuel nozzle automatically clicks off. Read More »
-
TSB #20TE04 - RAV4 HV
RL: Toyota has received customer reports of certain 2019-2020 model year RAV4 HV vehicle fuel gauges displaying less than full and/or total fuel dispensed is less than expected, when the fuel nozzle automatically clicks off. Read More »
-
TSB #T-SB-0095-20
TSB: Some 2020 model year Camry, Camry Hybrid, Corolla Hatchback, RAV4, and RAV4 Hybrid vehicles may exhibit one or more of the following conditions: ?Diagnostic Trouble Code (DTC) B15A804 is present in current or history. Read More »
-
TSB #T-SB-0021-20 Obs
TSB: OBSOLETE NOTICE September 30, 2020: This bulletin is now obsolete. Please see T-SB-0095-20. Read More »
-
TSB #T-TT-0616-20
TT: Some customers may experience an abnormal steering sensation (?pulling?, ?drifting?). Condition may be more pronounced with ADAS systems (LTA, LKA, DRCC) turned on or after a cold soak. Read More »
-
TSB #T-TT-0614-20
TT: Some 2020 model year models equipped with A25A-FKS or A25A-FXS engine may exhibit a MIL ON with one or more of the following DTCs (P26CB71, P26CA14, and P26CA31) and/or coolant leak from electric water pump body or electrical ... Read More »
-
TSB #T-SB-0023-20
TSB: Some 2019 ? 2020 model year Avalon Hybrid, Camry Hybrid, and RAV4 Hybrid vehicles may exhibit a MIL ON condition with a ?Hybrid System Malfunction? message displayed and one or more of the following DTC(s) that represent an over ... Read More »
-
TSB #T-SB-0009-19_Rev
TSB: Long-term or off-site storage requires special care to keep vehicles factory fresh and ready for delivery. Read More »
-
TSB #T-SB-0021-20
TSB: Some 2020 model year Camry, Camry Hybrid, Corolla Hatchback, RAV4, and RAV4 Hybrid vehicles may exhibit a condition in which the Remote Connect app does not accept the activation code and/or becomes inoperative, and/or the SOS call ... Read More »
-
TSB #T-SB-0008-19_Rev
TSB: An initialization procedure is required to activate the Entune? 3.0 App Suite Connect for Audio, Audio Plus, and Premium Audio head units before they are used for the first time on new vehicles. Read More »
-
TSB #T-TT-0442-17_Rev
TT: Safety Connect is a vehicle option which requires a subscription fee for the system to be active after the initial trial period. Once the subscription has expired the DCM (Telematics Transceiver) will be in an inactive state. Read More »
-
TSB #T-TT-0572-19_Rev
TT: Some 2020 model year Camry, Camry HV and Corolla Hatchback vehicles equipped with a DCM may exhibit a B15A8** DTC in history during PDS. Read More »
-
TSB #T-TT-0553-19
TT: The new DCA-8000 Diagnostic Charger may cause your facility?s Ground Fault Circuit Interrupter (GFCI) breaker to trip. A GFCI breaker can be tripped for various reasons, one of the reasons may be related to the DCA-8000. Read More »
-
TSB #T-SB-0007-19
TSB: A battery in a stored vehicle is subject to conditions that can reduce its performance and life. These conditions include storage period, temperature, parasitic drain, and battery load. Read More »
-
TSB #T-SB-0074-20
TSB: Some 2003 ? 2020 model year Prius, Prius C, Prius V; 2006 ? 2019 model year Highlander Hybrid Vehicle; 2007 ? 2020 Camry Hybrid Vehicle; 2013 ? 2020 model year Avalon Hybrid Vehicle; 2016 ? 2020 model year Mirai and RAV4 Hybrid ... Read More »
-
TSB #T-TT-0553-19 Rev
TT: The new DCA-8000 Diagnostic Charger may cause your facility?s Ground Fault Circuit Interrupter (GFCI) breaker to trip. A GFCI breaker can be tripped for various reasons, one of the reasons may be related to the DCA-8000. Read More »
-
TSB #T-SB-0006-19
TSB: Hybrid vehicles are equipped with two types of batteries: ? Hybrid Vehicle (HV) battery ? Auxiliary (12V) battery If the hybrid vehicle is put into storage, the State-Of-Charge (SOC) of its HV battery and auxiliary battery will ... Read More »
-
TSB #CUSTOMER SUPPORT
DE: Toyota has received customer reports of certain 2019-2020 model year RAV4 HV vehicle fuel gauges displaying less than full and/or total fuel dispensed is less than expected, when the fuel nozzle automatically clicks off. Read More »
-
TSB #CUSTOMER SUPPORT
RE: Toyota has received customer reports of certain 2019-2020 model year RAV4 HV vehicle fuel gauges displaying less than full and/or total fuel dispensed is less than expected, when the fuel nozzle automatically clicks off. Read More »
-
TSB #20TE04 - RAV4 HV
DL: Toyota has received customer reports of certain 2019-2020 model year RAV4 HV vehicle fuel gauges displaying less than full and/or total fuel dispensed is less than expected, when the fuel nozzle automatically clicks off. Read More »
-
TSB #T-SB-0064-18 Rev
TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased and can never be reused. Read More »
-
TSB #T-TT-0613-20
TT: Unibody vehicles commonly have lashing holes on the under body used for securing the vehicle during logistics -The lashing holes are intended to be plugged during Pre-Delivery Service (PDS) -The plugs are: oRequired for ... Read More »
-
TSB #T-SB-0002-19
TSB: During the manufacturing process, tires are mounted on the vehicle as matched sets to help reduce conditions such as pulling or drifting. Read More »
-
TSB #T-SB-0095-20
TSB: Some 2020 model year Camry, Camry Hybrid, Corolla Hatchback, RAV4, and RAV4 Hybrid vehicles may exhibit one or more of the following conditions: ?Diagnostic Trouble Code (DTC) B15A804 is present in current or history. Read More »
-
TSB #T-SB-0021-20 Obs
TSB: OBSOLETE NOTICE September 30, 2020: This bulletin is now obsolete. Please see T-SB-0095-20. Read More »
-
TSB #T-TT-0613-20
TT: Unibody vehicles commonly have lashing holes on the under body used for securing the vehicle during logistics -The lashing holes are intended to be plugged during Pre-Delivery Service (PDS) -The plugs are: oRequired for ... Read More »
-
TSB #Toyota Safety Re
Safety Recall and Service Campaign - Technician Certification Requirements Read More »
-
TSB #T-SB-0009-19_Rev
TSB: Long-term or off-site storage requires special care to keep vehicles factory fresh and ready for delivery. Read More »
-
TSB #T-SB-0021-20
TSB: Some 2020 model year Camry, Camry Hybrid, Corolla Hatchback, RAV4, and RAV4 Hybrid vehicles may exhibit a condition in which the Remote Connect app does not accept the activation code and/or becomes inoperative, and/or the SOS call ... Read More »
-
TSB #T-SB-0008-19_Rev
TSB: An initialization procedure is required to activate the Entune? 3.0 App Suite Connect for Audio, Audio Plus, and Premium Audio head units before they are used for the first time on new vehicles. Read More »
-
TSB #Safety Recall an
Safety Recall and Service Campaign - Technician Certification Requirements Read More »
-
TSB #T-TT-0594-20
TT: Some vehicles equipped with Dynamic Navigation may experience a pop-up message notifying them that their map update service will end soon. The date that is shown could be more than one year in the future. Read More »
-
TSB #T-TT-0572-19_Rev
TT: Some 2020 model year Camry, Camry HV and Corolla Hatchback vehicles equipped with a DCM may exhibit a B15A8** DTC in history during PDS. Read More »
-
TSB #T-TT-0553-19
TT: The new DCA-8000 Diagnostic Charger may cause your facility?s Ground Fault Circuit Interrupter (GFCI) breaker to trip. A GFCI breaker can be tripped for various reasons, one of the reasons may be related to the DCA-8000. Read More »
-
TSB #T-TT-0551-19
TT: Some customers may experience an Entune? update pop-up message after every key cycle. Read More »
-
TSB #T-SB-0006-19_Rev
TSB: REVISION NOTICE February 11, 2019 Rev1: ? The Introduction and Every Two Months sections have been updated. Any previous printed versions of this bulletin should be discarded. Read More »
-
TSB #TSB-0009-19
TSB: Long-term or off-site storage requires special care to keep vehicles factory fresh and ready for delivery. Read More »
-
TSB #T-SB-0008-19
TSB: An initialization procedure is required to activate the Entune? 3.0 App Suite Connect for Entune? 3.0 Audio, Entune? 3.0 Audio Plus, and Entune? 3.0 Premium Audio head units before they are used for the first time on new vehicles. Read More »
-
TSB #T-SB-0021-20 Rev
TSB: Some 2020 model year Camry, Camry Hybrid, Corolla Hatchback, RAV4, and RAV4 Hybrid vehicles may exhibit one or more of the following conditions: ?DTC B15A804 is present in current or history. ?Red SOS LED stays on after bulb check. Read More »
-
TSB #T-SB-0064-18 Rev
TSB: The Immobilizer and Smart Key Reset is a feature that allows the registration of new keys when all master keys are lost. Once the system is reset, all previously registered keys will be erased and can never be reused. Read More »
-
TSB #T-TT-0442-17_Rev
TT: Safety Connect is a vehicle option which requires a subscription fee for the system to be active after the initial trial period. Once the subscription has expired the DCM (Telematics Transceiver) will be in an inactive state. Read More »
-
TSB #T-TT-0582-19 Rev
TT: Customer states that there is a squeak or groan noise from the steering column area when turning the steering wheel. Read More »
-
TSB #20TE04 - Dealer
DL: Dealer Inventory Procedures have been added for inclusion of a Point of Sale Disclosure Read More »
-
TSB #T-TT-0442-17_Rev
TT: Safety Connect is a vehicle option which requires a subscription fee for the system to be active after the initial trial period. Once the subscription has expired the DCM (Telematics Transceiver) will be in an inactive state. Read More »
-
TSB #T-SB-0006-19_Rev
TSB: REVISION NOTICE February 11, 2019 Rev1: ? The Introduction and Every Two Months sections have been updated. Any previous printed versions of this bulletin should be discarded. Read More »
-
TSB #T-SB-0095-20
TSB: Some 2020 model year Camry, Camry Hybrid, Corolla Hatchback, RAV4, and RAV4 Hybrid vehicles may exhibit one or more of the following conditions: ?Diagnostic Trouble Code (DTC) B15A804 is present in current or history. Read More »
-
TSB #T-SB-0158-18-Rev
TSB: REVISION NOTICE July 03, 2019 Rev1: ? Applicability has been updated to include 2020 model year Supra vehicles. ? The Hook and Loop Style section has been added. Any previous printed versions of this bulletin should be discarded. Read More »
-
TSB #T-SB-0158-18
TSB: 2020 model year Toyota vehicles are equipped with driver side floor mat retainers to secure the floor mat in the correct position. In addition, some models may also utilize retainers for passenger side and rear seat floor mats. Read More »