The frame is damage by the weather.

- Monroe, NJ, USA

The contact owns a 2005 Toyota Sequoia. The contact stated that the rear driver's side frame corroded and the suspension arms that holds the frame springs were also corroded. The contact became aware of the failure while driving approximately 30 mph, when the contact heard an abnormally loud sound. The contact drove the vehicle home. The vehicle was not taken to a dealer for inspection. The manufacturer informed the contact that the warranty had expired for the corrosion repair. The vehicle was not repaired. The failure mileage was 240,000.

- Blue Springs, MO, USA

On 1/31/20 I took possession of 2005 Toyota Sequoia, VIN [xxx] and on 2/3/20 I registered the vehicle in the state of Massachusetts. The previous owner [xxx] had originally purchased the vehicle on November 27, 2007 with 48,836 miles. [xxx]. told me that Toyota had inspected the frame and coated it. On 2/4/20 I visited Toyota of dartmouth in North dartmouth, MA 02747 for set up an appointment to have two air bag recalls addressed. Upon their review of the vehicle's Toyota service record they informed me that no record regarding the frame or frame coating exists. On 2/11/20 Toyota dartmouth took the vehicle in for the two air bag recalls and during that time I had asked for an opinion of the frame. They completed the air bag recalls and told me that they were unable to lift the vehicle. Severe rot holes on the driver side rear of frame where drag link connects to frame. Vehicle is unsafe.? they recommended I call Toyota because the frame program had expired but said that Toyota might be able to help. I called Toyota that afternoon and was told a customer experience agent would call me back the following day. On 2/12/20 a Toyota agent called me and explained that because the frame program had expired in January 2019 that there was nothing that Toyota could do. I asked to speak with someone higher up who could review the case. I was connected with [xxx], operations supervisor of customer experience at the Toyota headquarters in plano, tx. [xxx] also explained that because the frame inspection/replacement program for my vehicle had expired that there was nothing Toyota could do. I requested that he elevate the case higher to someone who could review the case on a stand alone basis. [xxx] told me that he was the highest this could go and that there would be no further action by Toyota for this case # [xxx]. information redacted pursuant to the Freedom Of Information Act (FOIA), 5 U.S.C. 552(B)(6).

- Westport, MA, USA

The recall warranty expired on this vehicle on January 31, 2017. I first received notice of this defect when I took my vehicle to the dealership for another issue I was experiencing. The dealership notified me that the recall was for rusting of the vehicle's chassis and is dangerous for me to continue driving my vehicle. I usually receive notices, as I did for the airbag recall, however, I never received any notice with regard to the recall for the vehicle chassis. I have kept the same address for the past 20 years. I attempted to call Toyota and Toyota told me I should have visually noticed the defect. The defect is the rust underneath my car, which is not open and obvious. This was also admitted by the agent/supervisor. Toyota failed to even offer 50% coverage on this recall. How can a car company allow its customers to continue driving a vehicle with such a dangerous defect that I never received notice of.

- Canton, OH, USA

Rust developed on rear driver side under fender.rear window glass malfunctioned and would not come down.

- Congers, NY, USA

I own a 2005 Sequoia 4 wheel drive limited edition. I received a letter from Toyota corporation regarding the rusting frame recall campaign on November 3,2017 and scheduled a service apt to have my frame inspected and was told the inspection takes approx. 2 hours. Within 30 minutes my truck was "ready " meaning the inspection was complete. I asked the service writer of the outcome and was told the frame was good. Nothing was written in my service order that was handed to me sign regarding findings, perforation or status of the inspection results, or that the inspection actually took place. The service writer told me verbally that another service writer would contact me in a few days to schedule a cleaning and spraying of the entire frame in a few weeks. I don't believe the tech removed my wheels to examine the frame or thoroughly inspected my vehicle. I am a 5 Toyota vehicle owner and explained that to the service writer. My service location is lakewood Toyota located in NJ, my service writer was angel burgos. I have extensive rust on my frame in numerous areas especially before the rear axle and after, in the area of the hitch assembly as well as the rear axle. I understand the criteria for replacing the frame versus a temporary covering of sealant. I understand that the frame on this type of vehicle is rusting from the inside due construction methods of the dana corporation being faulty in drainage design or manufacture. My concern that this product was not inspected properly and hastily attempted to get me out the door. This is not acceptable business practice to me.

- Pine Beach, NJ, USA

Va. state inspection failed due to left front sway bar link broken and steering rack leaking and caused bushings to come apart due to corrosion from rusting out frame. Previous work done on 04/02/17 revealed issue but no one informed us of any related recalls.

- Mechanicsville, VA, USA

My rear hatch quit 48 months after purchase. First the rear defrost/wiper/window quit soon followed by the hatch not opening at all. The issue lies with the inadequate 360 degree sealing of the rear hatch itself. Several issues have resulted from the inadequate seal: Water coming in under the hatch and mold forming inside the vehicle. Dust comes in the vehicle while driving on dirt roads. Night driving is especially difficult due to the rear wiper and defrost not working. Every 03-05 owner I speak with has an issue with the rear hatch and the internet forums are endless.

- New Milford, PA, USA

Frame has rusted through and has caused the structural integrity of the vehicle to become unsafe

- Harvard, MA, USA

I was driving when I felt the vehicle swaying side to side when I tried to accelerate past 40 mph. I pulled over and checked the tires there was no problem there, upon further investigation I noticed the frame of the vehicle had snapped and was about to break. I had it towed to a garage where I was told it was unsafe to drive, and that's where it's located now.

- Braintree, MA, USA

I took my Toyota in for an alignment. They took me out to look at it and the frame was so rusted that the swaybar had broken and was resting against the boot, which it ripped a hole in. The other side was eaten away with rust and ready to break at any moment. The whole frame from front to back was rusted. I took it to my local dealer and they declared it unsafe to drive. I called Toyota and they said there was no recall on mine. So they won't do anything. I still owe about $7000 on it and the way it is, has no resale value. I can't afford to buy anything else and shouldn't have to. This is not normal and they had to have used subpar metal on these frames. I am very fortunate that I wasn't in a wreck with dire consequences.

- Sugar Grove, OH, USA

The rear door has continued to have issues repeatedly. The handle to open the rear door broke once and had to be replaced in order to open the door. The rear wiper has stopped working severall times, and the window in the rear door has stopped working multiple times despite repeated repairs.

- West Des Moines, IA, USA

My 2005 Sequoia has the vsc off and vsc trac lights on and it causes a hesitation in acceleration - which is a significant crash hazard. I notified Toyota about this and asked if they would fix it because they recalled other years of Sequoias for the same problem. Toyota will not fix it and said that the 2005 has different parts than the years that they recalled. That is silly because the problem is there even if the parts are different. The hatchback latch has also broke and the hatchback will not open. I looked online and saw that this is another well known problem with 2005 Sequoias that Toyota refuses to fix despite the dangers if there were a crash and somebody needed to exit from the hatch area.

- Bayville, NJ, USA

The contact owns a 2005 Toyota Sequoia. When the vehicle was being inspected by the dealer, it was noticed that the frame was rusted and was unable to be repaired. The dealer stated that the vehicle was unsafe to drive and the frame needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was 160,000.

- Colchester, CT, USA

Vehicle had new front shocks put on as front shocks were rusted and seized, after inspection of vehicle, technician told us frame of the car was severely rusted and had holes in it. He felt it was very unsafe as spare tire could fall off and SUV may not take impact from a crash correctly. We phoned Toyota directly and we asked for a technician to come over to our dealer to view the SUV. We were told they could not do that, and we had to go to dealer and have dealer look at it. Dealer looked at it and took pictures and advised us that is in poor condition. They are sending that information over to Toyota. Toyota should take this much more seriously as they have had recalls on other vehicles with this same issue. I do not feel safe at all in my car and I bought this new and paid a lot of money for this vehicle. There should be a recall on this issue as this is definitely a safety issue.

- Iron River, MI, USA

Extreme rusting on vehicle chassis, spare tire mount, shock mounts, entire under-carraige. Toyota has performed chassis replacements on model years up to 2004 due to extreme rusting on the Sequoia. This generation needs to be included in recall or campaign to remedy the situation.

- Mullica Hill, NJ, USA

Rear hatch window frame and mechanism has rusted to point of failure. Rear window fell into rear hatch and would not stay closed. Vehicle taken to dealer who informed me of entire rear door/hatch rusting away from inside. Vehicle has never been in any type of collision. Dealer informed me they have seen many Sequoia's where door is rusting out. Dealer reported that Toyota is aware of issue but will to recall vehicle. I am still hoping that Toyota will rectify issue as I was informed from dealer that repair would cost $1200.

- Palatine, IL, USA

I recently purchased a used 2005 Toyota Sequoia from a dealer. The car has about 70K miles on it and looks to be in great shape inside and out. However, upon further inspection, I discovered that the entire frame of the car is rusted out with severe rust around the joints and welds of the underframe. I have lived in ne for the past 12 years and have owned my fair share of cars and trucks and I have never seen a frame that is this rusted on a fairly new car. My previous car was a 2003 Ford Explorer that I used in the snow/dirt/road all year long and the frame looked brand new when it was sold. Doing research online and talking to other Sequoia owners, it is clear that this is a known issue and that Toyota does not want to take responsibility for their lack of qc. The Toyota Tundra from the same years was recalled for the same exact issue and the warranty was extended and yet the Sequoia owners are left with expensive trucks that can't pass inspection after 6 or less years on the road. To me, this is unacceptable and I really hope that something will be done.

- Newton, MA, USA

The contact owns a 2005 Toyota Sequoia. The contact stated that the rear lift gate would not open. The vehicle was taken to an authorized dealer and they informed her that the vehicle needed a new cable for the lift gate. The vehicle was repaired, but the failure recurred twice. The manufacturer was notified and offered no assistance. The failure mileage was approximately 62,100. The VIN was unavailable.

- Mount Airy, NC, USA