At times when the driver quickly pulls out his shoulder belt the belt doubles over itself inside the guide on the door post behind and to the left of the driver's shoulder. If the driver continues to pull the belt the amount of overlap increases causing the belt to jam very tighly inside the belt guide. When this happens it is almost impossible to undo the doubled over belt (without damaging the belt) unless the trim panel and mechanism that attaches the belt guide to the car frame is removed. The shoulder/seat belt cannot be used when the belt is doubled over and jammed tightly inside the guide since the belt length cannot be adjusted. As such, when this fault occurs, the driver would be unbelted when operating the vehicle.

- San Antonio, TX, USA

Front seat passenger unfastened front seat belt when exiting vehicle and noted that seat belt wouldn't retract.

- Sacramento, CA, USA

Driver seat belt fails to retract as the strap gets caught in the opening where it retracts. It did this on rare occasion under warranty but now does it constantly. There fore the seat belt is very loose and does not restrain the occupant. The rear belts were recalled for this type of defect and were working fine at the time of the recall. This problem has been ignored by the dealer under warranty and now they simply work it free when we bring it in, despite us telling them that it recurs daily.

- Dearborn, MI, USA

The driver side seat belt sometimes fails to retract. When I pulled the belt out, it stayed out and would not retract. I inspected the area and found no interference. This happened on a sat. I drove the vehicle sat. And sun with a faulty belt. I called the dealers service dept. Told them the problem but couldn't get in for a week. In the meantime, the belt began to work again. The dealer said"bring it back when it doesn't work." I have a phobia not knowing when the seat belt will fail again. The vehicle is a 2004 Toyota Sienna. I purchased it new from the same dealer. Carmax in kenosha wi. I sent this same E mail to Toyota.

- Zion, IL, USA

: the contact stated the front passenger side seat belt retractor locks up while in use. The seat belt must be released, and then put back on. The dealership determined this was a safety feature for child safety seats. The dealership stated it was illegal to replace the front seat belt assembly.

- Boca Raton, FL, USA

The way the middle seat is located and designed it has a split in the plastic. The seat belt gets caught in the split, and as a result, the seat belt fails to retract. Dealership replaced the seat belt, but problem still exists.

- Santa Monica, CA, USA

Passenger's side seat belt in middle row of the captain chair will not retract. Dealer is aware of the problem. Driver is concerned because he picks up and Transport children from place to place.

- Edmond, OK, USA