The contact owns a 2016 Volvo XC60. The contact stated that while operating the vehicle, there was an abnormal burning odor inside the vehicle. The "Low Oil" message was displayed. The vehicle was taken to the local dealer to be diagnosed and the contact was informed that the piston rings were faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 5,500.

- Orlando, FL, USA

Purchased the vehicle sometime in 2021. Been dealing with oil consumption issues since then. Always maintained the vehicle per manufacturer recommendations. At first I had to top off the oil here and there and didn-??t think much of it. Forward to Sept 2023 I have to add a quart every 500 miles. I began to research about the oil consumption problem and learned the following: There was a letter that was sent out to Volvo owners in Feb 2023 about a service bulletin regarding an oil consumption test and if the vehicle fails the oil consumption test then Volvo will replace piston rings or engine. They would also extend the warranty. The free oil test applies to vehicles within 8yrs or 100k. I never received the letter because I was the second owner. I called Volvo North America and they confirmed that the previous owner was listed on their end and that previous owner must-??ve received the letter. If I had received the letter in Feb 2023 then I would be within that 8yr time frame and that would qualify me for repairs. I asked Volvo for grace to be included in the free oil consumption test. They said no because I was outside the time frame which was 3 months. Only 3 months! I never received the letter and I had to research on my own. I never received that letter and if I had received the letter then I would-??ve taken it immediately to Volvo for the free oil test consumption. I believe this is a serious safety problem because at one point the engine will seize and could stall on the interstate due to the excessive oil consumption. Please look into this safety issue. A sudden seizure of engine leads to a sudden stall at interstate speeds which can cause a major collision and I know NHTSA is all about safety for operators of vehicles. Thank you!!

- Lewiston, ID, USA

My vehicle sustained catastrophic, permanent engine failure while I was driving, in two-way city traffic. Cars backed up behind me, I had difficulty opening my door because of oncoming traffic, and eventually was able to push it (and get help pushing) to the intersection gas station. No warning lights appeared on my dashboard before, during or afterward. Independent service center reports no battery or alternator issue - engine is locked up. No idea why. The vehicle is out of warranty. I will have to pay to replace the engine myself, ~$7-8,000 in order to sell it at near KBB value. So disappointed in Volvo.

- Mt Pleasant, SC, USA

Volvo XC60 is burning oil and putting off a smell. Approximately every 500 miles I am prompted to put in another quart of oil. No signs of leaking. Took the car into a mechanic to inspect and was notified this is a known Volvo problem and I'd need to take it to a dealership since there are several TSBs on it with this known issue. Issue has been progressively been getting worse since I purchased the car a few years ago.

- Greenville, NC, USA

The engine is using a quart of oil every 1000 miles, There is no leaks or pools of oil on the ground under the car. This is one of the engines identified in a class action lawsuit filed for this same reason.

- Allison Park, PA, USA

This car has excessive oil consumption and burns oil because the piston rings are faulty. Eventually can cause the engine to stop working and put lives on the road in danger. This was proven in a class action lawsuit against Volvo and they extended the warranty to 8 years or 100,000 miles however some cars are over the 100,000 miles and are still needing to add oil every 2-3 weeks. The low oil light started coming on about 80,000 miles. Had it in for repair but the dealership didn't know what was wrong with it.

- Wheaton, IL, USA

When stopped at a stop light, have to hold brake down in order to keep the car from driving as the rpms are revving up and down, causing the car to want to move and when in park revving so high that it went into red and caused the check engine light to come on and I had to turn off the vehicle. Also the gas tank filler tube cloggs up easily and has to be dropped in order for the tube / vents to be cleaned out or replaced.

- Niota, TN, USA

"The contact owns a 2016 Volvo XC60. The contact stated that while driving at 25 MPH, the oil warning light illuminated. The contact stated that she refilled the oil when she arrived at her residence. The contact noticed that the vehicle was consuming an excessive amount of oil and she was refilling the oil each 4-6 weeks. The vehicle was taken to the dealer, Bobby Rahal of the South Hills, who diagnosed that the piston rings needed to be replaced for more than $4,000 or the dealer stated that adding oil to the car every month would be a cheaper and not unsafe solution. On January 1 while driving on the highway, far from home, in the rain and fog with 3 children in the car, the engine started riding rough. The vehicle was driven cautiously home and taken to the independent mechanic specializing in Volvos who diagnosed that the engine had failed and needed to be replaced. The independent mechanic said he has seen 4-5 Volvos this year with the same problem, and that there is something wrong with the 2015 2/5 engine for this car, but prior to that year, it has been a good engine, and since that year, it has been a good engine. The vehicle was towed to the dealer where it was purchased, Bobby Rahal Volvo of the North Hills, and the diagnosis was the same for the 6 year old car needing a new engine for more than $16,000. Since the car was purchased in November 2020 for $18K+, the customer is wondering if the dealer that sold the car and the dealer that was asked about the oil issue knew the car engine was likely defective, did not tell the contact and put the contact's family in an unsafe situation. The manufacturer was notified of the failure, and the contact is awaiting a response. The vehicle has not yet been repaired. The failure mileage was approximately 76,000, after less than 8,000 of vehicle ownership."

- Pittsburgh, PA, USA