I brought my 2003 Passat glx sedan into dealership because car was jerky when the brakes were applied. Car has 41,214 miles on it, 90% highway. Dealer informed me that the rear brake rotors were warped and had to be replaced along with pads. Dealer informed that Passat rotors could not be turned in lieu of replacement. From other complaints I view, it appears this is a defect in the rotors.

- Flagstaff, AZ, USA

My 2003 Passat has approx. 34,000 miles. The brake rotors had to be replaced twice -- once at somewhat over 12K miles ago, and the other very recently. The most recent time, we were told not to drive the car any further (by the dealer) because it was unsafe to drive. The first time, VW paid for the repair, this time they would not. I believe there is a safety problem, one which I am afraid will happen again. Please note...I do not have the exact date in the field below.

- St. Louis, MO, USA

At 44,400 miles and just 4,000 miles after fuel pump replaced the new fuel pump failed on my 2003 Passat wagon. Both incidents occurred while driving the car on high traffic Suburban Washington DC streets. There was no warning and car came to an abrupt stop without time for me to signal the cars behind me. This is in addition to having to replace both front and rear rotors at about 20,00 miles as well as control arms. This seems to be an inordinate amount of service in only 3 years and 44,000 miles!

- Gaithersburg, MD, USA

: the contact stated while traveling up hill at 25mph the vehicle sputtered and stalled. The vehicle was towed to a dealer where it was determined the fuel pump needed to be replaced. Previously the contact experienced braking problems while traveling at high speeds. There was vibration and grabbing in front end of the vehicle when braking. The vehicle was seen by the service dealer four times. The front rotors, the rear rotors and both control arms were replaced. The problem was corrected by the replacement of these parts for twenty thousand miles and has now returned.

- Gaithersburg, MD, USA

Bought new a VW Passat, glx, V6 in May 2003. It has 18500 miles on it. I have had three sets of rear rotors replaced because they have warped. The last set were replaced in March 2005, and I am experiencing the same problem today, and have an appointment at the dealer to have them replaced again. The rotors warp badley, the car, especially at highway speeds shudders when the brakes are applied and does not stop adequately.

- East Rockaway, NY, USA

Vibration from steering wheel when braking and uneven stopping. Dealer found warped front rotors. I found this problem rather unusual as we drive the car to and from the station daily and we only have 29,000 miles. Dealer had to replace pads and both front brake rotors. VW refused to cover under warranty. I feel the car is not safe due to these constant brake problems. I have had other brake problems with this car, the dealer has replace the rear brake pads and then rear pads and rotors under warranty.

- Hillsborough, NJ, USA

2003 Volkswagen Passat sw developed problems rear brake pads and rotors.** answer required***. the consumer stated 8,493 miles later the brakes began to squeak. The consumer took the vehicle back to the dealership where it was discovered the rear brake pads and rotors were damaged again. The head light bulb was replaced.

- San Francisco, CA, USA

Design defect in brake rotors.

- Oracle, AZ, USA

Vehicle is experiencing problem with excessive wear of front brake rotors and pads. Both the rotors and the pads had to be replaced on two separate occasions. The first time at 9,000 miles, and now at 17,000 miles. The problems was causing the vehicle to vibrate and make a roaring noise when braking. Consumer anticipates the problem may recur again.

- Brick, NJ, USA

VW Passat - brake rotors warp, causing dangerous braking situation. This is a common problem known by VW, and complained of by thousands of Passat owners (many, many sites and complaints on the internet, and mechanics). VW refuses to fix this problem.

- Studio City, CA, USA

Under normal driving conditions, and 90% highway driving, the vehicle's front and rear brake pads became severely worn out in approximately 10,000 miles of driving. After the first all 4 brake pads were replaced, in another 10,000 miles, the vehicle's right rear brake pad fell off the vehicle during street driving. All 4 rotors, 4 brake pads, and 2 rear calipers became severely damaged and had to be replaced. Vwoa made an exception, and paid for the rear brakes, rotors, and calipers.

- Jersey City, NJ, USA

Under standard daily driving 50/50 local and freeway miles, rear brake rotors warped before the car had 14,000 miles driven. Rear break pads are at 6mm which I am told is just less than 50% of maximum. Also been told vwoa will not replace rotors under warranty until pads are at 2mm. Warped rotors cause pumping and potentially unstable driving under heavy breaking.

- Lake Oswego, OR, USA