A severe crack formed around the full circumference of tire near where the sidewall joins to the tread. The tire started leaking air and the severe crack was found while mounting the spare tire. The crack was present on the inside of the tire and therefore not visible until the wheel was removed. This crack was on its way to a catastrophic failure of the tire. The crack was found at 23500 miles on a tire with claimed treadlife of 60,000. This was the tire sold with my new 2019 Tacoma: Goodyear Wrangler AT Adventure with Kevlar 265/70R16. The Toyota dealership said to take the problem to GY but GY has no recall on this tire and I do not want any new GY tire if offered a replacement.

- Bellingham, WA, USA

I have 4 Toyo Open Range A31, P25 45 R16 Tires on my 2019 Toyota Tacoma. They were new tires on the 2019 Tacoma when I purchased it new from the Toyota Dealership in August 2019. 4 tires on the Tacoma and 1 Spare tire. I noticed over he life of these 4 Toyo tires they wore rapidly and chunked and lost chunks of rubber in the tread areas. I always rotated and balanced my Toyo tires as required. I had yearly front end alignments done. 2020 and 2021. I do an air check every 30 days. There are no mechanical problems with my 2019 Toyota Tacoma. When these Toyo Open Range A31 Tires were new they started out at 11/32 tread in August 2019. As previously noted all 4 tires wore rapidly and chunked, rubber loss in thread. By October 2021at 19,500 all 4 Tires were at 5/32 closer to 4/32 and had Chunking Rubber loss in threads on all 4 tires. These tires lasted 2 years and 19,500 miles and must now be replaced. Toyota does not warranty the Toyo Tires and told me to deal with Toyo Tires directly. Toyo Tire has been challenging to deal with and are only offering 25% off towards a purchase of 4 new Toyo Tires. This in Unacceptable. Its reasonable for a consumer to expect more than 19,500 miles or 2 years from tires. The Big Picture and Major Concern is Safetey !! These Toyo Open Range A31 Tires Wore Out and Chunked with Rubber Loss in Thread by the time they were 2 years old and by the time they reached 19,500 miles. For safety reason I must replace these tires. I respectfully request that NTSB investigate this serious safety matter.

- Tucson, AZ, USA