The contact owns a?2015 Dodge Grand Caravan mobility vehicle. The contact stated that while driving at an undisclosed speed, the driver's side rear wheel air bag was deployed. The vehicle was driven to the contact's residence. The contact stated that the vehicle had been converted into a mobility vehicle by Compacity Trucks. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and unofficially agreed to cover the cost of the repair. The failure mileage was approximately 95,000.

- Walbridge, OH, USA

The driver side automatic headrest randomly deployed while we were driving down the highway. Thankfully the driver was leaning forward and did not receive the full force of the blow. It appears the plastic brackets inside are shattered. I called our dealer, their response was basically tough luck. I am trying to find a non-AHD replacement headrest as our teenage son drives this van and unexpected deployment can lead to concussion, cause accidents, etc. If Dodge is aware of the issue, why has no recall been issued?

- Two Rivers, WI, USA

The contact owns a 2015 Dodge Grand Caravan. The contact stated that while driving at an undisclosed speed, the passenger's side air bag warning light illuminated. The vehicle was taken to the dealer to be diagnosed and the contact was informed that the passenger's side air bag needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 93,164.

- Beaufort, SC, USA

transmission went totally out, sliding door makes loud buzzing noise when unlocking and locking air bag light on dash wont go off

- Milwaukee, WI, USA

The front head rests contain a safety device that extends the head rest to support the head during a crash. We were unaware of this feature until the passenger head rest burst over a year ago. That was reported in a seperate incident report. We are still waiting for Dodge to repair the passenger head rest. Within the past couple weeks, the driver head rest burst open, while we were not in the vehicle. We did not notice the head rest was burst until my wife saw it from the side when I was driving it. She normally drives the vehicle.

- Bastrop, TX, USA

I just made this same report but with my son's Dodge 06 VIN number. Ignore that report!! for my Dodge 2015 Dodge Grand Caravan here is my report: Passenger side air bag exploded. Luckily no injury. Vehicle was not moving. I didn't even know it could do that! I'd like this fixed. Also, two leaks in engine. Oil leak/transmission leak. Is this normal" leaks are ongoing. Another thing: Noticing headlights getting slightly dimmer, then brighter, at night as if some sort of electrical problem" this happens during driving and not driving.

- Bolingbrook, IL, USA

Front passenger active headrest system deployed with no explanation. The vehicle was being driven normally in a parking lot and the headrest just went off.

- Phoenix, AZ, USA

Front seat active head restraint deployed on its own. Vehicle was parked with nobody inside when it happened. I did receive a letter in mail that it is an issue and letter had been submitted with this.

- Lake Havasu City, AZ, USA

While my husband was driving the passenger side headrest deployed for no reason! I happened to be sitting in the seat at the time and thankfully it didn't hurt me but it scared the crud out of me!! we were actually only going about 5mph as we were coming out of the parking lot of a chic-fil-a.

- Patterson, LA, USA

I took my car in for service to fix air conditioner not working they fixed the front and rear evaporators. I picked up from dealer drove T mins down the road and while driving both the driver and passenger head ready air bags deployed. Almost caused an accident not to mention hit me in the back of head while driving down major hwy 41 in fla. I also have daughter in wheelchair it's a converted wheelchair van had to be towed back to dealer and now driving non wheelchair accessible rental..my air conditioning was also whilstling after just being fixed. I was only doing about 30mph.

- Nokomis, FL, USA

The electric controls are going haywire when van is turned on nothing will function than the rear defroster comes on nothing else works then the air comes on and cool air on drivers side heat on passenger side then some cool then heat and I have a lighting bolt simble on the dash and van was hit head on while park and the air bags did not deploy

- Dubuque, IA, USA

The headrest deployed while driving down a residential street.

- Keizer, OR, USA

The driver's side headrest deployed unexpectedly. My vehicle was parked in my garage. The car was stationary, not running and had not been in any kind of collision. When I inspected the inside of the headrest, the plastic brackets that hold the metal pin were compromised. The metal pin is still in place, but the plastic prongs that were supposed to hold onto the pin to keep the headrest in place both failed. One cracked and is partially attached. The other prong came off completely. I believe the plastic broke from being under prolonged tension. Why would something that is designed to be a safety feature be made out of something as flimsy as plastic? I'm so thankful that I wasn't driving when this incident occurred because it could have caused serious injuries. There are many other reports of Dodge customers having this same issue. The active head restraint (ahr) system should be recalled due to safety concerns. The headrest should not deploy by itself. Unfortunately, from what I have read, Dodge is claiming no responsibility and the issue is not covered under warranty. The repair is around $900, but most people can't afford that and don't want to pay it anyway because the problem could happen again. Dodge should be repairing these headrests at no cost to the customers.

- Hurst, TX, USA

The contact owns a 2015 Dodge Grand Caravan. Passenger side headrest unit erroneously deployed. Passenger sustained head injury cause of the failure was unknown the contact stated that while at a stop light the passenger side active headrest unit erroneously deployed causing a head injury to the passengers. No medical treatment was required. The cause of the failure was not yet determined. The local dealer was not notified. The manufacturer was notified of failure. The failure mileage was 128,000.

- Mansfield, OH, USA

I had a minor collision where a car backed into me as I was driving forward at a slow rate of speed. Minor body damage to both cars. However, all of my front air bags deployed. Insurance, the estimator, everyone, is shocked they all deployed, or that any deployed considering how minor the collision was. My van, unbeknownst to me, had a knee airbag. The knee air bag exploded against my shins, causing extensive bruising, cuts, and gouges where the cover and casing shot out onto my legs like shrapnel. It felt like a bomb of sharp glass went off against my shins and knees, there was blood all over the place. I had to go to the er to get the wounds cleaned up and they're still trying to heal weeks later. Consumer stated car is at insurance auto auctions. Photos attached. 'parts of this document have been redacted to protect personally identifiable information pursuant to the Freedom Of Information Act (FOIA), 5 U.S.C. 552(B)(6).'

- Starke, FL, USA

On this 2015, Florida based, Dodge Grand Caravan with 58,640 miles, the passenger side active head restraint deployed with the car parked in the driveway and no one in it. It could not be reset as the thin plastic bracket that held a metal restraining bar in place disintegrated under the pressure of the deployment spring and released. In fact it appeared that multiple plastic parts had broken. Checking the internet, this appears to have happened in hundreds of other vehicles in multiple models and model years and Dodge/Chrysler has made no attempt to fix the problem or warn the owners. There are also at least two separate law firms pursuing class action lawsuits regarding this. There also appear to be hundreds of complaints on this site. If this happened on the driver's side while the car was in motion, an accident could have resulted. The Dodge dealer said they have no obligation to fix this and that replacing each head restraint would cost close to $900. They also could not say the driver's side head restraint wouldn't also deploy unexpectedly. One wonders if there haven't already been significant or even fatal accidents related to this. Getting hit by the headrest would cause injury alone this appears poorly designed. The idea of putting a thin plastic bracket under constant strong spring pressure for years is just asking for trouble, especially for vehicles in Florida where temperatures in parked vehicles can remain well over 120 all day. How can thin plastic be expected to take this for the life of the vehicle" these parts should be metal. I pushed the deployed headrest back together and secured it with two cable zip ties. As Dodge can't tell me if the other headrest won't also deploy, I have also secured it with cable zip ties to guard against its unexpected deployment. Where is the NHTSA in all this" at least change the design.

- Port Charlotte, FL, USA

The passenger seat headrest deployed while the car was sitting in my driveway sometime between Sunday evening (5/26) and Tuesday afternoon (5/28). The car had not been involved in any accidents prior to or during this time frame. My husband and I had driven our 2015 Dodge Caravan on Sunday. I was in the passenger seat. I am 8 months pregnant. On Monday, we did not drive the van. On Tuesday around 12 noon, with the car still in the driveway, I noticed that the passenger side headrest had basically exploded. I called the dealership where I had bought the van (a Chevy dealership that had received it in a trade-in). They had never heard of such a thing and told me to bring in the van immediately. That afternoon, I (reluctantly) drove the van the 25 miles to the dealership, leaning forward as far as I could in the driver's seat in case it were to deploy. The dealership called me today, Wednesday 5/29, to inform me that Chrysler refuses to accept any responsibility for the defect, and would charge nearly $900 to cover the new headrest. Chevy generously offered to cover half the cost since I am a repeat customer, and they saw this as a severe safety issue. I declined, not wanting to spend over $400 to replace a defective part with another part, especially since this would not ease my worries about the safety of the driver's side. I plan to zip tie the headrests with multiple zip ties. There's no other solution at this time. Even if I were to pay to replace the broken passenger headrest, there is no guarantee at this point that either headrest is safe and will function as intended. I would not feel safe driving with one of these headrests ever again. I would trade in the vehicle, but I am worried this will cause significant financial harm since I only just acquired the vehicle in October 2018. Also, I will be having a baby in 1 month and have no money to spare.

- Mooresville, NC, USA

The active-restraint head rests deployed while driving through a parking lot making a loud bang that sounded like a gun shot. The deployment of the active-restraint head rests was a distraction to the driver and if anyone had been in the passenger seat it could have caused an injury. The van is still under warranty and the dealership could not tell us if reseting the headrest would be covered under our warranty or not.

- Sneads Ferry, NC, USA

2015 Grand Caravan my wife michelle O'connell drive in pulling into our driveway and the headrest restraint system airbag deployed striking my wife in the back of the head van was towed to black Chrysler Dodge Ram in statesville North Carolina to be repaired my wife sought medical attention Chrysler then demanded the vehicle be inspected by an independent inspector to see if it was in an accident after the report was done in received Chrysler notify the dealer do not touch the vehicle the report said the vehicle was flawless which we knew that then Chrysler's lawyer contacted us and said we are not fixing your vehicle until you sign paperwork absolving us of any liability which they know they're liable cuz the van is in perfect condition we are reporting this because we believe there is a known defect by Chrysler and they're trying to sweep it under the rug they had a similar incident where they had to recall 880000 vehicles in 2013 for the exact same issue Chrysler made of direct threat saying we're not going to fix your vehicle and leave it on registerable because of the airbag for inspection and unusable unless you absolve us of liability the vehicle was only traveling less than 2 miles an hour pulling into our driveway it was a driver's side headrest restraint at deployed

- Mooresville, NC, USA

The contact owns a 2015 Dodge Caravan. While driving 40 mph, the air bags deployed without warning or impact. The front driver and passenger air bags did not deploy. The vehicle was taken to the dealer, but was not repaired. The manufacturer was notified of the failure. The VIN and failure mileage were not available.

- South Webster, OH, USA