I was driving and the van suddenly lost all propulsion. Brakes and steering and dash lights functioned, but there was a red turtle icon and error message about a system failure. The accelerator pedal did nothing at all. I was able to coast off the side of the road to a place to pull over, but that could have been a terrible accident if I lost power like that on I-95 or any other major highway. My husband came and we switch cars (kids, car seats, etc) and he was able to get the van to start after half an hour. It had check engine lights on for things, but the dealer said to bring it in because it was drivable again. Despite brining it in as told, with check engine lights on that they saw, they said they could not reproduce it and couldn't find codes for the check engine light (even though I pulled them from my own OBD2 diagnostic plug tool and took photos of the codes) and eventually said I have to take the car back, despite no cause or resolution. These cars have known faulty battery issues and a large number have been replaced already, but Chrysler isn't authorizing dealers to do that unless they can reliably reproduce the failure. Very frustrating to see Chrysler not go the route of other manufacturers who sourced their batteries from the same plant and ended up proactively replacing them for consumers. While Chrysler's many recalls for the hybrid battery system software have probably made it detect faults earlier to try to prevent fires, they are still known to happen, but now in addition to a fire risk, we also have a car that has a much higher chance of just losing power while driving due to over sensitive battery monitoring, or a plain old faulty battery that just isn't faulty 'enough' for Chrysler to authorize a replacement. So frustrating and dangerous.

- Fredericksburg, VA, USA

Vehicle lost all internal communications while driving. During this incident propulsion was lost, turn signals, hazards, power brakes, power steering, all electronics except speedometer failed. I was unable to put indicators on during this incident outting others at risk. It appears hazards and turn signals are CAN communication which is absolutely insane and a severe design flaw.

- Bucyrus, KS, USA

After safety recall 73B was performed on my 2018 Chrysler Pacifica Hybrid on 08/25/2025, the vehicle's check engine light illuminated on 09/09/2025. I was inundated with multiple failure lights including; check engine, service electronic throttle control, service hybrid electric vehicle system, blind spot alert, and I felt like I lost power steering. I was unsure if the van was safe to drive, but was able to get it to the dealership. They were able to pull multiple codes. Including the one for the check engine light. They decided that the problem was related to the ABS control module. They replaced it and the van has been fine so far. It seems these error codes are widespread after performing recall 73B. Many other customers are complaining of the same thing. I believe these errors are from the testing to the High Voltage battery, and their 'software fix'. It's not safe to lose your power steering while driving. It's not safe to have multiple error codes continuously going off while operating the car. It's not safe to have a family car that we have been told twice to not park in the garage, charge, or park near a structure. This is their second attempt at 73B, and overall the second fire recall. My van and high voltage battery are definitely available for inspection.

- Simi Valley, CA, USA

Soon after having recall 73B completed on my 2018 Chrysler Pacifica Plug in Hybrid the check engine illuminated with DTC P0BBE. The vehicle no longer accepts a charge through the charge port and is now indicating there is an error with the high voltage battery. This issue has happened within 147 miles of driving. I can no longer use the vehicle as it is now in limp mode.

- Fresno, CA, USA

On Thursday, July 3, we were on our way out of town and had just gotten on a highway when I smelled something burning, saw smoke (we thought was steam at the time) coming from the hood and heard the engine making a grinding, or rattling noise so we pulled over immediately. My husband got out of the car to start to take a look when another vehicle who had just passed us backed up and motioned frantically saying -??Your car is on fire!-?? So we got out and looked under the front of the car and sure enough, there was liquid spilling onto the ground and fire coming from underneath. So we quickly got away from the car and called 911. Another gentleman who had been going West also stopped to make sure everyone was okay and was also calling 911. Within 10-14 minutes the front of the car was totally engulfed in flames.

- Round Hill, VA, USA

My 2018 Chrysler Pacifica has confirmed internal engine damage-?"scoring in the cylinder wall-?"diagnosed by an authorized Chrysler dealer. This occurred with no abuse or neglect, and the failure is consistent with many documented reports involving the 3.6L Pentastar engine. Chrysler is aware of premature failures in this engine across various models, but has denied goodwill assistance in my case despite providing it in others. I have involved the Washington State Attorney General-??s office (File #[XXX]), and I believe this should be part of a broader investigation into systemic engine defects that pose safety and financial risks to consumers. Mileage at failure: 77,000 Diagnosed by: Renton Chrysler Dodge Jeep Ram (WA) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

- Federal Way, WA, USA

User bought 2018 Chrysler Pacifica PHEV in 2019. User had no issues with the vehicle, all recalls completed, until the completion of NHTSA Recall 22V-077 (Chrysler recall 73B). Recall 73B was completed on 13 Feb 2025 with approx. 103,000 miles on the vehicle. The recall included flashing the HV Battery Pack Control Module and a "soak" of the HV Battery to determine battery health; servicing dealer reported recall successful and battery health test found battery health was good. Approximately 1 week following the recall, the check engine light came on and stayed on for a couple of days and "self cleared". Several weeks later, the same sequence of events as above occurred once again. On 9 April, following a full charge overnight, I started the vehicle and the gas motor immediately started, check engine light illuminated, "turtle mode" icon appeared, and I was notified that "Vehicle Speed May Be Limited". After completing the short trip in "limp mode", I restarted the vehicle and only the check engine light was visible, van ran as normal. The following morning, no issues at all. Took the van to be diagnosed and was told an actuator in the dash needed replaced; actuator replaced. Five days later, once again, started the vehicle and the gas motor immediately started, check engine light illuminated, "turtle mode" icon appeared, and I was notified that "Vehicle Speed May Be Limited". Took the van to the dealership, at 106,163 miles, for diagnosis and have been told that the HV Battery is now dead and must be replaced. Dealership quotes $16,000 to replace HV battery and Stellantis (Chrysler parent company) would not deal with me as the battery warranty expired at 100,000 miles. Many other complaints like this following the 73B recall reported to NTHSA, this does not seem to be a coincidence. I had ZERO issues with this van until this recall was completed.

- Milton, FL, USA

My transmission went out at 108,000 miles. 6 out of 9 gears went bad. Had it replaced and it went out again 2 weeks later. The transmission dropped while I was driving but luckily I was pulling into a parking spot. Had to have another transmission installed. This scared me because my kid was in the car and was on the expressway a couple of minutes before it dropped. Also, the oil filter housing was cracked and I know this is a common problem because it is made of plastic.

- Temperance, MI, USA

Our vehicle is always kept in a garage and rarely parked outside for extended periods of time (not a vehicle used for transportation to and from work on a daily basis). We had our check engine light come on. This resulted in us using our second vehicle for several days before determining days later that the check engine light was still on. We took it in and they said the stored code was for a small evap leak and said it was likely due to cold temperatures and ice build up around the edge of the vent that blocked the flap from opening. As mentioned, this vehicle was in a garage for several days leading up to the check engine light appearing and for several days after the initial appearance. When I asked the dealership doing the repair what we could do to prevent this from happening again they suggested we avoid having the vehicle parked outside in the cold. This seems to be an issue that should be handled by Chrysler as opposed to me as the consumer and causing me to pay $217.31!

- Riverside, MO, USA

Had vehicle towed to Orange Coast Chrysler Jeep Dodge and Ram 11/4/24 due to vehicle being unable to start. Error message in vehicle indicated "Service Hybrid System"" and "Service Charging System" Vehicle was left at dealership pending inspection. 12/5/24 I contacted dealer asking for update and was told Chrysler STAR case was opened for vehicle for hybrid battery. No further information was provided. 1/5/25 I contacted dealer again for update. Was told Chrysler engineer had attempted diagnosis/ repair of vehicle including application of current recall 73B (NHTSA Recall ID 22V-077) but was unsuccessful. Was told another Chrysler engineer must be brought in to assess/ repair vehicle.

- Ontario, CA, USA

I bought my 2018 Chrysler Pacifica limited about two years ago. It-??s been the worst decision I-??ve ever made. I have just about a 3% rate and with the amount of issues these things have I-??m so far upside down it-??s not even funny. This car with all of its known issues is depreciating faster than I can pay for it. I currently have about 129,000 miles on it. I couldn-??t get rid of this thing if I tried. The Chrysler dealership I service it with said they would give me $4000 IF they were willing to buy it back. The engine build company my mechanic uses says they won't even build these engines at all because of how many issues they have. So no option other than to buy the exact same engine is has now through Chrysler and know it will do it again. I-??m having stalling/accelerating issues (shop can-??t figure it out, kids cry when it stalls in traffic.. I've been in for it about 9 times to two different place) Oil cooler housing unit replaced last year (taken it back in a few times for ongoing leak, now need a head gasket) Head gasket Batteries galore Ongoing start stop issues My AC went out the month I bought it (leak in the lines near the rear) 3000k to fix The shop says it needs lifters, cam shafts and rockers (might as well do the engine if I had the extra money after paying off the rest of the repairs) My heated and cooled seats have stopped working numerous times Dash comes on and off when it wants Back up camera stays on the screen while I drive as much as it doesnt My rear washer fluid sprays INSIDE the car onto my kids Rear power seats stopped working multiple times now Get in to head to work and it just won-??t start-??. Have to basically play a video game with the controls and key fob to miraculously start it up Starting to rust already We have owned 2 Durango-??s, 2 dodge rams, a Chrysler Sebring and now this. Clearly we support Chrysler but after this my husband switched to a ford truck and I will be going back as soon as I can if this isn't resolved.

- Fort Wayne, IN, USA

While driving a message came across the dash to "service charging system" and then a second message appeared that said "speeds limited" and the vehicle slowed to 44mph entirely out of my control.

- Charles Town, WV, USA

Piston Number 3 is misfiring which is the from an error code. Replaced the piston 3 twice and now coolant is leaking into the engine which cause the coolant to leak into the engine. This is a safety risk since the car does not give a warning until there is no more coolant in the car which can cause a fire while driving. The issue was shown twice and confirmed by 2 independent mechanics and the dealership. The vehicle has been inspected and checked out by 2 independent mechanics and the dealership. It first appeared Feb 16 2024 when the check engine light came on and the next Monday the car lost coolant. The car also shook violently when it was started.

- Toms River, NJ, USA

The #5 cylinder keeps having a misfire sometimes causing failure of the vehicle to get up and move when needed in an emergency Situation this being a family van make even putting children in danger at times. After inspection by myself a Mechanic that even taught College Automotive repair, I have also taught Jet engine repair I find this concerning. Is what is happening is the head gasket is leaking coolant into the #5 Cylinder and we all know water will not admit a spark. Rust can be seen on the Valves and top of Piston cylinder upon inspection. This is a well know issue across the United States and Chrysler Dealers and manufacturers, their mechanics, parts and service departments also know this. This is poor workmanship inferior parts. But the most concerning is not being able to get a response out of the vehicle to get out of the way in an emergency situation and that the owners of Chrysler Corporation do not care. With the cost the consumers paid for these Vehicles it should not have to fall on them due to the inferior parts and workmanship of the manufacturing Company. The Average Consumer cannot afford to fix this issue, and some are still paying for their Pacifica's Immediate action should be taken with this problem as many Babies, Children and adult lives are being put at risk. I would recommend to stop driving these vehicles immediately until the problem is resolved. Accident waiting to happen possibly causing bodily harm.

- Haughton, LA, USA

My vehicle lost the ability to accelerate when driving on a busy two-lane street. I was able to coast to the side of the road, but the vehicle would not move forward or backward even though the engine was running. This was the fifth time this condition has occurred, and I had the 03A Loss of Motive Power recall service performed during Summer 2023. The vehicle had to be towed - luckily nobody was directly behind us so an accident did not occur. The vehicle is currently being evaluated by the dealership for further repair. The check engine light is illuminated, but no other warning lights are illuminated at this time.

- Lakewood, OH, USA

We began having major issues with our van in October 2022. There were numerous incidents of loss of power and sudden increase in temperature gage. We kept fluids checked. Kept oil changed on time. We reported this to the dealership multiple times before they agreed to fix under warranty. Even after fixing factory recall (which we were charged for by the dealership) and then replacing batteries, we continued having issues with loss of power and surge in temperature gage. July 8th of 2023 engine light came on and temperature gage shot up, van stalled at the intersection. I had My self and FIVE kids in the car. This was accompanied by a sudden loss of fluids. We had the van taken to another repair shop who then told us the head gasket was blown. This happened just 4 miles after our warranty lapsed. We had to have the entire motor replaced out of pocket. More than $8,000 in repair costs so far and the van I still making noises and not driving correctly.

- Cedartown , GA, USA

Our engine has stalled while driving the vehicle at least four times since July 1. The engine begins to shudder, and the car will not accelerate, and then the engine completely dies. After it happened today, it was not possible to restart the engine or put it in gear. My and my family's safety was put at risk because the vehicle was inoperable. Three times this happened on major interstates with traffic moving at high speeds. I had to move my children and their car seats into another vehicle while traffic passed. We have had the vehicle in for service at least three times, at least twice at Chrysler dealers. The problem has not been reproduced (yet) but this latest time it completely disabled the vehicle so expect they will see more of the problem now. After the engine cuts out, we get an electrical warning light that flashes briefly, plus a check engine light, and a message that instructs to move the gear shift to P to start the vehicle and another that warns that the Start/Stop system needs service. We have had these all serviced, the fuel pump and battery replaced, and have been told the problem is resolved and yet it keeps happening.

- Cleveland, OH, USA

Cylinder head inside the engine has a Crack with antifreeze leaking into the engine. I had been driving the car prior to being able to make an appointment at the dealership. Luckily there was not a crash due to this.

- Batavia, IL, USA

The transmission shifts hard when traveling around 14 mph then will jerk (like being rear ended), slows down then accelerates on its own. I'm afraid it will cause an accident. Chrysler said it is supposed to work like that and nothing is wrong with it. I have had 3 diagnostic tests done it and it shows nothing is wrong.

- Erie, PA, USA

Coolant leak as well as the other problems that I reported.

- Enon, OH, USA